2002 Volkswagen Passat suspension problems

Filed Aug 28, 2018 · Fuel system, Lights · 174,000 miles · SC

Headlight pigtails have melted ,fuel pump has gone ,and the plastic reservoir peice from my coolant pump has melted off driver side wiper arm bar has malfunctioned

Filed Mar 23, 2010 · Suspension · 82,010 miles · MI

Broken left front suspension coil spring - spontaneously broken - car left undriven in closed private garage for ~2 weeks, found after ~2 weeks listing at left front corner with left front coil spring broken.

Filed Jun 1, 2009 · Suspension · 72,000 miles · PA

I am writing to complain about the control arms on the vw 2002 passat. I recently replaced an upper and lower control arm on the right and now have been told that I need to replace three of the four control arms on the left side. I fell these are a safety issue.

Filed Mar 20, 2009 · Suspension · MA

We have a 2002 1.8l passat that was affected by the defective coils in the 2003/2004 recall. Now less than 5 years later, 2 coils failed at once with complete loss of power and all 4 need to be replaced. Luckily we were driving were we could safely get out of traffic but if it had happened on the highway, we could have been killed. I wonder if the replacement coils were also defective.

Filed Feb 24, 2009 · Body, Suspension · 15,000 miles · CA

Tl*the contact owns a 2002 volkswagen passat. The contact took the vehicle to the dealer for a recall repair and was informed that other repairs were also needed. Prior to the recall being issued, the vehicle was experiencing the same symptoms stated in the recall. The vehicle is currently at the dealer to have the motor mount and cv boot repaired. In addition, there is a rubber component that needs to be repaired. The contact would like to know why she began experiencing so many issues with her vehicle at 15,000 miles. The federal safety agency campaign id number was unknown. The failure mileage was 15,000 and current mileage was 44,000.

Filed May 17, 2005 · Suspension · 53,995 miles · KY

I have my oil changed every 5000 miles as suggested. At 48,880 miles my oil was changed with know problems. At 53880 miles my oil change again. But at this change I was told that the front axel boots were cracked and needed to be changed. I asked since it was just 3,000 miles past warranty if this would be covered. Both the dealer and volkswagan said no. I had the axel boots fixed. But after speaking to many people no one has ever heard of axel boots breaking at 53,000 miles. I believe this must be defect with the car, since both axel boots broke at the same time.

Filed Apr 20, 2005 · Body, Brakes · TX

2002 volkswagen passat experiencing problems with passenger seat, door panels, glove compartment, radio equipment, buttons for the mirror equipment and the vehicle kept cutting off.*mr the consumer stated when the passenger seat went forward it would not stop, the heated seats burned the consumers children, however he did not state how many children. The vehicle could not be aligned. The door panels and arm rest were peeling. The headlights were always going out. The brakes squeaked. The battery, generator and ground wire were replaced due to vehicle stalling.

Filed Feb 24, 2005 · Suspension · 70,000 miles · AZ

Complete failure of steering control arms. Wheel shakes like it is going to fall off, this is a common problem with the volkswagen passat and vw will not warrant this issue or perform a recall. This is a very dangerous situation.

Filed Oct 25, 2004 · Body, Suspension · 35,000 miles · CA

Front end/engine protector has separated from vehicle while driving. *bf in both cases, the turn bolts on the left front and right side separated. A single central screw bolt at it's front then supported the air dam. The plastic around it finally tore under vibration and air pressure forces.

Filed May 13, 2004 · Suspension · 15,000 miles · TX

I had problems with the faulty ignition coil two times and the second time, they replaced all the coils. Here in texas, when the temperature goes down below 28 f ( which is very rare) I am afraid.I can be stuck in the road. Hope the coil problem wont happen again. I also have problem with the brakes. Its making creaking sounds with the parking brake / hand brake. The technition told me that its natural..I cant beleive that. I gues I have to spend lot of money in near future to replace all those brake parts. Also the metal beeding on the roof is coming up. It is not causing any problem, but I have to push it hard almost everyday. I guess vw never tested the car for long time. So far I found so many complaints about passat. Hope they will improve it.