Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carpet shampooing, and extended airing out over several weeks. Dealer dismissed concerns and suggested owner pay for cabin filter replacement which had no effect. VW's own Recall 20UF documentation acknowledges that fuel odor may be noticed by occupants when the recall condition exists. Requesting investigation into whether recall repair was fully completed and whether odor is related to incompletely resolved recall condition. A neighbor experienced identical odor issue after bringing their Tiguan to a different Westchester dealer for service.
Volkswagen Golf fuel smell problems
33 of the 1,387 owner complaints about the Volkswagen Golf describe gas smell in the cabin, most of them for the 2017 model year.
- owner complaints
- 33
- worst model year
- 2017
- typical mileage
- 42,000
By model year
Often reported together
Fuel leak 15Fuel pump 5Check engine light 4Jerking 3Hesitation 3Loss of power 2Stalling 1
What owners say
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he took it for a drive her drove “conservatively” and the mpg was normal. They did not physically inspect the fuel pump jet and gaslit me saying it was how I’m driving. Refused to actually look at the problem and then threatened that if I wanted them to look they would charge me for the labor. They did not seem concerned that a safety hazard of smelling fuel in the cab and poor fuel efficiency was an issue.manager said he knew of the active extended recall but hid behind the no code from their scanner instead of listening to the customer who voiced concerns. They didn’t want to do the work if they had to pay for it.
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during acceleration, and a powerful raw gasoline smell inside the cabin immediately after fueling. These symptoms heavily align with the known physical failures covered under Volkswagen's Suction Jet Pump safety campaigns. I took my vehicle to the Volkswagen dealership today for a diagnostic inspection. The service manager initially dismissed my complaints, refused to physically check the EVAP charcoal canister or suction pump, and claimed that my 50% drop in fuel economy was merely due to my 'driving style.' However, upon forcing me to pay a $136 diagnostic fee to retrieve my keys, the official paperwork provided by the dealership directly contradicted the manager. The technician documented finding a physical fuel leak. Alarmingly, this is the exact same 'small fuel leak' that this specific dealership claimed to have fully repaired a few months ago. That previous visit occurred because my steering wheel completely locked up while driving, nearly causing a severe accident—an issue the dealership also dismissed at the time because it 'failed to throw an error code.' The dealership has demonstrated a reckless pattern of ignoring severe mechanical safety hazards—including steering failures and active, recurring fuel leaks—solely because the vehicle's computer does not register a digital fault code. I am trapped driving a vehicle that is actively leaking fuel, smelling of raw gas inside the passenger cabin, and suffering from dangerous acceleration hesitation due to an unresolved fuel-system defect. I request a formal investigation into this ongoing safety hazard and the dealer's failure to remedy it.
I brought my 2015 Volkswagen (with only 50,000 miles) to Island Volkswagen in NY for a fuel system recall repair. Before this, the car had no fuel smell, no leaks, and was driving normally. Immediately after the recall work, I began smelling fuel. The dealership told me the fuel line is leaking and needs to be replaced. I never had this issue before, and it’s clearly related to the repair they performed. I’m now being told I must pay $550 out of pocket for something I believe was caused by their handling of the fuel system during the recall. This is a serious safety concern. If I drive this car and something goes wrong, it could result in a fire. I believe this issue deserves review, especially if other drivers experience similar problems after this recall.
The contact owns a 2015 Volkswagen Golf. The contact stated while driving at an undisclosed speed, the fuel gauge level dropped quickly, and there was an abnormal fuel odor before the vehicle shutoff in the middle of the roadway. The contact stated that the check engine warning light was illuminated. The contact exited the vehicle and push the vehicle to the side of the road. The contact stated that while checking underneath the vehicle, the contact became aware of a fuel leak. The vehicle was towed to an independent mechanic to be diagnosed. The independent mechanic confirmed the fuel leak and referred the contact to the dealer for assistance with the repair. The vehicle was not yet repaired. The contact referenced the federal safety agency Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE) as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 111,000.
Vehicle had recall for "leaking fuel fire risk" Strong smell of fuel inside car. Manufacturer recall #20UF the federal safety agency recall 24V110 There has not been a fix yet available. Dealer (Team Volkswagen Merrillville IN) replaced the Jet fuel pump. Problem continued, VW engineering said bring the car back and replace the entire fuel tank. Completed. Problem returned 2 weeks later (XXX). While driving home from work noticed extremely strong fuel odor in car. Pulled off in a store parking lot, someone ran up and told me my car was leaking fuel. Gas was literally pouring out, I lost 1/4 tank of fuel on way home. The fuel was leaking under hood, under fuel tank area and under the rear passenger seat. I had the car towed to the dealer. Volkswagen does not have an actual fix for the problem. I should be given a replacement car due to Volkswagen being unable to correct this serious safety issue. What should I do, I am afraid to take the car back. I have videos and several pictures but unable to upload onto this website. Call [XXX] Crown Point Indiana INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Volkswagen Golf. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while starting the vehicle, there was an abnormally strong fuel odor inside the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank suction jet pump had failed, causing damage to the fuel tank. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,018. VIN tool confirms parts not available.
***DATE OF OCCURRENCE: 07/03/2023*** SOLUTION REQUIRED IMMEDIATELY: I have been without a working vehicle for nearly 1 full year without recourse. ONE YEAR! Initially the recall for the exact suction jet pump issue did not include 2017 GTI models. I was furious. Repair estimates I received ranged rom $2,000-4,000 to replace the entire fuel system. Being unable to afford this, I was forced to leave it parked and completely unusable. I even had to change my car insurance to "garaged" status to avoid paying premium on a vehicle I couldn't even drive. I am extremely disappointed in the timeline for this recall. I'm glad that the recall for suction jet pump issue now includes my vehicle's year, but a repair solution is needed immediately. INCIDENT DESCRIPTION: Vehicle began losing engine power a day or so before the incident. I was driving home and noticed the intermittent engine power issue. Thankfully, I was not far from home. As I approached my neighborhood gate, I rolled down the window to enter the code. That's when I smelled a strong fuel odor. There were NO indicator lights or warning lamps displayed on my dashboard panel that suggested an issue with my vehicle. I looked around nearby for lawn maintenance trucks, suspecting they were refueling or had potentially spilled fuel from their equipment. As I pulled into my parking space and exited the vehicle, I immediately noticed fuel streaming down from the inside of the wheel well and pooling on the ground below the gas tank door. Honestly, it was a really scary experience. I was afraid for my safety. It looked like my car could explode at any moment. The only good news is that my gas tank was relatively low on fuel so the spill didn't last long. I have not started my vehicle since the incident, nearly 1 year ago. It's a gut punch every day to see it parked, unusable AND have to continue paying for it. Please issue a repair solution for this recall immediately. Thank you.
VW is not acting fast enough to fix the active fuel tank suction jet pump recall, given the immense danger risk. The recall was issued a month and a half ago - they should have the parts available now to fix it. I have noticed fuel smells while inside and driving my car on and off for several months now!! I took my car to their dealership yesterday to get their faulty water tank replaced and when I asked about the recall I was completely dismissed and they said they had no idea when the parts would be available. I need my car to get to work. I can't just stop driving it but it feels incredibly unsafe to drive now that I know about the recall!
The contact owns a 2016 Volkswagen Golf. The contact stated while driving approximately 35 MPH, there was an abnormally strong gasoline odor in the cabin of the vehicle. The contact drove to the residence and became aware that there was a puddle of gasoline under the passenger’s side rear wheel nearby the fuel tank. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.
Related recalls
Fuel system, gasoline
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1‑800‑893‑5298 or Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V‑647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V‑647.
Recall number 24V110000 · Recall details
Fuel system, gasoline
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
- Risk
- As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1‑800‑893‑5298, Audi owners may contact Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V‑110.
Recall number 16V647000 · Recall details
Fuel system, gasoline: fuel injection system: fuel rail
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2016 Jetta vehicles manufactured October 31, 2015, to January 21, 2016, 2016 Passat vehicles, equipped with 1.8T engines manufactured November 13, 2015, to December 9, 2015, and 2016 Golf vehicles manufactured November 5, 2015, to November 11, 2015. In the affected vehicles, the fuel rail may detach from the cylinder head and result in a fuel leak.
- Risk
- A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
- Remedy
- Volkswagen will notify owners, and dealers will replace the cylinder heads, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Volkswagen customer service at 1‑800‑822‑8987. Volkswagen's number for this recall is 15F7.
Recall number 16V403000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Golf, and GTI manufactured on February 17, 2014, to May 22, 2014, and Audi A3 manufactured on February 16, 2013, to April 23, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
- Risk
- If the fuel pump fails, the vehicle will not start, or if the engine is running, it will stop and the vehicle will stall, increasing the risk of a crash.
- Remedy
- Volkswagen will notify owners, and dealers will inspect the vehicles and replace any affected fuel pumps, free of charge. The recall began on June 16, 2015. Owners may contact Volkswagen at 1‑800‑893‑5298 or Audi at 1‑800‑253‑2834.
Recall number 15V229000 · Recall details
Fuel system, gasoline: fuel injection system: fuel rail
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2014, to November 20, 2014, and 2014-2015 Beetle and Beetle Convertible vehicles manufactured March 31, 2014, to November 27, 2014. A sealing cap at the fuel rail may fail, allowing fuel to leak into the engine compartment.
- Risk
- A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
- Remedy
- Volkswagen will notify owners, and dealers will replace the fuel rails with new parts, free of charge. The recall began February 6, 2015. Owners may contact Volkswagen customer service at 1‑800‑822‑8987. Volkswagen's number for this recall is 24BL. Note: This recall expands and supersedes recall 14V‑809 (Volkswagen recall number 24Bi) and only affects vehicles not previously repaired under that campaign.
Recall number 15V028000 · Recall details
Fuel system, diesel
- What is wrong
- Volkswagen is recalling certain model 2009-2012 jetta and jetta sportwagen vehicles, manufactured from may 2008 through september 2011, model year 2010-2012 volkswagen golf vehicles, manufactured from may 2009 through september 2011, and model year 2010-2012 audi a3 vehicles, manufactured from september 2009 through september 2011, that are equipped with a 2.0l tdi common rail diesel engine/clean diesel engine. The fuel injection pulses could coincide with the natural frequency of the injector line #2, in specific load and RPM conditions. This resonance creates additional stress in the fuel line.
- Risk
- Due to the resonance condition, injector line number 2 could develop small cracks which could lead to fuel leakage. Leaking fuel in the presence of an ignition source, may lead to a fire.
- Remedy
- Volkswagen will install an improved fuel injector line for the number 2 cylinder on certain vehicles and will install vibration dampers on all of the injector lines. Volkswagen and audi will notify owners to have the vehicles repaired free of charge. The safety recall is expected to begin during november 2011. Owners may contact volkswagen at 1‑800‑822‑8987.
Recall number 11V490000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- On certain passenger vehicles equipped with gasoline engines and double-layer fuel tanks, tension on the fuel supply line may cause the fuel pump supply nipple to crack which could result in a leak.
- Risk
- Leaking fuel, in the presence of an ignition source, may cause a fire.
- Remedy
- Dealers will inspect the fuel supply line for tension, and inspect the fuel pump supply nipple for cracking. If necessary the fuel line and the fuel pump will be replaced free of charge. The recall began on july 25, 2005. Owners may contact volkswagen at 1‑800‑822‑8987.
Recall number 05V154000 · Recall details
Fuel system, diesel
- What is wrong
- On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.
- Risk
- Fuel leakage in the presence of an ignition source may lead to a fire.
- Remedy
- Dealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact volkswagen at 1‑800‑822‑8987.
Recall number 04V586000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- The fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.
- Risk
- Fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.
- Remedy
- Replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.
Recall number 92V058000 · Recall details
Questions about the Volkswagen Golf fuel smell
Which Volkswagen Golf years have gas smell in the cabin problems?
The model years with the most reports are 2017 (8 complaints), 2016 (7 complaints) and 2015 (5 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Volkswagen Golf?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history