Dt: consumer was driving and a cloud of smoke came from behind steering wheel. Prior to this vehilce had been running hot. Consumer took vehicle to dealer for a coolant flush, and had the belt replaced around the fan. Also, had a new radiator installed. Consumer was in the car 5-10 minutes and the vehicle overheated. The fire department came out when the steering wheel smoked.
The worst 1992 Volkswagen Corrado problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Visibility32
- Engine12
- Electrical4
- Transmission3
- Brakes2
- Lights2
- Acceleration1
- Body1
- Fuel system1
- Steering1
- Tires1
Specific symptoms reported on the 1992 Volkswagen Corrado
Recalls 3
Engine and engine cooling: cooling system
- What is wrong
- Vehicle description: passenger vehicles equipped with vr6 engines. A coolant system component such as the thermo switch, radiator fan, or water pump, can malfunction causing the coolant temperature and coolant system pressure to increase significantly. Over time, excessive pressure can cause leakage of coolant fromthe system, including leakage from the heat exchanger.
- Risk
- Leakage of hot coolant from the heat exchanger can cause injury to the feet of the driver or steam up the interior of the vehicle temporarily impairing the driver's vision.
- Remedy
- Dealers will install in the coolant inlet hose to the heater core, a pressure reducer with a 5mm diameter secured by a spring tensioned hose clamp. Also a new relay that will change the operation of the secondary electrical coolant pump will be installed. Dealers will also perform a functional check of the cooling system to make sure that all cooling system components operate properly.
Recall number 98V295000 · Recall details
Electrical system: wiring: front underhood
- What is wrong
- An engine compartment electrical wiring harness may have been routed too close to a sheet metal edge. The wiring can become damaged during normal vehicle operation due to chafing, resulting in an electrical short.
- Risk
- If a short occurs, either the engine could stall orthe radiator fan could stop operating causing the engine to overheat. Eithercondition could result in a vehicle accident.
- Remedy
- Reroute and secure various wiring harnesses inside the engine compartment.
Recall number 93V102000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- The fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.
- Risk
- Fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.
- Remedy
- Replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.
Recall number 92V058000 · Recall details
See all 3 recalls for the 1992 Volkswagen Corrado
Defect investigations
Heater core repture
Heater core allegedly ruptures and releases hot coolant into the vehicle interior, resulting in impaired visibility and potential burn injuries to occupants.
EA98012
Heater core rupture
Heater core allegedly ruptures and releases hot coolant into the vehicle interior, resulting in impaired visibility and potential burn injuries to occupants.
PE98006
Technical service bulletins for the 1992 Volkswagen Corrado 11
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The part number listed in the document is to be returned if it meets the criteria provided.
- This special notice is to inform dealers to return all part numbers listed in the document and order the...
- Vas 6154
- This communication is to update our ProFi dealers of the current status of the latest inbound and outbound...
- Update model year applicability to include 2017.
- Airbag Issues.
- This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates,...
- This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates,...
- Volkswagen: exhaust heat shield, replacement guidelines
- Subject regarding latch system lower anchors and tethers for children, installing / retrofitting
1992 Volkswagen Corrado fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.8L 4‑cyl | FWD | 17-18 | 25-26 | 20-21 |
| 2.8L 6‑cyl | FWD | 15-16 | 21-23 | 17-19 |
What 1992 Volkswagen Corrado owners say
Most recent owner complaints, unedited.
Consumer had the same problem as mentioned in the federal safety agency recall 98v295000. Passenger vehicles equipped with vr6 engines. A coolant system component such as the thermo switch, radiator fan, or water pump can malfunction, causing the coolant temperature and coolant system pressure to increase significantly. Over time, excessive pressure can cause leakage of coolant from the system, including leakage from the heat exchanger. Dealer indicated this vehicle was not include in the recall due to the VIN.
The vehicle experienced the same defect with the engine cooling system as stated in recall 98 v 295 000, but the VIN number was not included.
The temperature gauge flashed. The consumer heard a noise, and at that point the vehicle's cabin became filled with steam and hot radiator fluid was on the floor board. It was determined the heater core failed.
Heater core recall repairs done. 1 year later it broke, causing radiator fluid to leak and front windshield to steam up.
Recall work performed and failure immediately occurred. Ruptured heater core repaired, but car is unsafe to drive due to coolant fumes. Dealer refuses to fix recall 98v295000.
My heater core failed spilling radiator fluid into the passenger compartment and vapor through the HVAC system.. I have been told this is a part that consistantly failed in my type of vehicle and am hoping that the manufacturer of the vehicle will be responsable and replace the part as a recall issue.
Fog lights overheat. Vwoa has refused hella oem fog light replacement design. Heated outside rear view mirror delaminates.
Heater core located behind ventilation system blew up, hot coolant hit vent and white smoke and coolant entered into vehicle, chemicals were very strong. Took vehicle to dealer ,and they will replace heater core, consumer indicated that he could have been injuried, because liquid was hot,consumer was temporarily blinded by white smoke.*ak consumer stated the dealer finally replaced the heater core after numerous complaints.
Ignition switch and the heater were repair with used parts and still failed.
Compare the 1992 Volkswagen Corrado
Other model years
Questions about the 1992 Volkswagen Corrado
Is the 1992 Volkswagen Corrado reliable?
Owners have filed 48 complaints about the 1992 Volkswagen Corrado, 1.2 times a typical Corrado model year.
What is the most common problem with the 1992 Volkswagen Corrado?
Windows, wipers and visibility, with 32 complaints. Next is engine (12).
How many recalls does the 1992 Volkswagen Corrado have?
3 recalls, covering engine and engine cooling, electrical system and fuel system, gasoline.
What year does the Volkswagen Corrado have the most visibility problems?
The Volkswagen Corrado model years with the most visibility complaints are 1992 (32 complaints), 1993 (20 complaints) and 1990 (10 complaints).
What gas mileage does the 1992 Volkswagen Corrado get?
Official estimates for the 1992 Volkswagen Corrado range from 17 to 21 mpg combined. The most efficient version (1.8L 4-cyl, FWD) gets 17-18 city and 25-26 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1992 Volkswagen Corrado?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history