The contact owns a 2006 Toyota Sienna equipped Hercules Tires, Tire Line: Roadtour 855 SPE, Tire Size: 215/65/R16, DOT Number: U96VH260H21. The contact stated while driving 35 MPH during a trip, the steering wheel started shuddering. The vehicle was taken to a tire shop, and the contact was informed that the two front tires had sustained tread belt separation and bulges. The two front tires were replaced. Additionally, the contact stated while driving 65-70 MPH, the TPMS warning light illuminated. The vehicle was taken to the tire shop, and the contact was informed that the rear passenger's side tire had sustained tread belt separation, and the metallic belt was poking through the rubber. The contact requested that the rear tires be replaced as a precautionary measure. The rear tires were replaced. All four tires were replacement tires. The dealer and the manufacturer were not notified of the failure. The vehicle failure mileage was 173,414. The tire failure mileage was approximately 16,022. The VIN was not available.
Toyota Sienna tire blowout problems
136 of the 8,561 owner complaints about the Toyota Sienna describe tire blowout or tread separation, most of them for the 2004 model year.
- owner complaints
- 136
- worst model year
- 2004
- typical repair cost reported
- $692
- typical mileage
- 43,000
By model year
Often reported together
Premature wear 3Pulling 2No deployment 2Wipers 1Slipping 1Power steering loss 1Fire or smoke 1
What owners say
The contact owns a 2012 Toyota Sienna equipped with Michelin Tires, Tire Line: Cross Climate 2, Tire Size: 235/60/R17, DOT Number: (N/A). The contact stated sidewalls on all four tires were expanding, causing the tires to bubble and bulge outwardly. The dealer was not contacted. The contact informed the tire shop where tires were purchased of the failures, and two tires were replaced. The contact was unsure what two tires were replaced. The manufacturer was made aware of the failure. The vehicle failure mileage was approximately 152,000 and the tire failure mileage was approximately 1,000. The VIN was not available.
This vehicle is a tire eater. It does not matter what the brand of tire it is- Michelin, Bridgestone, or Yokohama, tires last, at best, 18 months of local soccer mom driving. After five sets of 50K mile, or better rated tires, at $800 to $1200 hundred per set, I think it is time that Toyota owns up to the fact that something is wrong with this model (4x2) vehicle. In my mind thjis is similar to the Toyota airbag situation only on a smaller scale. The manufacturer always has an out, such as, did the customer have the vehicle aligned, have the tire pressure checked, rotate tire on schedule, was it driven off road? My concern is that just about any driver would expect to get 30 to 40 thousand miles of normal driving from a set of premium tires. If the tires wear abnormally quickly while expecting "normal" tire mileage, this puts the driver in danger due to unexpected tire failure and possible tire related accident. This needs some data analysis.
10-01-2022 new tire blew out at I-10 , Columbus TX78934 4 new tires installed at 07-07-2022; YOKOHAMA YK-CTX; 235/60 R17 Invoice total cost $1085.76
This tire separated at the side wall nearest the rim. The last one separated and swelled roughly the size of a ping pong ball, prior to that the same thing. This is the 3rd Pirelli Scorpion Verde All Season tire to fail. After this last one, I realized it's got to be something with the construction of the tire so I googled and found recalls for other Pireeli tire models. I contacted the mfr and they refused to assist. Spoke with very rude individual at Pirelli USA in Rome, GA location who stated 'if I am concerned about the safety of the tire, report it to the federal safety agency' and that in order to obtain a replacement I would have to contact the retailer to initiate a return. As instructed, I spoke with the retailer Simple Tire (Trevose, PA), an individual named Shailesh. I was told since there is no the federal safety agency recall therefore there is no replacement.
About two weeks after getting all new tires installed at Costco, the driver side rear tire blew out. I was driving about 50 MPH on a dry road with no debris in sight. The blowout gash was in the middle of the tire, not on the sidewall.
We recently had two Dunlop P 235 / 50 R 19 tires fail on our car. On 11/5/21, the front passenger-side tire tread and belt began to unravel while driving at freeway speed. This happened suddenly, with no warning lights, and we became aware of the problem when we heard a loud thumping noise from the unraveled tire striking the underside of the vehicle. We immediately exited the freeway, found a tire shop, and had the tire replaced. The following week, I inspected the other tires and found that the front drive-side tire was failing in exactly the same way. We immediately had that one replaced too. Neither tire shop that replaced the tires could identify a cause of the tire failures other than possible defects in the tires.
215/65 R 16. Four new CONTINENTAL tires fitted early 2021 to Sienna at Discount Tire in Tucson. July 2021 severe vibration and evidence of tire structural issue photographed. All tires showed similar failure mode.. this was on a very hot day. I took the vehicle to Big O tires and had the front two replaced at my expense so the vehicle was drivable. I returned to Discount Tire in Tucson (Speedway) to ask for a recall check after I learned of the 2021 recall on similar Continental tires for sidewall failure. Discount tire reimbursed one tire. I complained to agent Matthew Harby that the other two tires were dangerous because they showed the same sidewall defect on the hot day. He denied my request for replacement if the remaining two Continental tires because there was no open recall on these. I told I him I was worried about a catastrophic failure in normal operation. I then resumed driving. The weather cooled off and until October the two tires behaved normally again.. On 10/30 about 630pm I was dri ong on I10 and experienced catastrophic tire failure in the outside lane speed approx 65mph. I was fortunate to be able to pull over without losing control but the photo shows the extent of this serious failure. I am now at Discount Tire on Ina Road in Tucson requesting replacement of the failed tire and the final remaining CONTINENTAL tire. The photos should show sufficient evidence of sidewall failure matching the failure mode of the recalled tires. THESE ARE DANGEROUS AND NEED the federal safety agency ACTION WITH A UNIVERSAL RECALL BEFORE A FATAL EVENT OCCURS
on July 3rd, traveling on highway to airport tire blew out (right rear). Pulled to side of road and attempted assistance but this was friday afternoon before july 4th holiday, NOTHING was going to happen except a tow - possible wait as long as 2-3 hours. reportedly the Sienna has drive flat (50 miles at 50 mph) We drove 5 mph for approx 3 to 4 miles to tire store/Les Schwab. Flat was replaced but then on inspection ALL remaining tires had card showing wear on inner tires. ALL 4 (including the blowout). Pictures submitted . Of particular concern is that we had taken the vehicle about 10 K prior (March)specifically for tire wobble noise and to fix alignment. Wear was noted, but no safety concerns raised and no cautionary recommendations offered. When we brought the vehicle and tires to the dealer AFTER the blowout we were told by service manager that the early wear was a known problem to occur specifically on the all wheel Siennas. Again, NO CAUTIONARY ADVICE GIVEN in March despite recognized wear and this known history. We had a blowout in heavy holiday traffic at 60 mph less than 10K /3month later. This easily could have been catastrophic. We reported to Toyota to a "Beth" at customer documentation and risk reduction department who did an excellent job of deflecting causation/potential blame and advised us to contact the tire manufacturer or the dealer. Absolutely no evidence of concern for safety - ours or those around us - at highway speeds. Review of web shows known problem, service manager volunteered it to be a known problem of premature wear, with service given shortly before incident WITHOUT GUIDANCE. "Beth" told us she would document our concerns but that there was nothing Toyota could do or would do other than documenting. I am hopeful you can investigate further and initiate some reparative process before there is a preventable catastrophe much like the Prius accelerator problem. we will send copies of to wherever is useful
Tl* the contact owns a 2008 toyota sienna equipped with bf goodrich tire, tire line: all terrain k02, tire size: 215/65/r16, dot number: bfaeat11. The contact stated that while driving at 55 MPH, the passenger's side front tire experienced a blowout. The vehicle was not taken to be inspected or repaired. Neither the tire manufacturer nor the vehicle manufacturer were contacted or notified of the failure. The vehicle failure mileage was 134,920; tire mileage failure was unknown.
Related recalls
Tires: temporary/emergency spare tire
- What is wrong
- Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.
- Risk
- A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.
- Remedy
- Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1‑800‑444‑1074. Toyota's number for this recall is 17R2.
Recall number 17V295000 · Recall details
Tires: temporary/emergency spare tire
- What is wrong
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
- Risk
- If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
- Remedy
- Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1‑800‑331‑4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V‑160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V‑160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Recall number 14V273000 · Recall details
Questions about the Toyota Sienna tire blowout
Which Toyota Sienna years have tire blowout or tread separation problems?
The model years with the most reports are 2004 (28 complaints), 1998 (16 complaints) and 2006 (13 complaints).
How much does it cost to fix tire blowout or tread separation on the Toyota Sienna?
Owners who mentioned a price put the repair at about $692 (median of 12 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Toyota Sienna?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history