Volvo XC60 screen failure problems

Filed Sep 28, 2026 · Electrical · NY

This has happened multiple times, confirmed by the dealer that it is a know issue with no fix. While driving down the road, the digital dashboard goes completely blank. No speedometer, no fuel guage, nothing. Very dangerous when driving to not know the speed that you are travelling. Also, all audio cuts out - no blinker signal sounds, no radio, etc. Less concerning is the infotainment system going completely black and silent as well - radio, maps, climate control. There have been multiple recalls performed but the dealer but none of them has fixed the issue. This must be a MJAOR safety concern when the dash does completely blank while traveling 65mph down the highway.

Filed Sep 4, 2026 · Driver assistance · GA

Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display home button for 20–30 seconds, but the complete audio failure recurs every few drive cycles.

Filed Jul 16, 2026 · Acceleration, Driver assistance · 40,000 miles · WA · crash · 2 injuries

The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, the federal safety agency Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000

Filed Jul 6, 2026 · Driver assistance, Electrical · VA

In the four months that I have owned this car, the following issues have occurred and have not been resolved: - Google Maps suddenly stopped working while navigating while I was driving on multiple occasions. - Bluetooth connectivity will disconnect suddenly and not reconnect - All audio in the car has stopped since 7/2/26. This includes turn signals, safety alerts, cross traffic alert. This has happened on at least 4 separate occasions (lasting 2 days or more) and usually resolves, but this has persisted. I have called the service department each time and been told there is nothing they can do about it and that I have to wait for a software update. I updated the software on 6/15/26 and the problem seems to have gotten worse. - Backup camera intermittently does not work and screen is black - Radio will freeze on station. Audio will change but screen will not. - Climate control does not work on auto. Fan will not adjust based on temperature, has to be adjusted manually even in auto mode. I am concerned for my safety and the safety of my children when driving in this vehicle. The electrical system has proven to be unpredictable, and my research has shown that this is not an isolated issue. The vehicle has been at a Volvo service center 3 times for this same issue and continues to have the same unresolved problems. There were no warning lamps or symptoms prior to the system malfunctioning, it happens while I am driving. This poses a hazard to me and to the people driving around me.

Filed Jun 21, 2026 · Driver assistance, Electrical · DC

I own a 2025 Volvo XC60 plug-in hybrid (PHEV). The vehicle has recurring software defects that create a serious safety risk. First, the infotainment and central control system repeatedly reboots while I am driving. On a single trip from Washington, DC to Burlington, Vermont, the system rebooted approximately 8 to 10 times. It has also rebooted within minutes of starting the vehicle during local driving. Each reboot blanks the center display, which disables the backup/parking camera and interrupts the speedometer and driver-information display, climate controls, and other functions. Losing these displays and controls while the vehicle is in motion is a significant safety hazard. Second, after installing a Volvo over-the-air (OTA) software update, the vehicle was rendered completely inoperable. It would not unlock or start and could not be accessed through the key fob or the Volvo Cars app, and it had to be towed to the dealer. Based on numerous owner reports, failed OTA updates that disable the vehicle this way are a known, recurring problem on these models. Third, the front and rear parking cameras have both cracked during normal use, with no impact damage, and the vehicle displays a "parking cameras need cleaning" message at nearly every stop. No crash or injury has occurred. I have reported these issues to the selling dealer and to Volvo customer care. The reboot and lockout problems are recurring and have not been durably resolved.

Filed May 12, 2026 · Electrical · NY

Re: Demand for repurchase or replacement under warranty — VIN [XXX] Vehicle: 2022 Volvo XC60 (pre‑certified) Purchase date: 08/19/2024 Dealer: [Dealer name, [XXX] ] Dear Volvo Cars USA Customer Care: I am the owner of the above-referenced vehicle. Since the date of purchase (08/19/2024) the vehicle’s infotainment system has repeatedly failed: it shuts down and reboots frequently (as often as 10 times within one hour of normal driving). Each shutdown disables navigation, HVAC controls and Bluetooth, and on reboot I must reset settings. This defect creates a significant safety hazard while driving, especially in unfamiliar areas. Since purchase I have returned the vehicle to the dealer for diagnosis and repair on multiple occasions. The vehicle has received software updates approximately 3–4 times, most recently on05//05/2026. The problem persists. I have retained copies of all repair orders and service records documenting these visits. (Copies attached.) This recurring failure remains unresolved despite multiple repair attempts and continues to present a SERIOUS safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 23, 2026 · Driver assistance · PA

2022 Volvo XC60 T8 Recharge VIN: [XXX] Mileage at time of complaint: ~38,400 Purchased: November 2023 (Certified Preowned) DESCRIPTION OF PROBLEM: The vehicle's infotainment system and backup camera have experienced repeated failures since the time of purchase. The backup camera intermittently fails to display an image when the vehicle is placed in reverse, leaving the driver without rear visibility. The infotainment system freezes, goes black, or becomes unresponsive without warning. These failures affect the federally mandated rearview camera display required under FMVSS 111. The vehicle has been brought to authorized Volvo retailers (Jim Fisher Volvo, Portland, OR and Germain Volvo North Hills, Wexford, PA) more than eight times for in-person service for this concern. The same issues have also been troubleshot remotely by phone or text on approximately ten additional occasions. Software updates, system resets, and other attempted repairs have not permanently resolved the problem. On one occasion, the backup camera failed to display while reversing, which contributed to minor rear bumper damage. The driver was relying on the camera display as designed and federally required, and the system did not perform. I am aware that the federal safety agency Recall 25V282 (Volvo R10320) was issued in April 2025 for this defect across 413,000+ vehicles including the 2022 XC60. Despite the recall, the underlying infotainment and camera reliability issues in my vehicle have not been resolved. A second recall (25V392) was issued after the initial software fix caused braking concerns in some vehicles. No injuries have occurred. No crashes have occurred beyond the minor bumper contact described above. Volvo Customer Care Case #XXX was opened and a goodwill assistance request was denied. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 4, 2026 · Driver assistance, Electrical · NH

System/Component Malfunction: Systemic failure of the onboard computer (Infotainment/Connectivity Module) and Advanced Driver Assistance Systems (ADAS), specifically the Collision Avoidance/Auto-Braking system, Rear-view Camera (FMVSS 111 non-compliance), and the 12V Battery management system. All components remain in the vehicle and are available for inspection. Safety Risk: The vehicle exhibits frequent "phantom braking" where the emergency collision avoidance system abruptly activates without obstacles present, creating an immediate risk of collisions. Additionally, the "hands-on steering wheel" sensor malfunctions, triggering emergency stopping procedures while driving. The backup camera intermittently fails (black screen), causing a total loss of rear visibility. These issues lead to unpredictable vehicle behavior in high-speed traffic. Confirmation & Inspection: These issues began to be reported to an authorized Volvo dealer within the first year of ownership (2022-2023). Most recently, a total vehicle failure occurred due to a drained 12V battery, which the dealer service department confirmed was caused by a known software module defect. Despite multiple "software updates" by the manufacturer, the safety-critical ADAS malfunctions (phantom braking) have recurred three times in the last week following the most recent dealer service.

Filed Jan 29, 2026 · Electrical, Locks · 30,000 miles · AZ

The contact owns a 2022 Volvo XC60. The contact stated that while operating the vehicle, the instrument cluster display screen independently reset and then displayed a blank screen. During the failure, the driver was unable to view the speedometer and the fuel gauge. There was no audible sound while activating the turn signal, and the doors failed to immediately lock and unlock while attempting to use the door switch. The vehicle was taken to the local dealer, but no cause for the failure was found. The contact stated that the failures recurred intermittently. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

Filed Sep 17, 2025 · Electrical · 3,000 miles · MA

The contact owns a 2025 Volvo XC60. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a blank screen. The vehicle was taken to the dealer, where it was diagnosed with an inoperable instrument cluster. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The dealer performed a software reboot; however, the failure reoccurred. In addition, the contact was informed that the instrument cluster failure was a known failure; however, there was no fix. The contact stated that the failure was a major concern while using the GPS. The contact stated that the failure was persistent. In addition, the contact stated that the failure had occurred while the contact and his wife were driving the vehicle. The contact stated that when the failure occurred, within several minutes, the instrument cluster independently reset. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 3,000.