2007 Toyota Tundra body problems

Filed Jun 9, 2025 · Body · 279,000 miles · IL

The contact owns a 2007 Toyota Tundra. The contact stated while parking the vehicle, there was a loud sound coming from the vehicle. The contact inspected the vehicle and determined that the fuel tank scrap and bolt had fractured and detached. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact stated that when the vehicle was purchased in May 2024, the contact later noticed flaking material on the ground underneath the vehicle. The vehicle was then taken to the dealer, but no assistance was provided. The manufacturer was made aware of the failure and a case was filed. In addition, the contact confirmed that in March 2019, the vehicle was serviced under an unknown corrosion prevention recall repair. The contact confirmed that at the time, the dealer performed the recall repair by spraying anti-corrosion prevention on the suspension. The unknown recall repair was warranted for 60 months. The failure mileage was approximately 279,000.

Filed Mar 20, 2025 · Body · 142,255 miles · NY

The contact owns a 2007 Toyota Tundra. The contact stated that occasionally while driving at various speeds on bumpy road surfaces, the fuel tank was scraping against the pavement. The contact stated that upon inspection from the outside, the contact became aware that the fuel tank was hanging abnormally low and the bracket holding up the brake lines and fuel lines were completely rusted. There were no warning lights illuminated. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that due to the abnormal amount of rust on the sub frame, the vehicle was not safe to be driven. The contact was informed that the entire sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 142,255.

Filed Oct 13, 2024 · Body · PA

Undercoating of vehicle was not properly installed causing the frame to rust out creating a serious safety concern as the fuel tank can fall from the vehicle due to extensive rust. Toyota is aware of this situation however refuses to repair the problem.

Filed Apr 6, 2024 · Body · NY

The frame of the vehicle has a recall on it because of excessive rusting. The previous owner had not gotten the recall fixed. The rusted frame causes issues with steering, maintenance, and general control and safety of the vehicle. Toyota dealerships claim this recall has expired. A rusted frame violated NY State inspection. Since this indefinitely violates the federal safety agency guidelines and regulations, how can it expire? Toyota refuses to fix the recall on the frame due to “expiration” and would rather endanger roadways see as many of these vehicles still are driven on public roadways and come with a hefty cost due to the expiration. Many vehicles like this with under 100k miles have the same critical issue, leaving Americas at a loss. This recall should not “expire”

Filed Dec 30, 2023 · Body · IN

What component or system failed or malfunctioned, and is it available for inspection upon request? Gas tank cover plate is rusting out causing the tank to almost fall out. How was your safety or the safety of others put at risk? My safety and others safety was put at risk as if the tank were to fall out, it could catch the vehicle on fire. Also as the plate rusts even more day by day, the heat from the exhaust and other parts that heat up it can damage the gas tank and once again is a fire hazard. Has the problem been reproduced or confirmed by a dealer or independent service center? No, there are no open recalls from what I can’t tell by the vin but same year has same problems and are under recall. Not sure why this one isn’t under recall. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there would be no lights for an issue like this.

Filed Aug 13, 2023 · Body · WV

The frame is shot on my 07 Toyota tundra the frame rails has several big holes in the frame as well all the crossmembers are rusted and I’m still currently paying on the truck I still owe $14,000 on it and I can’t afford to get it fixed so will you please please please help me out with this situation and either open the recall up or see if I can qualify for the assistance program I’m paying on a vehicle I cannot drive it’s unsafe to drive and the issue needs fixed the recall or whatever it’s was called should’ve never been expired to begin with and I wasn’t even aware of the recall had I was I would’ve got it fixed !! I’m begging you please help me as my family relies on this on truck I have !! Thank you and have a nice day !!

Filed May 10, 2022 · Body, Transmission · 167,000 miles · NJ

The contact owns a 2007 Toyota Tundra. The contact stated the door locks were inoperative. There were no warning lights illuminated. The vehicle was taken to several independent mechanics to be diagnosed. The contact was informed that the subframe needed to be replaced. Additionally, the contact was informed that the driveshaft was defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 167,000.

Filed Mar 28, 2022 · Body · MA

I have a major safety concern regarding the frame of my 2007 Toyota Tundra Limited. My truck has only 128,665 miles on it, and it's pristine, except for the fact that the frame is rusted away, to the point where it needs to be replaced. I noticed last week that one of my straps holding up my gas tank was hanging, and my tank was near the ground. I brought it to my mechanic, and he said that the strap was fine, the strap was rotted off my frame. He said that the frame is in such dire shape that I was lucky that my truck didn't fall apart while driving it, and that I'm lucky the gas tank didn't drag on the highway, causing a catastrophic event. Upon researching this, I found that Toyota Corporation was aware of this major safety issue. Toyota evidently replaced quite a lot of these defective frames due to rust issues, but a recall was never sent out to all Toyota Tundra owners. I just spoke to someone at Toyota's Corporate office, and the person told me that there was nothing that Toyota could do for me, except say that they are sorry. How can such an important safety issue with these Toyota Tundra frames not trigger a recall? Is there anything that the NHSTA can do to make Toyota correct this hazardous safety issue and problem? A formal recall should have been sent out. How many more Tundra owners are still driving around with this major life safety problem, that they are unaware of? Please help me, Toyota needs to do more than just say 'sorry'. If there something that you can do? If not, where do I turn next? Respectfully, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Dec 29, 2021 · Body · 107,000 miles · MA

The contact owns a 2007 Toyota Tundra. The contact stated that the frame of the vehicle was severely corroded. The vehicle was taken to the dealer who diagnosed that the fuel tank crossmember was corroded and the sub frame was severely corroded on both the driver’s and passenger’s side. The manufacturer was notified of the failure and advised the contact that the vehicle could not be repaired under an unknown frame corrosion recall because the recall had already expired. The vehicle was not repaired. The failure mileage was approximately 107,000.

Filed Sep 20, 2021 · Body, Fuel system · IL

Rear fuel tank strap bracket detached from frame. Bracket appears to have corroded and detached at its frame weld without warning. Tank dropped about 3 inches down at rear and was barely supported by the front tank support strap and the flexible fill hose, which appeared to prevent it from shifting. The fill hose is attached to the tank via a stainless steel clamp. The tank could have dropped from vehicle when I was on the highway, before I was even aware of the issue. I happened to see something sagging when I was walking to my vehicle. It appears that the tank bracket would be very difficult to inspect, and I believe I had the vehicle inspected for a corrosion recall about 2-3 years ago. I was lucky I observed the tank when I did, it may have broken 1 or 2 days before I even noticed it. Attached photo shows the corroded detached bracket assembly. I was able to temporarily resupport the tank under the existing strap.