2006 Toyota Sienna body problems

Filed Sep 2, 2026 · Body · 218,000 miles · OH

The contact owns a 2006 Toyota Sienna. The contact stated that while the vehicle was at the dealer for a recall repair, the mechanic discovered large holes in the center of the subframe caused by rust. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 218,000.

Filed Aug 13, 2024 · Body · NC

The contact owns a 2006 Toyota Sienna. The contact stated that while the vehicle was parked, the liftgate was opened and raised; however, the liftgate failed to remain open and raised as intended. The contact stated that when the liftgate was raised, the liftgate independently fell due to faulty liftgate struts. The vehicle was not diagnosed or repaired by an independent mechanic. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to report the failure to the federal safety agency Hotline. The failure mileage was unknown. The VIN was unavailable.

Filed May 19, 2020 · Body · 51,300 miles · OR · 1 injury

Liftgate failure date 5-8-2020 mileage 51,300 miles my 2006 toyota sienna limited, was purchased new in 2006. The van is meticulously cared for with all service done on time at the toyota dealership. When not in use, it's parked in a climate-controlled garage. On or about 2008, recall 80c was done at the toyota dealership. The liftgate malfunctioned on 5-8-2020. The liftgate fell about ten inches after it reached the fully open position, at which point the power motor engaged and powered the liftgate to the fully closed position. The door came down on my head and bruised my shoulder. If the door switch is turned off, the door will slam down hard, possibly causing serious injury or death to anyone in its path. I'm a fairly strong 83-year-old. If this happened when my wife or one of my great grandchildren were under the malfunctioning hatch, they could have been seriously injured or killed. The malfunctioning hatch was demonstrated to a toyota service rep. The toyota rep. Said, whereas the recall repairs have been done, toyota will charge for a second repair. The cost of repairs would be more than five hundred dollars. After doing some research on the internet, more than seventy similar lift-gate problems were found that sienna owners have experienced. Obviously, toyota hasn't been able to do satisfactory, lasting repairs. Toyota's failure to resolve this problem needs to be addressed once and for all at no cost to the sienna owner. A list of similar issues being reported follows: note: comments relating to personal injury highlighted in red. Note: these are just a few of the reports. Note: due to character limitation, unable to provide list of similar issues found. Can provide list if you request.

Filed May 23, 2019 · Body · 124,000 miles · DE

While driving on route 1, we heard a "whoosh" sound. The sunroof glass spontaneously flew out of the sunroof, and the interior slide cover popped up through the sunroof. We don't know where the glass went, and didn't hear a shattering sound, so we are hopeful that it landed in the grass somewhere and not in the roadway, causing injury to anyone.

Filed Mar 1, 2019 · Body, Locks · 175,000 miles · WI

I have a 2006 toyota sienna that I bought in 2009. I had to turn off my electrical right back side passenger door because it slides open by itself while I'm driving. The door opens and closes with the push button but due to the door flying open while I'm driving I had to turn the automatic option off. I take my vehicle in for all recalls but I'm not sure if this has been one of them and if it hasn't it should be. It just happens out of nowhere and you never know when it's going to happen you just see the door fly open in traffic. I have kids and a dog that rides in my van on a daily basis so this problem needs attention.

Filed Dec 29, 2018 · Body · 108,000 miles · GA

Passenger-side powered sliding door suddenly malfunctioned; no preceding odd noises or other trouble signs. The door will slide backwards to open position and latch there as it should, but upon button-push to close, it rolls forward about two-thirds of the way, then stops and retracts. Same problem no matter which of the several door switches is used. Worse: the door cannot be manually pushed beyond the malfunction point to shut it. I fear damage to mechanism and dealer service department backlash if I force it. Obviously not safe to drive in this condition. Luckily did not occur on a long family trip! Car must be garaged out of weather until problem resolved. Here is the issue I would like the federal safety agency to consider: a motorized door should have been provided with a bypass procedure which would allow damage-free manual closing for any and all mechanism failures. Toyota's failure to provide this alternative is a safety hazard to its customers.

Filed Sep 24, 2018 · Body · 125,000 miles · NY

On the sliding door with the automatic open, the cable snapped that controlled to door to open and close. Now that door is unable to be opened. Even with the power assist button turned off, the door in not able to be used. During an accident, I would not be able to open that door. This is a safety issue and I was shocked that this isn't a recalled part as I have seen many others with the same issues.

Filed Jun 7, 2018 · Body · FL

2006 toyota sienna. Consumer writes in regards to electric doors safety recall. *ld the consumer stated the doors failed after having the recall repair performed.

Filed May 29, 2018 · Body · FL

Dash panel - cracked ignition - panel - cracked

Filed Feb 21, 2018 · Airbags, Body · 120,000 miles · CT

Tl* the contact owns a 2006 toyota sienna. While the vehicle was stationary, the air bag indicator illuminated and the dashboard fractured. Lynch toyota in manchester, connecticut was made aware of the failure and stated that there was no warranty coverage on the vehicle. The manufacturer was made aware of the failures. The failure mileage was approximately 120,000. *tt