2004 Volkswagen Touareg: headlights failing or too dim

Filed Oct 24, 2024 · Lights · OH

Hello: this is the 2nd VW TOUAREG this year to repair so far, this one is a 2004 model that I have had to replace complete left & right xenon headlamp assembly Very pricy. Wiring insulation turns brittle, cracks & falls off inside the headlamp assembly, This allows the bare wires to touch & short causing fuses to blow shutting off headlamps while driving at night. This I think should be recalled, I have fixed 5 of these TOUAREGs in 4 years for this same problem. THANK YOU 10/24/24

Filed Apr 24, 2023 · Electrical, Lights · TX · fire

My SUV was sitting for a few days at the airport and I when I got in the car, it started fine but the headlights, interior lights, power folding mirrors and the voltmeter were not working. I had to leave the car there since it was night time. The next day I drove it home in daylight and started checking fuses. I noticed two fuses (#2, #12) on the driver side fuse panel were failed. I replaced the #2, 5 amp, fuse and no changes were noticed. Then I replaced the #12, 25 amp, fuse and I heard a number of systems clicking and powering on; the lights flickered. Then I smelled burning and saw a puff of smoke come from under the dash. I immediately pulled the fuse . After troubleshooting, I found the body control module 7L6-937-049-K had caught fire internally and started to burn through the casing. Had I not pulled the fuse and disconnected the battery, this could have been catastrophic. Once I smelled the smoke, I realized it was like the acrid smell in the suv the night before. The fact the fuse blew the previous day saved the vehicle. It was parked on the fourth floor of parking garage at the airport so many vehicles could have been damaged and people endangered had it caught fire. Not to mention the disruption at an airport. There were no warning lamps. The only indication of a problem was the inoperable systems I mentioned. Also thinking back, the slight acrid smell was present the day I arrived at the airport, I had mistaken it for plane exhaust and car exhaust smells in the garage. The vehicle has not been inspected by any dealer, manufacturer or govermental agency. I have contacted the manufacturer for guidance and help with repairing. I am awaiting a response.

Filed Nov 25, 2021 · Electrical, Engine · AL · fire · 1 injury

Leaking gas caught on fire put it out but now I have no head lights no high beams replaced everything still nothing. All lights on dash go crazy kills battery all the time and had to replace something in the rear end. Overall it has cost me $2500 and I still have no headlights at all and leaking gas. It’s my only vehicle I hope next time it doesn’t catch back on fire could have been worse and still could be. Somebody could get hurt and I have kids.

Filed Nov 7, 2018 · Lights · 150,000 miles · PA

The headlight assemblies on this vehicle fail due to the internal wiring inside of the housing. This leads to zero visibility during night time. The headlights when operating correctly also do not produce enough light output to be able to see during the night even with a brand new assembly.

Filed May 9, 2018 · Lights · NC

The headlights continuously short out and stop working. The wires on the headlights have no insulation because it has fallen off. This problem has been fixed multiple times and still continues to happen. I contacted the local vw dealership and was not helped. I contacted vw corporate office and no help. There was a class action suit against vw for this very issue. More than once it has left my dad stranded because he had no headlights to drive home with.

Filed Mar 11, 2017 · Electrical, Lights · 140,232 miles · IN

About 2 weeks ago, I started blowing fuses for the drivers side turn signal. I would have no front or rear turn signal, as well as no hazards on the drivers side. I looked inside the headlight assembly and found that all the wiring was exposed due to the wiring insulation rotting off, leaving exposed wiring. I am a firefighter, and this is a vehicle fire, waiting to happen. You cant even wrap electrical tape around it, due to the headlamp unit not being able to be taken apart. I have no left turn signals, and risk being hit, sideswiped, or getting a ticket from the police for something I cannot fix. I have replaced 4 different fuses now trying to fix this.

Filed Feb 11, 2016 · Lights · 50,100 miles · FL

Defective headlights in 2004 vw touareg, lights go out periodically while you are driving. This was an issue covered by a class action lawsuit. Now vw won't even talk to you about it and refers you to an 800 number that was disconnected years ago. This is a major safety issue and vw is running away from their liability. Typical behavior for vw.

Filed Apr 27, 2014 · Lights · 75,000 miles · PA

This is a problem impacting a large percentage of 2005-2006 vw touaregs with hid headlights. Wire in headlamp assembly is to small for load. The insulation decays due to heat and results in a short which will blow the fuse for affected headlight. Usually occurs when switching on high beams or hitting a large bump. While there is an inexpensive diy fix, outlined in below link, vw is telling owners they need to spend $950 per headlamp to replace the assembly. Http://www.clubtouareg.com/forums/f43/touareg-dead-xenon-fix-code-01344-a-103130.html.

Filed Mar 30, 2007 · Brakes, Electrical · 100 miles · MA

Tl*the contact owns a 2004 volkswagen touareg. The warning tone of the tire pressure monitoring system sounds intermittently. In addition, the headlights failed, and the vehicle pulled to the right sporadically and without warning. The dealer was unable to diagnose the cause of failure. The contact possessed the repair invoices. The failure mileage began at 100. *ak the consumer stated the failures continue, she has had multiple problems with this vehicle brake rotors replace at 15,000 miles, brake pads had to be replaced at 18,000 miles, two tires replace at 16,000 miles, tps lights continue to go on and off been fixed, four new tires at 30,000 miles. The consumer states that there have been 9 recalls and tps lights still in failure. Update 05/04/07

Filed Jul 20, 2006 · Lights, Tires · 76,000 miles · IL

Dt*: the contact stated while driving the vehicle the passenger side or driver's side headlight darkened. There were no warning indicators or dashboard lights illuminated to indicate there was a failure with the headlight(s). Eventually, the other headlight darkened. The only way the lights would illuminate again is by restarted the ignition. The dealership replaced a computer chip, changed the bulbs and other unknown repairs were made, however the problem still persists. Updated 8/14/2006 - the tire warning light illuminated. The dealer replaced the control unit.

Filed Mar 24, 2005 · Visibility · 19,000 miles · CA

This headlight washer(s) that pop up from front bumper came off during drive from ca to md. During the drive back temperature went into the freesing range. Was not aware that when wash the windshield these other washers pop up to washer the headlight. Anyways, they do and due to cold it got stuck in up position and eventually came off. Dealer initially said covered under warranty and now says that since have a scratch on side bumper someone tempered with the washer. However more importantly they said that it has never happened to anyone before. I said maybe not yet or in different region since this was when driving in much colder weather. Also, they also confirmed that it stucks in the down position when they put in a new one.