Van hool t2140 2007 there are possibility to have turbo failure by installing defective turbo intake pipe by manufacture. There are installation difficulties when connecting turbo charger and turbo pipe because of limited space in engine compartment. The wall of vehicle was interrupted to locate the turbo pipe. Van hool manufacture trim(cut) the pipe to installed. Because of that ,pipe lost 90% of thickness. Originally about 7mm in diameter of the pipe became 1mm in diameter. It has been covered by rubber attached on the wall to be hidden. It can not see by regular inspection unless you take out pipe. The manufacture must recall this pipe to replace. We had turbo failure in only 90,000 miles of vehicle operation caused by the intake pipe leak. *tr updated 10/27/10 *bf updated ivoq 11/01/10.
The worst 2007 Van Hool T2140 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Engine3
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine3
Recalls 2
Visibility: rearview mirrors/devices: interior
- What is wrong
- Van hool is recalling certain model year 2002 through 2011 transit buses and motorcoaches manufactured from august 2002 through october 2010, equipped with hadley remote mirror switches, part numbers 509vh and 509vh1f. The rear view mirror switch may overheat, causing the plastic housing to melt.
- Risk
- Excessive heating can cause a fire resulting in smoke, operator distraction, or personal injury. An overheated mirror switch could cause the exterior rear view mirrors to not operate. The mirrors may not adjust properly from the interior switch or operate poorly. Therefore, the driver may not be able to have full use of the rear view mirror, increasing the risk of a crash.
- Remedy
- Van hool will notify owners via its dealer abc bus inc. Owners will have the choice to perform the repair themselves or to take the vehicle(s) to an abc-location for repair, free of charge. The safety recall began on january 10, 2011. Owners may contact the warranty administrator for abc bus, inc. Toll free at 1‑877‑427‑7278.
Recall number 10V603000 · Recall details
Visibility: windshield wiper/washer: linkages
- What is wrong
- Van hool is recalling 149 my 2004-2007 c2045, t2140, and t2145 motor coaches equipped with doga windshield wiper systems. Linkages were poorly finished. This could lead to a misalignment of the windshield wiper system, blocking the motor.
- Risk
- Failure of the wiper linkages will lead to wiper system breakdown. The operator will have reduced visibility which could result in a crash.
- Remedy
- Van hool is working with doga and doga will replace the wiper motor free of charge. The recall began on july 23, 2008. Owners may contact van hool (abc companies) at 1‑407‑656‑7977.
Recall number 08V237000 · Recall details
See all 2 recalls for the 2007 Van Hool T2140
Defect investigations
Windshield wiper replacement program
A january 2008 service bulletin suggests that certain model buses should upgrade to a high torque wiper motor.the tsb also alluded to wiper motor failures. Therefore, odi opened this investigation to determine the failure mode, frequency and safety significance since the wiper system is considered to be a critical item of safety equipment and is required by a federal standard. Van hool re-evaluated the issue and decided to conduct a safety recall. Van hool determined that there was an issue, but it was an issue with improperly finished linkage components that were causing the wiper motor to fail. All wiper motor linkages on the affected buses will be replaced under the recall. The recall action resolves the issues raised by this investigation. Accordingly, this investigation is closed.
PE08023
Technical service bulletins for the 2007 Van Hool T2140 24
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The control arms of the front and trailing axles are equipped with a flexible ball-joint at the chassis side
- Mobile column lifts raise the vehicle under the wheels
- To check emergency side window operation
- Introduction
- Van Hool recently changed-over in production to a “longer” articulation shaft (VH11717611) to fasten the...
- This service bulletin provides you with information about the location of emergency side window decals so...
- This service bulletin provides you with information about the location of emergency side window decals so...
- Service Information: In its production process, Bock, manufacturer of refrigerant compressors, has...
- Product Improvement: ALL VEHICLES WITH LIGHT-ALLOY WHEELS
- Service Information
What 2007 Van Hool T2140 owners say
Most recent owner complaints, unedited.
With cummins ism450 engine possibility of a turbo charger failure progressing to an engine compartment fire by allowing lubrication oil to enter the exhaust system. Currently vehicle does not have any warning system and protection to prevent an engine to be fire. In 2006, detroit diesel series 60 engine made recall to solve this problem to meet national traffic and motor vehicle safety act. Cummins dealer or any vehicle manufacturer which installed cummins ism450 must recall the vehicle to install 1)barometric pressure sensor 2)pigtail harness 3)reprogram ECM(electric control module) safety is most important for the vehicle, it must done before vehicle catch on fire or big accident happens. *tr updated 10/27/10 *bf updated 11/01/10
Tl*the contact owns a 2007 van hool t2140 charter bus. While driving at speeds of 35 MPH the vehicle stalled and the driver noticed that there was smoke coming from the exhaust. The vehicle was towed to an authorized dealer where it was diagnosed with failures to the engine turbo system. The vehicle was also leaking oil. The dealer replaced the turbo mechanism; however, the contact was concerned with the possibility of an engine fire. The failure and current mileages were 120,000. Updated 10/27/10 *bf the consumer stated the turbo failed in the coach. The consumer stated when the turbo failed, the coach lost five gallons of oil. Smoke emitted from the engine compartment. The consumer stated there was no warning. Updated 11/01/10
Compare the 2007 Van Hool T2140
Other model years
20062007
Questions about the 2007 Van Hool T2140
Is the 2007 Van Hool T2140 reliable?
Owners have filed 3 complaints about the 2007 Van Hool T2140, close to a typical T2140 model year.
What is the most common problem with the 2007 Van Hool T2140?
Engine and cooling, with 3 complaints.
How many recalls does the 2007 Van Hool T2140 have?
2 recalls, covering visibility.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Van Hool T2140?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history