2019 Volkswagen Atlas engine problems

Filed Nov 7, 2026 · Engine, Fuel system · FL

Vehicle stalls in normal driving. Problem was inspected and noted at Kuhn Volkswagen [XXX] Phone# [XXX]. Problem creates dangerous situation while driving because the engine stalls and prevents acceleration, steering, and creates a hazard for other traffic due to a disabled vehicle in traffic. Warning light has been intermittent. Problem has been confirmed by at least 2 separate mechanics. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 19, 2026 · Engine · PA

My vehicle is having a catalytic converter problem. I see that there was a recall on my exact make model and year but my vehicle is not on the list. This part is failing long before it should. There is a 0420 code.

Filed May 27, 2026 · Engine, Transmission · GA

For powertrain: failure of right front CV axle before 100k miles on a certified pre-owned vehicle; associated failure of shocks and struts in right front axle. The problem was inspected by an ASE certified VW mechanic, attested to be true and shown to us, and repaired. There were no warning lamps/lights, and the finding was made on a full vehicle inspection when brought in for a brake pad change. The issue appeared at approx 79000 mi on the odometer, 3 months after purchasing the vehicle. Obviously failure of the CV joints and components provide a risk to drivers and other motorists with the potential for injury due to steering and suspension failure during operation. Engine: the water pump was discovered to have begun to fail at approx 89000mi during a routine oil change service in May 2026. The mechanic states the issue is not noticeable without removal of the brush guard from under the engine compartment, and therefore may be missed by owners. A warning for “low coolant” is only shown once the level has dropped sufficiently. There is not currently a recall open for this part, confirmed with VW service center at a dealership May 27, 2026. This is harmful physically and financially for owners, passengers, and motorists as it can lead to catastrophic engine failure.

Filed Apr 30, 2026 · Engine · NE

I have a coolant leak. The first time presented to the VW service department, I was told it is a known issue and to add coolant if it isn’t a big leak or concern. I have been doing that, but now the leak is an everyday thing. I took it back to the service department and they said I need a new water pump and a belt. I asked about this known issue and they said I don’t qualify to have a recall for this. In researching this, I see because it is a known problem there is an extension of warranty to 8 years and 80,000 miles. My Atlas has 77,000 and I am requesting to have the needed repairs completed under the Good Will of Volks Wagen due to this being offered to other owners. Thank you for your consideration.

Filed Apr 15, 2026 · Engine, Fuel system · OH

2 fuel injectors have gone bad and 2 more are on their way out with 52,000 on the car. Just outside of the 6 year warranty.

Filed Mar 2, 2026 · Electrical, Engine · FL

The vehicle warning lights come on and off to make it seem like I am about to hit or to close to something when I am not moving at all. The vehicle putts and stalls while driving like it wants to cut off. It also does this when I am at a complete stop as well as if I am backing up Warning lights on the dash appear than disappear sometimes as well.

Filed Mar 2, 2026 · Electrical, Engine · CA

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine and the HVAC systems. Specifically, a persistent "ghost misfire"—where the engine vibrates and shudders without triggering a dashboard warning light—and a total heater failure. The vehicle is currently held at the dealership; all service records (RO# 367641, 367891, 367980, 368179) are available. 2. How was your safety or the safety of others put at risk? The "ghost misfire" causes shaking and hesitation during acceleration, creating a risk of losing power or stalling in high-speed traffic. Because the vehicle's diagnostics do not trigger a warning light for this condition, the driver has no advance notice of a potential engine failure. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Dealership technicians confirmed the misfire on Feb 9 (RO# 367891) and found a defective spark plug gap (.024” vs. .036”). On Feb 25, the service consultant confirmed the "ghost misfire" remained active. The heater failure was confirmed via a 'Heater Support Pump Dry Run' fault code (RO# 367641). 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by dealership technicians. Formal complaints have also been filed with the California Bureau of Automotive Repair and the California Attorney General. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Symptoms began following a service on Jan 30. Feb 8: Exhaust malfunction light (MIL) appeared briefly with severe shaking. Feb 9–present: Exhaust malfunction warning lights appeared briefly and then disappeared, but the engine vibration and "ghost misfire" symptoms remain active and undetected by the vehicle's onboard diagnostics. Feb 17: Total loss of heat occurred during a highway drive without a dashboard warning lamp

Filed Nov 19, 2025 · Engine · CA

My vehicle has P0420 and P0430 code errors, indicating a problem with the catalytic converters/emission system. There is a current recall on 2018 VW Atlas vehicles for this issue, but it does not include my vehicle. It appears this recall needs to be extended as the same issue is occurring on other 2018 VW Atlas vehicles.

Filed Nov 10, 2025 · Engine · LA

In July 2022, VW replaced the cylinder head and gaskets of my 2019 VW Atlas due to warped head. The vehicle was brought in for service because the low coolant light was on. The repair was done under warranty. In January 2024, the low coolant light came on again 31k miles after the first repair. We were told it was normal for this vehicle to burn coolant. Service refilled coolant. Since that time customer would refill the coolant when the low coolant light came on which was approximately every 6 months. Customer made appointment to bring in the vehicle because the low coolant seemed to be more frequent with evidence of a coolant leak. On November 6, 2025, service department informed customer that the Water pump was bad and needed to be replaced. On November 7, 2025, service department informed customer that they couldn't hold pressure and they had to test the block which would be on November 10, 2025. On November 10, 2025, service department informed customer that coolant was leaking into the head due to warped head.

Filed Aug 30, 2025 · Electrical, Engine · MD

With auto stop/start disengaged, vehicles stalls at slow speed (approaching a stop sign) or while idling at a stop light. displays "start car manually" when this happens. Now error code displays "Error Stop-start" The stalling has happened 5 times this week.