2006 Toyota Tacoma suspension problems

Filed Feb 22, 2026 · Suspension · OH

Voss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.

Filed Nov 28, 2025 · Body, Suspension · KS

I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. That was Dec. 2024 . The truck has been parked since . Ive had no transportation and can not run right out and buy another truck . I am also not willing to give up the truck either . I have put a lot of hard earned money into this truck believing it to last forever . The motor and train are sound . I do not want to junk the truck . Please , tell me what I can do . Yes . My vehicle is available for inspection upon request.

Filed May 9, 2025 · Body, Steering · CT

The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the federal safety agency review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 29, 2025 · Suspension · VA

The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to Toyota, this was a huge problem with the 2006 Tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.

Filed Feb 22, 2024 · Body, Suspension · OR

There are holes in the frame and the frame mounts. Sold with a clean title

Filed Feb 16, 2024 · Body, Suspension · OR

This truck is for sale in Oregon with HOLES/RUST on the frame and the frame mount. It is being sold with a clean title which clearly with the frame damage it is considered a branded title. The car lot that is selling the truck will no disclose the frame issue when asked about the structure damage on the truck. BUYERS BEWARE!!!

Filed Apr 17, 2023 · Body, Suspension · 178,000 miles · MT

The contact owns a 2006 Toyota Tacoma. The contact stated that after the vehicle was taken to a local dealer for unrelated repairs, the mechanic determined that the rear subframe needed to be replaced. The contact was made aware of the federal safety agency Campaign Number: 14V604000 (Suspension); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 178,000. The VIN was not available.

Filed Mar 19, 2023 · Body, Suspension · CT

I will try to give you as concise statement of my complaint as possible, however, I have copies I sent to the manufacturer and others that I'm willing to furnish you if requested. On 3/18/21, I wrote to Toyota's Executive VP , Chief Quality Officer, [XXX], stating my compliance with their notice of 7/9/15, requiring frame inspection, significant perforation not found, therefore they applied CRC corrosion resistant compound to my frame. As NO critical problem was noted, I felt I was good until during a later inspection was performed and rated more attention. On 3/29/21 during my next oil change I noted on a notation on an unusual service bill, typewritten not the usual custom printed type, a notation that I have 2 holes, approx. 3.5" on my frame, use caution if driving". At this time I found there was an open class action suit against Toyota. Toyota advised me that since I had not responded to more than one notification I was not included in the suit. I replied that "I DID NOT RECEIVE ANY SUCH NOTATION". As they did not send receipt requested or certified, I neither could prove sent or not received. I asked for consideration based on that to which, was denied. I have written also to CT Attorney General, CT US Senator, [XXX], with only the Attorney General's office stating Toyota's response was negative. I realize this is a late request, I was not aware of his avenue. I have Certified copies of each request for help, which I am more than happy to copy and send to you if you will try to help me right Toyota's wrong. I'm an 89 year old male just trying to right a wrong I believe done to me. I DID NOT RECEIVE NOTIFICATION FROM TOYOTA! , If I had, I would not be so persistent. I send my letters CERTIFIED, they should have had to also, could have solved this problem earlier. Please help me, thank you. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). The contact has noted that they still have yet to receive any compensation or resolution to this issue.

Filed Feb 26, 2023 · Steering, Suspension · FL · crash · 2 injuries

The frame is rusted so bad. The dealer wouldn’t replace due to the vehicle being registered in Florida as it’s not one of the states affected. But my Toyota came from a Pennsylvania dealer first then shipped to Florida after years of being in Pennsylvania and not having an issue up there. Now I’m stuck with a truck I can’t sell or fix. It’s not right. Where is the quality control on this.

Filed Nov 16, 2022 · Suspension · 70,000 miles · MA

The contact owns a 2006 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for front brake repair, she was informed that the front side of the subframe and the passenger's side and the driver's side subframe were severely corroded. The dealer was notified of the failure and informed the contact that she would need to pay for the repair because an unknown Extended Warranty related to the failure had expired. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 70,000.