Volkswagen Atlas fuel leak problems

Filed Aug 24, 2026 · Fuel system · OK

Fuel line leak due to the angle the manufacturer line is coming out of the fuel tank. Rubbing on the line caused a wear on the line, gas leak and has to be repaired and rerouted by mechanic to keep this from happening again. Very unsafe condition due to fumes and risk of fire. No warning lights just a very strong fuel smell and fuel leaking from under the vehicle.

Filed Jan 23, 2026 · Fuel system · FL

On January 16, 2026, the 2021 Atlas had a severe gas leak and a large pool of gas was observed underneath the vehicle. The vehicle was towed to the VW dealership in Bradenton, FL. The dealership stated they needed to take the car apart as it was suspected the fuel injectors were leaking. After disassembly, the technician stated the #3 fuel injector had a severe leak and there was so much gas, he couldn't be certain if fuel injectors #1 and #5 may also have issues but recommended replacing all 3 fuel injectors and the fuel rail. The repair cost was $3300, which was not covered by my warranty as it expired 6 months prior. History of issue - shortly after purchasing the vehicle in June 2021, a gasoline smell was noticed when parked in the garage. On October 19, 2021, the vehicle was taken to VW in Bradenton for the gas smell, they could not replicate the issue and replaced the charcoal canister. After the replacement, a gas smell was still noticeable and taken back to VW. VW again said they could not replicate the issue and stated nothing was wrong with the vehicle. It was noticed there was a previous the federal safety agency investigation on this issue. This is a serious issue and the car could have caught on fire. A large amount of gasoline was leaking from this vehicle.

Filed Dec 8, 2025 · Fuel system · CA

Gas tank melted on top of the tank next to drive shaft and a hole was leaking gas- we are keeping the tank that was removed for investigation. Extreme safety issue that put my daughter and granddaughters at risk of fire/explosion when it was unknown that there was a gas leak while driving. The part was inspected by a repair shop in Lake Havasu AZ as well as the Capistrano Volkswagen, CA dealership and no explanation of the cause. Since the vehicle is out of warranty the VW.com and the dealership refused to replace without full charge. Insurance claim has been filed. There were no warning lamps messages or other symptoms of the failure. About 45 miles prior to gas leak detection, while fueling, the reverse pressure shutoff did not work, and a significant amount of gas was released at the station. No indication of a leak from the gas tank until the car stopped, then significant release onto the ground was observed.

Filed Aug 29, 2024 · Fuel system, Transmission · OR

In May I brought the vehicle to the dealership because the vehicle was turning off at low speeds (exiting a parking lot) or switching from Drive to Reverse. This was in conjunction with the check engine light coming on. The dealership diagnosed it as a fuel sensor failure, which they told me was safe to drive, and they'd order the part. I went back the next week when the sensor had been received and the repair was made. Last week, the low fuel alert flashed when I knew the vehicle was not low on fuel. The alert was not stable for a few days (it turned on and then turned back off, and then on again), and the vehicle started to have the same issue of stopping at low speeds. I had it towed to the dealership because I was too worried to drive it. The dealership diagnosed it with a 'swollen and leaky gas tank'. They sent photos upon request and the gas tank appears to have a tear. It is not due to any accident or road debris. The VW dealership has recommended a complete gas tank replacement, and let me know the gas tanks are on back order and did not have a date it would be available. This is extremely dangerous situation because 1. it was leaking gas and 2. it was coming to a stop. I drive around children (my own and others) and I can't imagine if something had happened while I was in driving around a car of kids. I read on different sites (Reddit and other car sites) and it seems the stopping problem with the Atlas is somewhat common, unfortunately. I am curious if it's due to a bad gas tank or if it is a separate malfunction with the vehicle. I called the Volkswagen Care Line and was told that they were sorry, but my vehicle was no longer under warranty, so they were unable to give me any information or guidance.

Filed Jul 25, 2024 · Fuel system · FL

Object, too small to be seen or causing sound on impact while driving on HWY, ruptured the gas tank, making it loose gas / heavily dripping gas. No warning on car computer. I did not notice the leak until arriving at my destination and I don’t really want to think about what could have happened. Gas dripping could have caused car go up in flames, causing severe damage to passengers, other vehicles, other people. Car was inspected at VW dealership, gas tank needed complete replacement. Same dealership advised same day another VW came into the dealership with exact same issue. VW states no warranty. I’m seriously wondering if VW gas tanks are made of such weak material / are insufficiently protected to cause such a huge safety concern.

Filed Sep 14, 2022 · Fuel system · MI

While driving my 2019 Volkswagen Atlas, there was a sudden and significant loss of power accompanied by a check engine light and "ECP" warning light. My engine was sputtering and and would not accelerate. I immediately needed to pull off the road as it was not safe for other drivers. I turned the car off and then back on. The "ECP" light went away but the CEL remained and the engine still had a noticeable sputter. I brought my car to a local VW dealer for inspection. They diagnosed the issue as a faulty fuel injector that needed immediate replacement. Any further damage could cause a fuel leak which may lead to a fire hazard. They told me this was a known issue with VW Atlas'. After doing some further research, I see that an the federal safety agency investigation has already been issued regarding this issue. There are multiple Atlas owners who have reported the exact same issue. I reported this to VW customer service today and they told me they did not consider this a widespread issue, and until a recall is issued, there is nothing they can/will do. There have been no issues with the car prior to this, and this issue occurred out of the blue. It is extremely frustrating because, not only is this resulting in an insanely expensive repair, but my son was in the car with me when the car suddenly lost power on a busy highway. This is a significant issue impacting a larger population of VW owners. Thankfully for us, this was caught before there was a major fuel leak and danger of fire like many others have reported.

Filed Jan 10, 2022 · Fuel system · PA

While driving on Saturday, Jan 8, 2022, my Atlas started leaking fuel. It felt like it just down-shifted on its own and the gas pedal stopped working. We were simultaneously overcome by the smell of gasoline inside the car. Both the engine and EPC warning lights were on. Thankfully, I was just about to pull into my driveway when this happened, so I was able to safely stop and we exited vehicle immediately. the entire engine was smoking and fuel was pouring out of the engine onto the ground. It eventually slowed to a drip. I called my local VW dealership but it was closed so I left a message. I also filled out on online service request the next day.

Filed Oct 4, 2021 · Driver assistance, Engine · LA

Volkswagen Dealership of Lake Charles, LA attempted to repair a safety recall on catalytic converter. When I picked my car up for the safety recall on the catalytic converter my car smelled like fuel and was leaking fuel and would not stay running and stopped running while driving in traffic and at stop lights and intersections. The dealership has had my vehicle for 3 months and still not repaired my recall correctly and I just got it back today October 4th and the problem remains unresolved. I attempted to back out into traffic and my car stopped running and there was incoming traffic. Luckily me and my 2 daughters were not hurt however this car is not safe and request the dealership fixes the safety recall correctly.

Filed Sep 27, 2021 · Fuel system · CO

After starting the car, saw a start-stop assist error, but car seemed to start up normally. The car was slow to accelerate. Then a strong smell of gasoline followed by the EPC and check engine light. Pulled the car over and turned it off. Very strong smell of gasoline. Then noticed the gasoline leaking under the car. My safety was definitely put at risk as fuel leaks around ignition sources can cause fires. Luckily this time I was alone in the car. Had the vehicle towed to the dealership. Was told the issue was the fuel injector and happened at the factory. Manufacturer is aware of the issue. Dealership has replaced the fuel injector.

Filed Sep 27, 2021 · Fuel system · CO

This is the second time I've had the same issue with the fuel injectors. This time I was driving with my two children in the car when I started the car the start-stop assist error came on again and I smelled gasoline. The EPC and check engine lights then came on. I immediately pulled over and got the kids out of the car and away from the car as the gasoline smell was very strong. I checked under the car and it was again leaking gasoline. This is obviously a very big safety risk. There is a large risk of fire from the fuel leaking around an ignition source as well as the fumes and headaches me and my children suffered due to the gasoline fume exposure in an enclosed space. I again called a tow truck and they towed it to the dealership. I called and they said it was indeed the fuel injectors again and they will do a more thorough check this time. I will elevate the issue with VW.