The entire outside of this truck is rusting. The frame is completely rusted as is the outside of the vehicle and the bed which you can see the ground when looking down. This is ridiculous. It looks like the area that hold the gas is also rusted and is dangerous to drive.
2008 Toyota Tundra body complaints
Page 2 of 3: complaints 11 to 40 of 56, newest first, as owners wrote them.
Bed rust in areas where bed bolts to frame. Known issue by Toyota as evidenced by their TSB issued in 2012. Bed mat has been used since purchasing vehicle on 2010. Bed has rusted through at one location, rust is visible at another and the other two locations the paint is bubbling up. Contacted my local Toyota dealership (9/2020) and forwarded to the collision/repair shop manager. He supposedly sent an email to a district/area manager with pictures. I contacted him a couple weeks later and he said he hadn’t heard back and would sent it to another individual. I asked for the original email along with the new one. Original email was never furnished. Couple more weeks passed and I followed up yet again. Was told my vehicle was too old and nothing could be done. No official letter from Toyota, just a verbal statement. This rust will eventually cause a lack of support in the bolt area and may be an extreme safety issue while driving the truck and/or those driving beside or behind the vehicle if/when the bed disconnects from the frame. Incident date is the reported date to dealership. I am positive it had been ongoing under the bed mat quite prior to that date.
Excessive rust build up all along the underside of the vehicle, frame, and all over the suspension components
The contact owns a 2008 Toyota Tundra. While driving approximately 45 mph, the fuel tank detached from the vehicle. The contact was able to tie the fuel tank to the vehicle with a rope until he was able to get to safety. The dealer was made aware of the failure and confirmed that the subframe needed to be replaced however, the repair was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 181,000. THE CONSUMER STATED BOTH FUEL TANK STRAPS CORRODED CAUSING THE FUEL TANK TO DROP.
Rear left fuel tank bracket broke off from truck frame. It appears to have broken at weld. See photo. Noticed problem while driving due to bracket rubbing against driveshaft and scraping on road. Previously, fuel tank bracket on same vehicle snapped and had to be replaced. Truck towed to shop for repair. I will keep broken part once removed from truck.
I had my truck bed rhino lined when new. I now have only 95,000 miles on it and the bed is rusting from underneath. I lowered the spare tire and could see the corrosion more clearly. The rust is actually bubbling up the rhino liner.toyota did issue a recall for this issue, however mine was not showing these issues at the time, now the recall has expired. Toyota knows there is a problem, they need to extend the recall so that vehicles can be repaired safely and put back on the road without the bed falling off.
Bed bolts began rusting soon after I purchased the truck. I complained to the dealer but they said it was nothing. Waited a year and it got worse, rusting the bed, so I brought it to dealer #2 who said there was nothing they could do - no recall or tsbs. My frame was replaced 2 years ago at original dealer and I asked about the bed again but was told no warranty, recall or tsb. I just learned that there is a tsb on the bolts and corrosion of the bed. Other than a rusted out bed, my truck looks and runs great but I'm afraid that my bed it going to fall off every time I hit a bump. I feel like I was misled - lied to - by both dealerships. Toyota should have corrected this issue 10 years ago. I am not in the position to have repairs done or purchase a new truck. Toyota should be looked into for not making the corrections as soon as the issue was discovered. The design is flawed as the bed is double walled with some sort of insulation between the layers. As it rusts from underneath, water enters between the walls and the insulation holds the moisture. By the time the rust begins to show on top the bottom is so far gone. I really do not want to scrap a vehicle because of toyota's neglect.
I had reached out to toyota regarding the premature chassis rust issue on their trucks. I had inadvertently missed the cut off date for the coating which was in may of 2018 due to an unavoidable personal event. What didn't make sense was that they extended the campaign to replace the chassis if the perforation was deemed severe until january of 2020. I had the chassis inspected by a toyota dealer before this january cutoff date. While there isn't sufficient perforation to warrant a replacement but it is clearly evident that the chassis was never painted and the rusting on the chassis is clearly prominent for a vehicle of this age. What is most disconcerting is that they would extend the warranty to replace the frames but they would not extend the cutoff to coat the chassis. Shouldn't this coating be covered by the manufacturer without a cutoff date? My truck has been very well taken care of, never abused and always washed after snow storms but due to no fault of my own whereas the initial chassis coating was faulty I am now faced with a truck that looks almost mint but the chassis will be failing prematurely. I had reached out to toyota but they flat out refused to provide the coating as I missed the cutoff date. I am concerned that this will soon become a safety issue as the truck will lose it's structural integrity without the crucial coating to inhibit the rusting. Please let me know if there is anything the federal safety agency can do to help, thank you.
Bought 2008 tundra in 2015. Body excellent shape. Had 46000 miles on it. Blowed a brake line and put on rack to make repairs this past month. Brake lines rusted and frame is rotten. I can run my finger through the frame. I paid 25.000.00 for this truck. Was towing a camper when brake line blew. Was hardly able to get camper home. Will you folks replace this frame? Or will you stand good for it. I still owe on it. It is parked for the time being and not safe to drive.
Frame mount for gas tank has rusted and fuel tank is dropping down. Last year an undercoating was applied by a toyota dealer and is peeling off in certain areas. I believe pursuant to the class action lawsuit referred to as brian warner et al toyota motor corporation my vehicle may be covered under warranty because the gas tank strap mounting is part of the frame. As of now, my mechanic advised me not to drive it as it is a safety hazard. I noticed the tank strap was hanging down from the frame and the gas tank was also hanging down while the vehicle was parked in my driveway.
On 01-08-2018 I had a mva in which the front of my truck struck another vehicle and my air bag was deployed. As you may judge from the picture the impact was minimal. The other vehicle, a 2003 honda civic, was drivable, while my much bigger truck was not due to my condition and the deployed air bag. I was knock out approximately 5 to 7 minutes, I made this estimate by the arrival of winter park pd. I also suffered two fractured ribs on my right arm pit area and one on my left arm pit area, this was according to the er doctor and a fracture of my l5 vertebrae according to my mri report. Four herniated disc and six bulging. It is my sincere believe that some if not all this personal injuries I suffered were related to an over pressured air bag system. Although there are no recalls on my truck, I feel a need to register my complaint. As noted on my pd report I had just initiated a u-turn so I could not have been traveling more than 15 MPH on lee rd. (a paved city street). See also odi 11287678.
I had lifted the bed liner on my tundra and found the bed to body mount area rusted through with holes in it. There is a tech bulletin for the exact item but I am out of warranty. It has a hole in the bed now. If I had lifted it years before I feel the rust would have been seen and it taken care of. Toyota will do nothing for it now. I have never had a truck rust thru so fast.
My tailgate latch broke on me again. This is the second time that it happened in two years. I was just going to let my tailgate down and the latch broke. The vehicle was stationary.
Vibration at 70,000 miles in front and rear of vehicle. Checked out online. Seems people are having problems with bearings in toyota tundra's at relatively low mileage . Took to mechanic. Bearings need replaced in front right and rear wheel hubs. 70,000 miles, wow. Mechanic was flabbergasted too. Little early for bearing replacement . With the frame already under recall. Makes you wonder who went cheap with bearing's too. I bought toyota in thinking things like this wouldn't happen. My 1996 nissan frame looks better then the frame on my truck. Toyota inspected frame . Told me it looked better than most . Bolts that hold bed on under my bed liner are already rusted, as well as the bed body and frame .told me it doesn't meet replacement requirements . So now I'm waiting for them to spray underneath body. Something that should have been done in production . I don't see how that fixes a problem . If done correctly and prepped before spraying maybe. Need to replace all frames not coated in the first place.
Takata recall. Every light on the dash come on an the eng. Try to quit . It stared on jan. 23 2018. On us 119.I wash it ion the wheel the finsh came off . Thebed is rushing on the in side at the bolts.
Also my 08 tundra just like my 03 toyota sequoia has the paint coming off the hood and very top of truck including chipping and pain coming off and clear coat, has to be bad paint there using.
Truck bed rusting from under the bed forcing the metal up, bubbeling, and now the bed is rusting through. Rust exactly as described in the service bulliten t-tci-3823, july 30, 2012, truck bed floor rust/corrosion. .hopefully the truck bed won't fall off because of this, looks very bad.
On june 13th. My 2008 toyota tundra inexplicably cought on fire. The fire was located on the left side of the dash and the left front door. The truck was running, idle with the air conditioner on the windows were up. I had both of my small dogs inside. I was not in the truck . That day was clear sky and starting to get hot for the dogs . I always leave the truck running with AC on for them. I was busy working on a 2000 hino medium duty truck. My truck was parked next to the hino . I was in the hino. My client alerted me of smoke coming out of my cab. I immediately went to open the door all I saw was smoke and one of my dogs was barking the other I had to go in to find. He was alive but not barking. I removed both dogs the fire had melted my dash on the left side there was not any flames on dash just smoke the only flames where on my jacket that I had left on the floor driver side front. I pulled my jacket out through onto ground . My client than told me to use a fire extinguisher to be safe. I did . Thats it I didnt call fire department . The fire was over but it caused allot of damage. I don't understsnd how this could happen. I first tried to get someone to inspect it before I took to toyota dealership where I bought truck new. Could not find one in area. I took to dealer about 3 weeks later they could not explain it so they directed me to toyota headquarters on july 31st. Now toyota headquarters has not told me what caused this fire I'm assuming they are still investigating it. Can you please come and look at my truck I did take some pictures if you would like. Thank you. The fire happened in south san francisco in a parking lot for a big warehouse. Buisness area not residential.
The bed of my truck is rusting out in the area where the hold-down bolts are. Before long half or more of the bolts will be useless and the bed could come off. Nothing else on the truck body is rusty at all. This is obviously a defect and it negatively effects the safety of my truck. This has been going on for years but I just recently became aware of the full extent of the problem.
The bed of this truck is rusting out especially along the cross frame bars and where the bolts attach the bed to the frame of the truck. As the truck ages the rear of the truck has developed a sway when rounding turns.
So long story short my 2008 double cab 6.5 foot bed was taken back to the dealer for the factory or dealer (in mid 2009) installed plastic bed liner rubbing the paint off in the bed and discoloration of the back bumper or delamination as toyota called it. Toyota replaced the bumper free of charge due to the corrosion warranty and the dealership not undercoating the back of the bumper, great no problem there. But never in any of the records did the service rep record that the bed could corrode! Later to find out when taking the truck to get a spray in liner I dropped it off in august of 2016 later to get a call saying I should take a look at my bed before they did any work to find a hole rotten through the bed an paint that was bubbled, cracked and flacking off. I did some research on line to find a tsb for my exact problem. Its tsb-0101-12, I never got word of this till I dug online to find this! I took the truck to toyota to be told they could not help me because there was no warranty. So I contacted the north east regional claims manager to be told that since there was no record of this complaint during the warrantee period they could not assist. Would anyone have any advice on where to turn I might trade the truck in to not have to replace the bed
The truck bed floor has rusted at all four hold down bolts and has expanded to other aspects of truck bed floor itself.
Extrem rust under truck
Tl* the contact owns a 2008 toyota tundra. After the bed liner was removed, it was discovered that the bed of the vehicle was rusted. The vehicle was taken to a dealer, but no assistance could be provided. The manufacturer was notified of the failure. The failure mileage was 77,000.
80,300 miles. June 2, 2016 removed my bed liner to clean out from hauling a load of topsoil. Discovered rusting/bubbling on the floor surface. 2007-2011 toyota tundra truck bed floor rust tsb issued 110/17/12. My VIN falls into the category but it falls past the 60 month/unlimited miles corrosion warranty. I keep my truck immaculate and very well maintained....hence the bed liner. If I would have treated my truck differently and not protected the bed with the bed liner, I would have discovered the rust sooner and probably been covered. Penalized for taking care of my truck. The local dealer tried very hard to get toyota to cover the repair but the toyota reps would only offer $2000 toward a potential $13000 repair. I have been a toyota customer since 1990 and I am extremely disappointed with toyota. This issue has absolutely nothing to do with customer neglect...it's neglect by toyota who will not stand by their product. As far as this being a safety issue, the rust is concentrated where the bed is connected to the frame. If I did not discover this, it could potentially separate from the truck frame while driving/hauling a heavy load and cause serious injury or death. Toyota doesn't care about that apparently.
Significant rust around bed bolts. No other rust on body, or underneath bed, no rust on chassis. No rust anywhere else on truck. Seems to be softball size bubbles in a pattern on bed only. If not fixed afraid bed will come loose while driving over rough terrain or in a minor accident.
Tl* the contact owns a 2008 toyota tundra. The contact stated that the vehicle was rusted and there were enormous holes in the rear bed of the vehicle. The vehicle was taken to a dealer where it was diagnosed that the rear bed was corroded and needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was approximately 168,400.
Tl* the contact owns a 2008 toyota tundra. After inspecting the vehicle, it was discovered that the frame was rusted. The vehicle was taken to a dealer where it was diagnosed that the frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 39,000.
Bed rust.
The power windows on all 4 doors do not work when the weather goes to just freezing. I do not think there is enough insulation in the doors or water is accumulating inside the motors that run windows. I have only owned this truck since november of 2012 and did not drive it last winter as I work away from home for months at a time. This winter I was home and the power windows do not work when it is cold outside. I have never experienced this with any other vehicle in cold/frozen weather before so, I think there is something wrong. I live in washington state and it does not get that cold overnight here where I live just down to freezing usually in winter. My wife drives an acura rl 2006 and has never had this happen to her with her car.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Toyota Tundra?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history