Volvo XC60 seat belt problems

Filed Aug 6, 2026 · Airbags, Body · AZ · crash · 1 injury

The vehicle's Supplemental Restraint System (SRS) safety network experienced a total electrical blackout, resulting in complete airbag non-deployment during a severe unibody-deforming hit-and-run collision. The vehicle was stationary when a high-speed car rammed the passenger side and front profile. Kinetic forces split the cast aluminum steering rack housing completely in half, fractured front CV axle joint cages, and shifted the engine subframe mounts (creating physical gaps and shiny mechanical abrasions beneath the rust layer). Despite catastrophic structural distortion—which twisted the greenhouse safety cage and cracked the windshield directly beneath the laser cluster—zero front, side, or curtain airbags deployed. No dashboard SRS warning lights illuminated prior to or after the crash.A post-crash scan by a Master Mechanic confirms high-speed CAN-bus fragmentation, storing module timeouts U016700, U042268, and steering column resistance deployment inhibitors B1C0224, B1CO424, B1C0524. Additional codes include P134600, P134613, P261086, P0A0F68, C006468, B109B15, B116415, and B108467.Teardown reveals extensive, pre-existing saltwater intrusion residue inside passenger footwell fuse blocks (Centers B/C) and the under-hood relay box, plus green cupric carbonate oxidation on chassis grounds. This induced extreme electrical resistance, blinding the SRS module's ability to read the crash pulse. Occupant safety was heavily compromised; the driver sustained a severe concussion, whiplash, and active neurological time-loss blackouts after being struck by flying cabin cargo during the pulse. Both front seatbelt receiver buckles permanently bound and locked. The vehicle was inspected by local police under an active criminal hit-and-run report. Diagnostic logs are preserved and available for federal review.

Filed Jun 17, 2026 · Driver assistance, Seat belts · MI

I was completely stopped at a left turn. The rear collision sensor went off for no reason. The seat belt locked up so aggressively I could not get a breathe in and it ripped my insulin pump patch right off my stomach. If I was a couple hours away from home my blood sugar would go through the roof and cause ketones which could be fatal. Luckily I was 20 mins away from home. Being a [XXX] since [XXX] I am now [XXX] Volvo told me this is normal safety feature after inspecting the log. I don’t think it’s normal for collision sensors to go off while not moving as well as the seat belt aggressively pulling to the point were I can’t breathe and it rips off a life depending medical device right out of my stomach. If it is normal then they should have a warning for [XXX]. I’m currently trying to get out of the car lease completely as this feature could literally kill me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 13, 2026 · Airbags · MA

The driver's seatbelt buckle interlock stopped working, although engaged, and the auto's system no longer showed whether the seat belt was buckled up or not. This likely would have resulted in the passive restraint system not functioning if there were an accident. There are on-line comments about this same issue in this same model and year. The buckle was replaced at a cost of over $300 by the dealer and the dealer reported that there was a short or break in one of the wires. The vehicle has 87,000 miles at the present time.

Filed Mar 17, 2026 · Electrical, Seat belts · FL

I was driving home in my VolvoXC60. I think its a 2025 or 2024 model. I drive very safe and never do anything crazy when I drive. I came to a stop like normal at a red light and the screen said accident detected (specifically rear collision avoidance or rear collision something) and the seatbelt started crushing my chest and my body. It just continued to press down and crush me and the car wouldn’t let the seatbelt unbuckle like it was locked up. It was locked and basically just sucking her in with a very strong force. No car got close to me and I finally got it after like 2 minutes and drove home. I think its pretty unbelievable a new suv which is supposed to be very safe and reliable does that and appreantly and my chest is still very sore. Both dealerships near us don’t have a loaner car for a month. It was very scary and basically the car was crushing me for multiple minutes.

Filed Dec 28, 2024 · Seat belts · FL

Rear Center Seat seatbelt buckle does not latch.

Filed Dec 24, 2024 · Seat belts · MI

Passenger front seat belt no longer latches. Inserting latch plate into buckle and it does not latch.

Filed Aug 29, 2024 · Seat belts · NE

The contact owns a 2019 Volvo XC60. The contact stated while the vehicle was parked, the front passenger's seat belt retractor did not function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed front passenger's seat belt retractor. The contact was informed that the front passenger's seat belt needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was unknown.

Filed Oct 27, 2022 · Seat belts · MO

Since buying our xc60 Feb 2022, anytime we have our grandchildren we buckle their high back car seats in the rear seat of our volvo. Every time we install the car seats, the seat belts will not lock after being buckled. The implications of a seat belt failing to lock a car seat down could he catastrophic. It doesn't matter how many times we expand the belt and release it, tap the brake, buckle or unbuckle the belts will not lock. This poses a life threatening danger to children who are supposed to be safely secured in their seats. Coincidentally, the driver belt randomly locks sometimes even choking me if I lean forward quickly to get a better view. This happens without any sudden braking or change of speed. I have not visited a service center regarding the issue yet, I plan to address the issue at the upcoming vehicle maintenance and service appointment. Parents or caregivers need to be aware of this possibly dangerous failure. I check the belt tightness for our grandchildren car seats every time we stop. Until there is a resolution in place, I will attempt to find something that will keep the belt locked for a temporary solution. Please investigate for more possible complaints and issue a warning regarding this issue.

Filed May 25, 2021 · Seat belts · VA

This SUV. 2011 Volvo XC60 is our family travel vehicle. I had a bad scenario, The drivers side seat belt Buckle got stuck. Would not release, My girlfriend was in car trying to release buckle. This is not normal. its scary felling she told me. In a MVA. this may be a risk of stuck in car. The Dealer had replaced shoulder harness under recall. But My complaint was the seat belt buckle get stuck wont release. It seems to sit too close to seat I don't know why It was not replaced as an assembly. Does any record show seat belt buckle stuck issues and wont release.? Other than the Seat belt gets stuck wont release. My issue I think the buckle should be at a higher above lower seat to accommodate average size people.

Filed Mar 1, 2021 · Seat belts · OH

I have received two recall notices for defective driver and front passenger seat belt fasteners (the federal safety agency recall 20v‑378). The notices are dated 29 aug 2020 and 9 dec 2020. I have called the local volvo dealer repeatedly to schedule for completion of this recall. Each time they say they do not have the parts and apologize. In the meanwhile, the risk of the seat belt failing persists. More than six months have passed since the initial notice which I consider to be an excessive period of time. What can be done to expedite the completion of this recall? Any advice you can provide, or actions you could take would be appreciated. Thank you for consideration of this request. [xxx] cincinnati, oh [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).