2022 Volvo XC60: screen or infotainment failure

Filed Sep 28, 2026 · Electrical · NY

This has happened multiple times, confirmed by the dealer that it is a know issue with no fix. While driving down the road, the digital dashboard goes completely blank. No speedometer, no fuel guage, nothing. Very dangerous when driving to not know the speed that you are travelling. Also, all audio cuts out - no blinker signal sounds, no radio, etc. Less concerning is the infotainment system going completely black and silent as well - radio, maps, climate control. There have been multiple recalls performed but the dealer but none of them has fixed the issue. This must be a MJAOR safety concern when the dash does completely blank while traveling 65mph down the highway.

Filed Sep 4, 2026 · Driver assistance · GA

Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display home button for 20–30 seconds, but the complete audio failure recurs every few drive cycles.

Filed Jul 16, 2026 · Acceleration, Driver assistance · 40,000 miles · WA · crash · 2 injuries

The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, the federal safety agency Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000

Filed May 12, 2026 · Electrical · NY

Re: Demand for repurchase or replacement under warranty — VIN [XXX] Vehicle: 2022 Volvo XC60 (pre‑certified) Purchase date: 08/19/2024 Dealer: [Dealer name, [XXX] ] Dear Volvo Cars USA Customer Care: I am the owner of the above-referenced vehicle. Since the date of purchase (08/19/2024) the vehicle’s infotainment system has repeatedly failed: it shuts down and reboots frequently (as often as 10 times within one hour of normal driving). Each shutdown disables navigation, HVAC controls and Bluetooth, and on reboot I must reset settings. This defect creates a significant safety hazard while driving, especially in unfamiliar areas. Since purchase I have returned the vehicle to the dealer for diagnosis and repair on multiple occasions. The vehicle has received software updates approximately 3–4 times, most recently on05//05/2026. The problem persists. I have retained copies of all repair orders and service records documenting these visits. (Copies attached.) This recurring failure remains unresolved despite multiple repair attempts and continues to present a SERIOUS safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 23, 2026 · Driver assistance · PA

2022 Volvo XC60 T8 Recharge VIN: [XXX] Mileage at time of complaint: ~38,400 Purchased: November 2023 (Certified Preowned) DESCRIPTION OF PROBLEM: The vehicle's infotainment system and backup camera have experienced repeated failures since the time of purchase. The backup camera intermittently fails to display an image when the vehicle is placed in reverse, leaving the driver without rear visibility. The infotainment system freezes, goes black, or becomes unresponsive without warning. These failures affect the federally mandated rearview camera display required under FMVSS 111. The vehicle has been brought to authorized Volvo retailers (Jim Fisher Volvo, Portland, OR and Germain Volvo North Hills, Wexford, PA) more than eight times for in-person service for this concern. The same issues have also been troubleshot remotely by phone or text on approximately ten additional occasions. Software updates, system resets, and other attempted repairs have not permanently resolved the problem. On one occasion, the backup camera failed to display while reversing, which contributed to minor rear bumper damage. The driver was relying on the camera display as designed and federally required, and the system did not perform. I am aware that the federal safety agency Recall 25V282 (Volvo R10320) was issued in April 2025 for this defect across 413,000+ vehicles including the 2022 XC60. Despite the recall, the underlying infotainment and camera reliability issues in my vehicle have not been resolved. A second recall (25V392) was issued after the initial software fix caused braking concerns in some vehicles. No injuries have occurred. No crashes have occurred beyond the minor bumper contact described above. Volvo Customer Care Case #XXX was opened and a goodwill assistance request was denied. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 29, 2026 · Electrical, Locks · 30,000 miles · AZ

The contact owns a 2022 Volvo XC60. The contact stated that while operating the vehicle, the instrument cluster display screen independently reset and then displayed a blank screen. During the failure, the driver was unable to view the speedometer and the fuel gauge. There was no audible sound while activating the turn signal, and the doors failed to immediately lock and unlock while attempting to use the door switch. The vehicle was taken to the local dealer, but no cause for the failure was found. The contact stated that the failures recurred intermittently. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

Filed Sep 26, 2024 · Acceleration, Electrical · AZ

Case number 240821-000271 was opened on 8/21/24 with Volvo Car USA Support. I have three main concerns: 1) The infotainment system losing the favorites that I have saved in the Sirius application. This had been an intermittent problem that I had been having since I purchased the car. I finally took it into the service department at Volvo Cars of Gilbert on 1/7/23 for this problem (Invoice Number VOCS110975). The service department was unable to recreate the problem so they did nothing. 2)A complete car system reboot while I was driving on 6/10/24. As I was driving down the road the HVAC system shut off and the dash and infotainment system screens went blank. All car systems completely shut down except the engine. This was an extremely frightening experience as all of this happened with no warning whatsoever WHILE I WAS DRIVING. This is a huge safety issue! Within about a minute of driving like this the systems started to come back up. I proceeded home. The next morning I took the car to Volvo Cars of Gilbert again. They had the car for 5 days and performed a software update on the IHU (Infotainment Head Unit) (Invoice Number VOCS120164). 3)The failure of the infotainment system to update after starting the car and driving. This happened on 8/7/24 and I took the car directly to Volvo Cars of Gilbert again. The infotainment system was stuck on “Infotainment system starting…” for the entire 12-minute drive to Volvo. Volvo Cars of Gilbert had my car for 8 days this time and this time they did a reload to the existing IHU (Invoice Number VOCS121204). I asked that they replace the IHU. Volvo refused to replace the IHU because it was too expensive at $3200. Also, the problem of the infotainment system losing its radio favorites has become much worse. It happens daily now. I believe there is an opportunity for a catastrophic event to happen while I am driving if this IHU problem is not corrected immediately.

Filed Jul 18, 2024 · Driver assistance · MI

while attempting an OTA software update, the update failed. The instrument cluster was inoperative, it was a complete blank screen. Not able to tell how fast you were going, what gear you were in, how much gas you had. All features displayed on the instrument cluster were not available. Contacted Volvo to attempt a software reset, and all attempts were not successful.