2016 Volkswagen Golf: fuel leak

Filed Apr 23, 2025 · Fuel system · TX

I was driving my vehicle on the highway when a driver stopped me and warned me that my vehicle was leaking a huge amount of gasoline. I had a technician inspect the car to see if it might be a fuel line, the technician told me the fuel.lines were good and there were no signs of the gas coming from the lines and no cracks on the tank either. I received a letter from Volkswagen about the recall and I researched it and it says that if that is the problem the car would be leaking gas and it was dangerous as an ignition might cause a fire. I towed my vehicle to the Volkswagen here in Laredo after calling and speaking to someone from service and told yes I could bring it in and the recall part would be replaced free but I would have to leave the vehicle there. When I arrived they told me I would have to pay a diagnostic of 185 dlls and the repair. Which was not what I was told when I called earlier. So I had to pay again to have the vehicle removed from the premises without having the recall part changed.

Filed Jun 17, 2024 · Fuel system · 41,000 miles · TX

The contact owns a 2016 Volkswagen Golf. The contact stated there was fuel leaking from the charcoal canister. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

Filed May 14, 2024 · Fuel system · VA

My vehicle is leaking fuel. I have been unable to drive it for a few weeks due to the recall not having an approved repair. The dealership did not offer me any solution other than to pay for the repair out of pocket. This has been a known issue since February and no remedy is available from Volkswagen.

Filed Apr 19, 2023 · Fuel system · IN

Fuel was found to be leaking from the rear passenger side wheel well. A secondary flame source could cause a significant fire risk. Issue is being investigated by local VW dealer. There are no warning lamps or messages prior to the failure. Dealer recommends a replacement of the charcoal filter and N80 valve in order to have the ability to test the fuel pressure and fuel pump. My particular VIN number is not part of an existing recall on the fuel pump where fuel leak, bad charcoal canister, and N80 valve are symptomatic (secondary failures) of a bad fuel pump (primary failure). I question if the parts under the existing recall should be expanded to include a larger population.

Filed Jan 30, 2023 · Fuel system · FL

Fuel leaking and pooling from the rear right tire well. Tire well saturated with fuel. Occurs after engine hesitation at high speeds, similar to running out of gas. Opening the gas cap causes some fuel splashing around the opening and gurgling and hissing sounds. Difficulty re-fueling after incident, gas pump keeps shutting off. Fuel siphon pump was tested, and vehicle has been inspected by dealership, problem is not reproducible on demand. No warning lamps turn on.

Filed Oct 20, 2022 · Fuel system · CA

Fuel leaking and pooling from the rear right tire well. Tire well saturated with fuel. Occurs after engine hesitation at high speeds, similar to running out of gas. Opening the gas cap causes some fuel splashing around the opening and gurgling and hissing sounds. Difficulty re-fueling after incident, gas pump keeps shutting off. Fuel siphon pump was tested, and vehicle has been inspected by dealership, problem is not reproducible on demand. No warning lamps turn on.

Filed Jul 18, 2022 · Engine, Fuel system · TX

The car had a few hiccup on the freeway. Eventually the car had a strong gas smell, did not allow to add/fill up gas and was leaking gas at the back of the car. The car could have caught fire without us knowing. The problem was reproduced and known to the dealers. The second dealer Hewlett had seen another 3 cars with same issue as my car! Please see all invoices showing the parts and issues with car. suction pump in the fuel tank, fuel pump gasket, purge valve, evap canister, N80 valve. There is a recall for same issue but my car was never recalled! Recall 16V647000 Summary Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system. Recall 16V647000 Consequence As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire. Recall 16V647000 Solution Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1‑800‑893‑5298, Audi owners may contact Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5.

Filed Nov 22, 2021 · Fuel system · FL

While parked the gas tank started leaking gas from rear passenger-side wheel well.

Filed Sep 21, 2021 · Fuel system · NV

Volkswagen Group of America, Inc. "Volkswagen" is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions "EVAP" system. As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire. VW is not honoring the recall in my vehicle because it notes that my VIN number is not associated with the defected part, but this is the same issue that happened to my vehicle.

Filed Dec 27, 2020 · Fuel system · 28,000 miles · UT

Raw fuel smell in cabin. It seems to happen after a short trip. I stop and restart within a few minutes and it is quite a heavy smell like a fuel leak. This has happened before this month.

Filed Aug 22, 2019 · Fuel system · 31,546 miles · PR

Tl* the contact owns a 2016 volkswagen gti s 4d auto. While driving 45 MPH, the contact noticed an abnormal fuel odor coming from the fuel tank without warning. The contact managed to drive the vehicle and noticed fuel leaking from the fuel tank. The vehicle was towed by the contact's insurance company to flagship volkswagen carretera (#2 14.7, bayamn, 00922, puerto rico, 787‑302‑2718) where it was diagnosed that the evap system failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 31,546.

Filed Mar 13, 2019 · Engine, Fuel system · 37,000 miles · NJ

Tl* the contact owns a 2016 volkswagen golf gti. The contact stated that the check engine warning indicator illuminated intermittently. The vehicle was taken to an independent mechanic who diagnosed that there was a fuel leak. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 37,000.