While driving brakes locked up, key was stuck in ignition, and electronic system was down.
The worst 1998 Volvo WG problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical2
- Brakes1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical2
- Brakes1
Recalls 6
Exterior lighting: tail lights: switch
- What is wrong
- Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
- Risk
- It may not allow the driver of a rearward approaching vehicle to have full view of the lamps.
- Remedy
- Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began october 31, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1‑800‑528‑6586.
Recall number 02V238000 · Recall details
Service brakes, air: antilock
- What is wrong
- Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Risk
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
Recall number 00V232003 · Recall details
Parking brake
- What is wrong
- Vehicle description: heavy duty trucks equipped with haldex manifold dash valves (mdv) used in tractor and trailer parking brakes. These valves do not meet the requirements of fmvss no. 121, "air brake systems." a loss of the isolation of the two brake system circuits can result in the loss of service brakes when there is another failure of one of the two brake circuits.
- Risk
- The loss of service brakes can occur, increasing the risk of a crash.
- Remedy
- Dealers will replace the suspect valves.
Recall number 00V002002 · Recall details
Steering: linkages
- What is wrong
- Vehicle description: heavy duty trucks equipped with a fal 8.0 front steer axle. The upper steering arm can fail without warning.
- Risk
- This condition can result in the loss of steering control, increasing the risk of a crash.
- Remedy
- Dealers will inspect the upper steering arm and replace it, if required.
Recall number 98V297000 · Recall details
Suspension: front: springs: air suspension: lines and fittings
- What is wrong
- Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
- Risk
- This condition would result in increased stopping distances.
- Remedy
- Dealers will install the necessary air pressure protection valve.
Recall number 98V255000 · Recall details
Wheels: rim
- What is wrong
- Vehicle description: heavy duty trucks equipped with aftermarket aluminum dual wheels, 22.5x8.25, one-piece, tubeless, supplied by accuride/akw. Certain design revisions combined with process conditions caused fatigue cracks in these wheels.
- Risk
- This condition can cause failure of these wheels.
- Remedy
- Accuride/akw will replace these wheels.
Recall number 98V120001 · Recall details
Technical service bulletins for the 1998 Volvo WG 21
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
What 1998 Volvo WG owners say
Most recent owner complaints, unedited.
Consumer complained about problems with the whole wiring harnness for the engine compartment. Manufacturer was contacted, and they only gave the run around.also, dealer was contacted and stated that they would try to help consumer, but has not as of yetheard from him.
Compare the 1998 Volvo WG
Other model years
Questions about the 1998 Volvo WG
Is the 1998 Volvo WG reliable?
Owners have filed 2 complaints about the 1998 Volvo WG, close to a typical WG model year.
What is the most common problem with the 1998 Volvo WG?
Electrical system, with 2 complaints. Next is brakes (1).
How many recalls does the 1998 Volvo WG have?
6 recalls, covering exterior lighting, service brakes, air and parking brake.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Volvo WG?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history