2009 Volkswagen Routan transmission problems

Filed Nov 14, 2019 · Acceleration, Electrical · 21,432 miles · NJ

Even after rebuilding the entire transmission, every time the vehicle is placed into reverse, there is a pause, then a jarring as it slips into r gear; but every time acceleration is attempted in r, there is a delay, followed by consistent lag; if attempting to r up an incline, if speed is not already over a specific minimum, vehicle then assumes action as if it is in n. Even an incline slope of simply backing into a driveway, if vehicle is not entirely across the incline, it's not possible to continue controlling a reverse movement, though engine responds as though in n. This has been an ongoing issue; that has persisted even after rebuilding the transmission. Another issue that began several years ago; is that the door's locking mechanisms for several of the doors, no longer operate properly. Locking via key fob, or door panel, does not actually engage the door to lock. Nor does unlocking the doors via key fob, or door panels.

Filed Sep 14, 2019 · Transmission · 106,672 miles · IA

Car won't go more than 50 miles per hour

Filed Feb 14, 2019 · Transmission · 128,000 miles · PA

Vehicle shuts off automatically while driving. No specific temperature outside, no specific time of day, just shuts off more then once while driving to locations.

Filed Nov 13, 2018 · Engine, Transmission · 115,226 miles · MA

Tl* the contact owns a 2009 volkswagen routan. While driving between 30 to 65 MPH, the vehicle randomly jerked forward and backward as if it were skipping a gear. In addition, the check engine indicator illuminated afterwards several times. The contact spoke with two unknown dealers and then contacted an independent mechanic where it was diagnosed that the underdrive solenoid circuit of the transmission was malfunctioning. After conducting some research, the contact found that the manufacturer placed a chrysler engine and transmission into her volkswagen vehicle. The independent mechanic completed the repairs with another new chrysler transmission solenoid part. While the contact was driving on the highway, the vehicle lost complete acceleration and had to be pulled over to the shoulder of the road. The vehicle was towed back to the independent mechanic, but had not yet been diagnosed or repaired. The manufacturer provided case number: 181899879 and the federal safety agency's phone number to file a complaint. The failure mileage was 115,226. *tt

Filed May 22, 2018 · Electrical, Transmission · 75,000 miles · OR

Tl* the contact owns a 2009 volkswagen routan. While driving 40 MPH the contact noticed the transmission was stuck in third gear. The dealer was not notified of this failure. The manufacturer was notified and informed the contact that they were not able to assist. The VIN search reveled no recalls. The vehicle had not been diagnosed repaired. The failure mileage was 75,000.

Filed Feb 21, 2018 · Brakes, Steering · 120,000 miles · WA

We were driving the vehicle when all of the sudden it stalled! There is no check light on and when it does this we lost all power breaking and steering. This almost happened to us around an elevated corner luckily we had just past the curve when we lost all power. In reading this is a common problem on the town and country routan grand caravan and all associated models. Something should be done due to the danger and potential risk to human life! We bought this van to keep our children safe not have to worry of it will loose power steering at 30 MPH in a canyon corner!

Filed Feb 13, 2017 · Transmission · 85,900 miles · GA

The vehicle has only 85800 miles and when driving in the highway at about 75 to 80 miles, the vehicle loses power and may cause a bad accident. When driving in the city street, the vehicle does the same thing. It loses power

Filed Oct 28, 2016 · Transmission · TN

I bought my vw routan used in september 2014. In the 1st couple of months the transmission would stop shifting (I would turn it off and back on) to fix it and in november 2014 the transmission went out and got stuck in 3rd gear while driving and wouldn't reset after turning off, this is when the check engine light came on, at 62,000 miles. Had to have a new $6000 transmission brought in from germany to be put in the van. Now less than 30,000 miles later after a new original transmission put in, having the same problem not shifting out of 3rd gear and having to pull it over turn it off and turn it back on for it to work properly again.

Filed Aug 21, 2016 · Driver assistance, Electrical · 65,000 miles · VA

*sometimes the vehicle will not start for no apparent reason.vw service dept. Cannot detect an issue. *engine light comes on intermittently while driving-vw cannot detect anything wrong.* alarms go off but no signal showing on the dashboard.*power windows and seats work intermittently- *found vehicle's sliding door wide open I parking lot, twice. * have also found windows open. Our lift gate (trunk) opened while driving on the highway.* vehicle failed to shift,while driving, revved and would not reset until pulling over and turning off the vehicle. Though vw could not find faulty readings and didn't believe tipm is the issue because they couldn't read it. Being familiar with programming, I know that glitches can cause faulty readings.if there is a glitch before the reading can be processed by the computer, there will be no faulty reading logged. A pc won't save a file, either if the power supply is interrupted before it can do so..tipm malfunctions can also cause all other issues I have experienced. Upon getting a second opinion from transmission specialists, they said only the solenoid was faulty. They also confirmed that a faulty tipm box will cause solenoid issues and eventually ruin the new one, too. *recently, all locks stopped working & the vehicle can only be opened & locked manually. At the same time all interior lights were on and had to be turned off at the dashboard- this would have drained the battery had it happened on a work day. Vw has had the vehicle for 2 full days and yet doesn't know what's wrong with it. We have had these issues and useless repairs for over 2 years. All issues point to faulty tipm (manufactured by chrysler, who had to settle in a lawsuit about the tipm box/ faulty relay issue for jeep, dodge, and chrysler). We need help with these issues. Too many of us have it 2011 and 2012 models as well. Please help.

Filed Jun 28, 2015 · Electrical, Fuel system · 52,577 miles · FL

I driving last month 47 MPH and my driving sliding door open and my 8 years girls was dear and she scare when the door open when I driving ,, and when I stop the door not want to close automatic..that scare me and my wife... The other concern is my transmision hard shiffting ,hard shiffting , I ready take like 5,6 time my van to check my transmission and my sliding door and the say is normal , and my sliding door not found anytime , they say the sliding door recall was done ready,, the other big concern is the gas mileage, only 11 or 12 gallon for miles they did a lot test and not found nothing ,,is poss to 16 MPH for gallon and never have that,,.... Thanks.