2000 Volkswagen Eurovan problems

Filed Jan 28, 2016 · Seat belts, Seats · 216,312 miles · WA · 1 injury

I was driving in town on a city street on my way to church and the drivers side seat heater burned through and melted my coat a little bit. My back felt burned a little bit but went away after awhile so I did not have any lasting pain. But my good church coat was left with a slighty melted area on it. The passenger side did not burn because the heater doesnt work anymore.

Filed Dec 7, 2015 · Fuel system · 180,000 miles · CA

The issue with the vehicle is that an excessive amount of pressure and heat builds up inside the gas tank while driving at any speed and to even a greater extent when in stop-n-go traffic or sitting in the parking lot idling. The result is that when opening the gas cap from hot fumes and fuel spray out after running the vehicle for less than an hour. There are no check engine lights or checks in place to warn or prevent this from happening. It is a major safety concern! I have been working with the vw dealer for over one year now but still no resolve. Under the direction of vw of america their certified mechanics have systematically replaced almost all of the components relating to the fuel system but to no resolve. At this point the problem still persist and the dealership is reluctant to acknowledge that the gas tank is actually heating up even though they have reproduced the results in their shop. I do have a video of the problem in action but am unable to share that with you through the document uploading system. By the way I am the original owner of the vehicle and have always had it serviced at the certified vw dealership.

Filed Aug 1, 2008 · Engine · 97,000 miles · IL

Fan for cooling the air conditioning unit (in engine compartment) blew apart, damaging electronic components adjacent to it. The other fan (for engine cooling) failed last year.

Filed Sep 26, 2007 · 30,000 miles · CA

Tl*the contact owns a 2000 volkswagen eurovan. The contact stated that the metal bracket, which holds the luggage rack onto the vehicle, was rusted. The manufacturer was notified and stated that it was caused by the weather. The current mileage was 90,000 and failure mileage was 30,000. Updated 10/18/07

Filed Jun 22, 2007 · Engine · 89,000 miles · IL

Engine cooling fan on driver's (left) side broke and lost a piece, causing the fan to become unbalanced. The lack of balance caused severe vibration in the car. Car is currently in the shop for repair (replacement) of the fan.

Filed Sep 18, 2006 · Seat belts · 76,000 miles · MI

My kid pulled on his seat belt to fasten it, and the male latch came detached from the belt. The latch is made by trw-automotive, the world's largest provider of seat belt systems. It has the following identification: 0006 5980 trw. The seat belt that failed is a lap-belt only (center-seat). The latch consists of two sliding metal parts and a plastic cover. When the plastic cover breaks, the belt comes loose from the male latch. The seat belt can fail in a crash resulting in injury from the crash. I reported this to vw customer care, 800‑822‑8987. They entered it into their database, and told me to go to a vw dealer to get a repair.

Filed Nov 24, 2005 · Engine · 61,000 miles · CA

My wife, on a recent drive from no. California to southern ca noted an unusual sound from under the hood. No overheating or other issues though. When she stopped she noted one of the plastic radiator fans was broken in multiple pieces. Since she was away from home I told her to go to the local dealer for repairs. They decided the entire fan assembly had to be replaced, and that the radiator had to be replaced as well. The parts alone were about $2300 total repair for this about $2900. When they returned the car she found that the AC was no longer working. So back to the dealer. They stated the AC compressor was bad (btw the AC worked well prior to the radiator event) so the compressor and evaporator/dryer were replaced another $1200 approx. Then upon returning home to no. Cal. The AC still didn't work. Now we went to the local dealer and they stated the high and low pressure hoses to the AC were bad and needed to be replaced, parts alone $750 the dealer in long beach did kick in $300 for the labor and $150 for the freon recharge. The story continues... Then the AC failed again. This time I noted that the right fan was rewired improperly and running backwards. This was rewired by the oakland dealer and thus far the AC seems to be working though sometimes it is loud. The initial fan disintegration is a defect and this has lead to a constellation of problems requiring new fan, new radiator, new AC. A radiator fan should not spontaneously disintegrate at 60.000 miles. This defect has been reported multiple time on your website and this should be a covered defect in these vehicles.

Filed Sep 21, 2005 · Engine · 28,718 miles · WA

2000 volkswagen eurovan engine cooling fan broke apart.*mr while driving the vehicle began to vibrate violently. The consumer pulled off to the side of the road to inspect the vehicle. Upon inspection he noticed that one of the cooling fans had broken. The consumer did some research about found out that 1998-2000 eurovans had been recalled for the exact same problem but the consumer's vehicle was not included due to VIN.

Filed Aug 10, 2005 · Engine · 50,000 miles · PA

Three times in the last 3 years (2003-2005) I have had to replace my engine cooling fans on a 2000 vw eurovan, twice because they exploded. In each case additional damage was incurred due to the flying pieces of fan. The vw dealers (in nj, va/fl, and pa) asserted that there was no history of this occurring, despite correspondence between vw and the federal safety agency in 2003.

Filed Jun 13, 2005 · Lights, Visibility · 93,000 miles · NH

Dt:I brake light will come on . When the brake light comes on the headlights go off/the windshield wipers stop functioning, and air conditioner (A/C) stops. The new dealer could not find cause of the problem, and claimed that it was normal. It was happening quite frequently. Consumer has teenage children, and if this had happened on the interstate,one of my children could have died. If headlights had been turned on, and if I consumer pulled on them high beam would stick and stay on. Consumer would only have high beams. Also, the windshield wipers will come on.