Volkswagen Atlas fuel smell problems

Filed Aug 24, 2026 · Fuel system · OK

Fuel line leak due to the angle the manufacturer line is coming out of the fuel tank. Rubbing on the line caused a wear on the line, gas leak and has to be repaired and rerouted by mechanic to keep this from happening again. Very unsafe condition due to fumes and risk of fire. No warning lights just a very strong fuel smell and fuel leaking from under the vehicle.

Filed Jan 23, 2026 · Fuel system · FL

On January 16, 2026, the 2021 Atlas had a severe gas leak and a large pool of gas was observed underneath the vehicle. The vehicle was towed to the VW dealership in Bradenton, FL. The dealership stated they needed to take the car apart as it was suspected the fuel injectors were leaking. After disassembly, the technician stated the #3 fuel injector had a severe leak and there was so much gas, he couldn't be certain if fuel injectors #1 and #5 may also have issues but recommended replacing all 3 fuel injectors and the fuel rail. The repair cost was $3300, which was not covered by my warranty as it expired 6 months prior. History of issue - shortly after purchasing the vehicle in June 2021, a gasoline smell was noticed when parked in the garage. On October 19, 2021, the vehicle was taken to VW in Bradenton for the gas smell, they could not replicate the issue and replaced the charcoal canister. After the replacement, a gas smell was still noticeable and taken back to VW. VW again said they could not replicate the issue and stated nothing was wrong with the vehicle. It was noticed there was a previous the federal safety agency investigation on this issue. This is a serious issue and the car could have caught on fire. A large amount of gasoline was leaking from this vehicle.

Filed May 15, 2025 · MS

My 2019 Volkswagen Atlas 3.6L has shut off multiple times while driving, including once at 55 mph. I consistently receive a “Stop/Start System Error” message at startup. As of today, the check engine light has come on and there is an extremely strong smell of gasoline at the rear of the vehicle after driving. The fuel smell is intense enough to make me concerned about fire risk. I have young children, and this is my only vehicle. The combination of engine stalling, an active check engine light, and a raw gas smell poses a serious safety hazard to my family and others on the road. This appears to match known issues under VW’s recall 20V716000 for cracked fuel injectors and TSB 01-23-09 for engine control software glitches. I am requesting that the federal safety agency investigate whether more 2019 VW Atlas vehicles—including mine—should be included in these recalls, and whether VW is providing adequate support to affected families. I cannot safely drive my vehicle, and I cannot afford a rental. This is an urgent public safety concern.

Filed Jan 21, 2025 · Engine, Fuel system · SC

The first issue at 26k miles when the coolant light turned on. It was a broken head gasket which required the replacement of the full motor on the vehicle. After the motor was replaced, the vehicle had to be taken back to the dealership that completed the work on 3 different occasions for installation concerns including a loose bolt and low coolant levels. The second issue at 33k miles was the failure of the charcoal canister which ruined the fuel tank lining, resulting a replacement of the fuel tank. This issue caused the car to stall anytime it was idle (if I was in traffic and not able to accellerate or in a parking lot going slowly, it would stall requiring it to be put into park and restarted. This issue was a huge safety concern since my car would shut down in traffic. No indicator lights came on during this issue. Next, at 37k miles, I smelled terrible gas fumes each time the car idled. At one point, when blowing my nose, I had black soot residue, so I can't imagine what I was breathing or the risk of the vehicle catching fire with such strong fumes. I had to take the car in twice before they took me seriously. The car had broken O rings from the engine replacement. No indicator lights came on for this issue either. Last week, we received the car back after 33 days in the shop for ANOTHER broken head gasket. Within a day of getting the car back, it misfired and the check engine light was on again. The car does not accellerate correctly which poses a safety risk when trying to pull out into moving traffic or cross oncoming traffic. Volkswagen corporate office is well aware of all the issues but declined the buy-back process because we don't fall under our state's lemon laws.

Filed Jan 10, 2022 · Fuel system · PA

While driving on Saturday, Jan 8, 2022, my Atlas started leaking fuel. It felt like it just down-shifted on its own and the gas pedal stopped working. We were simultaneously overcome by the smell of gasoline inside the car. Both the engine and EPC warning lights were on. Thankfully, I was just about to pull into my driveway when this happened, so I was able to safely stop and we exited vehicle immediately. the entire engine was smoking and fuel was pouring out of the engine onto the ground. It eventually slowed to a drip. I called my local VW dealership but it was closed so I left a message. I also filled out on online service request the next day.

Filed Oct 27, 2021 · Fuel system · 26,000 miles · NY

The contact owns a 2019 Volkswagen Atlas. The contact stated that after starting the vehicle, the electronic power control and check engine warning lights were illuminated. In addition, there was a fuel odor in the vehicle. The vehicle was taken to the dealer where it was diagnosed that the high-pressure fuel injector needed to be replaced. The vehicle was repaired however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed that the top fuel rail assembly was leaking and needed to be replaced. The vehicle was repaired however, the failure recurred. The vehicle was taken back to the dealer where it was diagnosed that the bottom fuel rail assembly was leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 26,000.

Filed Oct 17, 2021 · Engine, Fuel system · IA

3200 miles on vehicle and ECP light came on. Heavy smell of gasoline and vehicle went into limp mode. Gas was pouring out the bottom of the hot engine and dripping onto the ground below. Opened the engine hood and there was lots of smoke or steam. Seriously concerning for a fire.

Filed Oct 4, 2021 · Driver assistance, Engine · LA

Volkswagen Dealership of Lake Charles, LA attempted to repair a safety recall on catalytic converter. When I picked my car up for the safety recall on the catalytic converter my car smelled like fuel and was leaking fuel and would not stay running and stopped running while driving in traffic and at stop lights and intersections. The dealership has had my vehicle for 3 months and still not repaired my recall correctly and I just got it back today October 4th and the problem remains unresolved. I attempted to back out into traffic and my car stopped running and there was incoming traffic. Luckily me and my 2 daughters were not hurt however this car is not safe and request the dealership fixes the safety recall correctly.

Filed Sep 27, 2021 · Fuel system · CO

After starting the car, saw a start-stop assist error, but car seemed to start up normally. The car was slow to accelerate. Then a strong smell of gasoline followed by the EPC and check engine light. Pulled the car over and turned it off. Very strong smell of gasoline. Then noticed the gasoline leaking under the car. My safety was definitely put at risk as fuel leaks around ignition sources can cause fires. Luckily this time I was alone in the car. Had the vehicle towed to the dealership. Was told the issue was the fuel injector and happened at the factory. Manufacturer is aware of the issue. Dealership has replaced the fuel injector.

Filed Sep 27, 2021 · Fuel system · CO

This is the second time I've had the same issue with the fuel injectors. This time I was driving with my two children in the car when I started the car the start-stop assist error came on again and I smelled gasoline. The EPC and check engine lights then came on. I immediately pulled over and got the kids out of the car and away from the car as the gasoline smell was very strong. I checked under the car and it was again leaking gasoline. This is obviously a very big safety risk. There is a large risk of fire from the fuel leaking around an ignition source as well as the fumes and headaches me and my children suffered due to the gasoline fume exposure in an enclosed space. I again called a tow truck and they towed it to the dealership. I called and they said it was indeed the fuel injectors again and they will do a more thorough check this time. I will elevate the issue with VW.