1999 wabash trailer right rear trailer caught fire while on the highway. Consumer states that he pulled to side of the road disconnected the trailer and pulled the truck forward and the trailer burned to the ground. *kb the right front axle/bearings on the trailer were dry from lack of oil and the surrounding components overheated and caught fire. (ohio traffic crash report # 10-0258-90)
The worst 1999 Wabash Trailer problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Transmission2
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission2
- Suspension1
Recalls 4
Service brakes, air: supply: check valve
- What is wrong
- On certain trailers equipped with sealco spring brake control valve assemblies incorporated in arvinmeritor axles, part nos. 110700 and 110800, there is a recessed area on top of the valve in which a brass guide pin fits down inside the body of the valve and is held in place by a steel snap ring. The recessed area allows accumulation of water, dirt, and/or chemicals to build up behind the snap ring to the point where it will no longer contain the guide pin resulting in a failure of the air valve.
- Risk
- Failure of the valve in an empty or lightly loaded trailer while the vehicle is in motion could result in a hard application of the spring brakes, possibly locking up the trailer wheels and resulting in a vehicle crash.
- Remedy
- Sealco will provide a repair kit and installation instructions to customers free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact sealco at 602‑253‑1007 or wabash at 765‑771‑5404.
Recall number 03V314000 · Recall details
Suspension
- What is wrong
- Vehicle description: trailers equipped with conmet pregreased trailer axle hubs. The outboard bearing on the pregreased trailer axle hubs used with the tire inflation systems may fail due to the intrusion of contaminants through the tire inflation system.
- Risk
- An outboard bearing failure can result in a separation of the hub assembly from the spindle.
- Remedy
- Conmet is conducting the owner notification for this campaign. Authorized dealers are instructed to convert greased hubs to oil hubs if the tire inflation system is to remain on the trailer. If the tire inflation system is removed, the hub must be inspected for contamination and corrosion. The hub and bearing assembly must be replaced if there is evidence of corrosion. If there is no evidence of corrosion, lubricant and seal maintenance can be performed and the hub reinstalled. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact consolidated metco at 1‑800‑425‑4827 or wabash at 1‑765‑771‑5440.
Recall number 00V102002 · Recall details
Service brakes, air
- What is wrong
- Vehicle description: trailer axle suspensions installed on wabash national trailers were assembled with incorrect brake camshafts. These trailers will not comply with the deceleration or parking requirements of fmvss no. 121, "air brake systems."
- Risk
- The brakes will not function properly. These trailers will also have diminished stopping distance performance and reduced parking (hill holding) capability.
- Remedy
- The trailer owners (jb hunt) will inspect the axle suspensions and correct the brake camshaft condition.
Recall number 00V093000 · Recall details
Service brakes, air: supply: quick release valve
- What is wrong
- Vehicle description: heavy duty trucks equipped with brake valves manufactured by honeywell bendix. The orientation and location of the brake valve is such that water can get into the valve through a vent in the valve. The water will contaminate the air system and could freeze the brake valve.
- Risk
- If frozen, the operator will not be able to modulate the brake forces with the brake pedal.
- Remedy
- Bendix is conducting the owner notification for this recall. Owners are instructed to contact bendix at 1‑800‑478‑1793 to receive a replacement unit.
Recall number 00V127002 · Recall details
Technical service bulletins for the 1999 Wabash Trailer 1
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 1999 Wabash Trailer owners say
Most recent owner complaints, unedited.
1999 wabash trailer caught fire. Consumer stated that the fire was near the rear axle. Consumer tried and was unable to extinguish the fire. *kb ohio traffic crash report# 10-0088-91.
1999 wabash trailer driveshaft broke off. *ts two other vehicle's struck the driveshaft in the middle lane causing damage to their vehicles. All vehicle's came to a stop in the right berm (ohio traffic crash report).
Compare the 1999 Wabash Trailer
Other model years
Questions about the 1999 Wabash Trailer
Is the 1999 Wabash Trailer reliable?
Owners have filed 3 complaints about the 1999 Wabash Trailer, close to a typical Trailer model year.
What is the most common problem with the 1999 Wabash Trailer?
Transmission and drivetrain, with 2 complaints. Next is suspension (1).
How many recalls does the 1999 Wabash Trailer have?
4 recalls, covering service brakes, air and suspension.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Wabash Trailer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history