My 2016 Audi A3 (VIN [XXX]) underwent Safety Recall 69BY on XXX, to correct a defect in the front passenger occupant detection system (PODS), including replacement of the occupant detection sensor. Less than two years later, the same safety-system malfunction returned. The vehicle intermittently displays "Safety system: system fault," "Audi pre sense: system fault," and "Passenger airbag off." These warnings appear unpredictably and sometimes clear temporarily before returning. This malfunction creates a serious safety risk because the vehicle may fail to recognize a front-seat passenger and disable the passenger airbag during a collision. We cannot safely use the front passenger seat. On XXX, at 74,151 miles, Audi Marin diagnosed the malfunction and documented fault codes B102202, B102229, and B12251B. The dealership confirmed that diagnostic testing continued to indicate a faulty passenger occupant sensor (G128) and recommended replacement. Audi Marin's service manager informed us that Audi has redesigned the replacement component, but the updated part is on an extended backorder from [XXX]. The dealership cannot currently complete the repair. Audi of America acknowledged the prior recall repair but referred repair coverage decisions to the dealership, citing the expired warranty. The vehicle remains unrepaired and is available for inspection. I request that the federal safety agency investigate whether the remedy installed under Safety Recall 69BY is failing prematurely, allowing the original passenger airbag safety defect to recur. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The worst 2016 Audi A3 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Airbags37
- Fuel system20
- Electrical16
- Engine13
- Transmission6
- Driver assistance3
- Seat belts2
- Seats2
- Suspension2
- Tires2
- Visibility2
- Acceleration1
- Body1
- Lights1
- Locks1
Specific symptoms reported on the 2016 Audi A3
Recalls 3
Fuel system, gasoline
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1‑800‑893‑5298 or Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V‑647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V‑647.
Recall number 24V110000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
- Risk
- An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
- Remedy
- Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1‑800‑893‑5298. Audi's customer service at 1‑800‑253‑2834. Volkswagen's number for this recall is 69DY and 61C1.
Recall number 22V543000 · Recall details
Air bags: sensor: occupant classification: front passenger
- What is wrong
- Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
- Risk
- A deactivated passenger air bag increases the risk of injury during a crash.
- Remedy
- Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1‑800‑253‑2834. Audi's number for this recall is 69BY.
Recall number 21V198000 · Recall details
See all 3 recalls for the 2016 Audi A3
Defect investigations
Fuel Leak due to Suction Jet Pump Failure within Fuel Tank (Remedy Effectiveness of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V‑647. Recall 16V‑647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V‑647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V‑647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V‑110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V‑110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V‑647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
RQ23007
Technical service bulletins for the 2016 Audi A3 515
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Diagnosed and confirmed malfunction of the vehicle’s AEB system that resulted from failure or malfunction...
- This bulletin provides information when there are creaking/squeaking noises from the front end on uneven...
- This bulletin provides informaiton on the use of the PICO-NVH tool (VAS 611 015).
- This bulletin proides service information when there is a prompt to take over the steering wheel (hands...
- This bulletin provides information when the starter battery is discharged or malfunctioning.
- This bulletin provides information to aid in diagnosing the vehicle locking system.
- This bulletin provides information when the engine is not runing smoothly; all gas engines.
- This bulletin provides information on VIN plates, Safety Certification labels, and ordering procedures.
- This bulletin provides infomraiton when the exterior lights have moisture accumulation.
- This bulletin provides information for reporting safety related information to the manufacturer.
2016 Audi A3 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.4L 4‑cyl Plug-in hybrid | FWD | 33-37 | 37-41 | 35-39 |
| 1.8L 4‑cyl | FWD | 23 | 33 | 27 |
| 2.0L 4‑cyl | AWD | 23-24 | 32-33 | 26-27 |
What 2016 Audi A3 owners say
Most recent owner complaints, unedited.
I was driving my vehicle on the [XXX] like normal and suddenly my car stopped accelerating at 70 MPH and displayed a message stating to stop vehicle, transmission malfunction. There were 2 cars that almost hit me while I was trying to get over to the side of the road due to the car barely having any power. The car also displayed a checked engine light and an eps warning. This all happened within one minute. I towed It to Rocco European garage in [XXX] where It was concluded that solenoid shift for the transmission has failed and is stuck. I was told that now the car isn’t technically drivable any longer distance and should have It towed again until it’s fixed to prevent further damage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Audi A3. The contact stated that the front passenger’s side air bag occupant sensor failed to identify a passenger seat in the seat. A dealer was contacted. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that PODS had failed and needed to be replaced. Additionally, the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The contact associated the failure with the federal safety agency Campaign Number: 19V474000 (AIR BAGS); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 44,000.
Electrical problems and fuel leak
This vehicle was involved in a rear end collision in late 2025. The vehicle was just sold at auction with a clean title even though it has frame damage that is more than 100% of the cost of this vehicle. It is sold with a clean title and I am worried that a used car dealership will try to sell it with no accident history and clean title to an unsuspecting person.
Fuel leaked all my garage almost causing a fire in my home while I was sleeping. I have had the fuel tank replaced 3 times. And I had to pay out of pocket to have it replaced because audi would not replace the recall of it so I am reaching out to you so you can reach out to audi about not standing by the recall procedure!
My 2016 Audi A3 Sportsback E-tron vehicle was parked at my house. When I went to start it the engine did nothing, no power. The message “Driver System Fault” and a red triangle with a red ! in the middle was displayed on the instrument panel. I was unable to start or operate the vehicle. I called AAA and they towed the vehicle to a Recharge Hybrid pump location near my house. I tired to charge the battery and it would just turn off. Then I called AAA again and they towed my car back to my house and checked the small 12 volt battery to see if that was the problem, they determined that the 12 volt battery still had 75% life in it. They were unable to get my vehicle started. The same message is still on the dashboard “Driver System Fault." The failure mileage is approximately 81,567. I want to know before I call the Dealer and get it towed again if this issue is the Hybrid High-Voltage Battery or the housing bonded seam could have lead to corrosion the service recall from a while ago. Service Action Code 93D2
The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked with the engine running, the vehicle experienced a sudden loss of motive power. During the failure, the message “Driver System Fault” was displayed on the instrument panel. The contact was unable to restart or operate the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the Hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 83,000.
Passenger airbag not activated when passenger is seated
Passenger Occupancy Detection System is malfunctioning. Pre-sense system fault
Compare the 2016 Audi A3
Other model years
2001200320042006200720082009201020112012201320152016201720182019202020222023202420252026
Questions about the 2016 Audi A3
Is the 2016 Audi A3 reliable?
Owners have filed 83 complaints about the 2016 Audi A3, 1.9 times a typical A3 model year.
What is the 2016 Audi A3 year score?
The 2016 Audi A3 scores 48 out of 100 (below average). The score compares it with the other model years of the Audi A3: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2016 Audi A3?
Airbags, with 37 complaints, typically around 44,000 miles. Next is fuel system (20).
How many recalls does the 2016 Audi A3 have?
3 recalls, covering fuel system, gasoline and air bags.
What gas mileage does the 2016 Audi A3 get?
Official estimates for the 2016 Audi A3 range from 26 to 39 mpg combined. The most efficient version (1.4L 4-cyl plug-in hybrid, FWD) gets 33-37 city and 37-41 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Audi A3?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history