2015 Volvo S60: engine failure

Filed Oct 27, 2026 · Engine · TX

Low Engine Failure with a 🐢 and had it repaired back in September '25 that costs me over 7k. Now it's worse and doing the same thing with 145k miles

Filed Jan 10, 2024 · Engine · PA

Was on the highway driving back from my aunts house and there were no signs anything was wrong with my car. No alerts on the dash besides low pressure tire which I filled up. As I was almost home, an alert randomly came up with “no oil pressure” along with a check engine light flashing and the car started shaking (misfiring). The car flashed a message that said something about reduced engine performance. As my car was shaking fervently, it was slowing down and failed to accelerate, causing cars behind me to almost crash. No oil pressure can also cause fires and put my life at risk. I had much time left to get my oil changed and yet I had oil message lights come on. I believe this is a problem with the piston rings that are defective & there was just recently a class action suit of them. I have had to continually fill up oil, and now I suddenly have an engine that does not work and threatened the safety of myself and others on the road. Volvo diagnosed the issue as being valve broken, piston ring damage, along with other engine components. I now need an entire new engine.

Filed Aug 17, 2023 · Engine, Fuel system · SC

I bought the car as a CPO on 9/25/19 32,860 mi. On 8/19/20 at 50,052 the engine failed. The oscillating dampener rubber separated causing serpentine belt to break, which in turn got caught in timing belt which caused that to break which then caused bent valves and valves to break. The failure was sudden. Had I been on the interstate I’d be severely injured or dead. I was told that I needed a new engine but they could not find one. I was told they would completely re-build my engine. In the end they replaced the cylinder head and starter under warranty. I was never told they didn’t re-build the engine and also used “ good parts” from the old engine. In the following months I had the car in the Volvo shop (Hendricks Volvo Charleston, SC). At 50,277 miles the check engine light showed a problem with the Cam shaft position sensor on 9/3/20. They claim to have driven the car 100 miles and cleared the code w/no repairs. On 3/18/21 w/ 64,485 miles, I took the car into the dealer because it was running and idling rough. They found no codes and they aligned the car. “Couldn’t duplicate”. The right rear door never shut properly and I was repeatedly told it was fine. Re-call on latches. Seat belts on rt rear passenger constantly was stuck. This is where my granddaughter’s car seat was placed. I’ll have to skip some. At 110,024 miles on 11/28/22 the car continued to have bad gas mileage and heavy oil use. I was told that the EGR leak detection pump was faulty and was replaced. At 113,706 miles on 1/19/2023 the cam VVT Solenoid was changed. Cause of poor gas mileage stated. On 3/29/23 at 116,790 miles replaced brakes and had aligned. Service tech noticed oil under the car underside while up on racks. Said it would be fine until next service. On 7/3/23 the engine failed again on the road and was towed to the dealer. Apparently a fuel injector failed causing gas to spray into the engine causing it to lose compression. I’ve never been given a clear answer. Records of services done.

Filed Feb 26, 2021 · Engine · 80,000 miles · PA

My car was excessively burning oil. It required multiple oil changes and I wasn't notified of the low oil until the oil was nearly empty. Volvo performed tests to confirm I had an oil consumption issue that cost over $500. The initial repair was to replace the piston rings. Now they've told me the pistons are scored from the lack of oil/consumption and I require a new engine. The lack of notifications of low oil and the damage to my engine pose a safety risk. I know this issue is occurring across a wide range of volvos.

Filed May 5, 2020 · Engine · 46,370 miles · GA

Driving vehicle at normal speed (45mph) when engine shut off entirely. Vehicle flashed brake controller failure and was able to be coasted to a stop on a side street. Power steering had failed at the time as well. The vehicle was unable to be restarted. Vehicle had 46370 miles at the time of the incident and had its previous oil change around 45000 miles. After replacing a battery and starter, it began making rod knock. The vehicle was towed to the dealer, where they said it needed a new engine, and was 2 quarts low on oil. Https://www.youtube.com/watch?v=hctl6_sz0cs.