2012 Audi A6 engine problems

Filed Apr 4, 2022 · Engine · NJ

Greeting, I drove my car for a minor body repair and paint job at Midland Park Auto Body located at 158 Godwin Ave, Midland Park, NJ 07432 on March 22 2022. There were no signs on the dashboard for any services or repair when I dropped of the car. Warren the owner called me to let me know that the paint job was completed by had some bad news for me. The car would not start. He thought it was the starter that had malfunctioned. We decided to have the car inspected by Jack Daniels Audi of Paramus Service Center located at 16-01 McBride Ave, Fair Lawn, NJ 07410. I have had this car serviced there since I bought the car from them. James a senior technician called Warren and told him that the engine was shot. He was surprised and shocked that the engine ceased working. The was enough oil in the engine, car had been serviced regularly with them. They told me it would cost about $25,000 to replace the engine. They also told me that they would ask Audi Corporate to see if they can assist me with. It has been about 4 days , there has been no response from Audi. I started to search on the internet to see if other consumer had experienced this problem. I found several. Did Audi know if their engines were malfunctioning ? What would happen if this car stopped when I was driving on a highway? This is very serious . Hope to hear from your team soon.

Filed Mar 13, 2020 · Electrical, Engine · 122,000 miles · NJ

Ran obd reader myself and at mechanic and found the following; p0456 evap emission control system (very small leak) | leak detected and p190f00 coolant pump for charge pressure cooler | electrical malfunction in load circuit. Mechanic informed that the vehicle needs a software update regarding the p0456 code as no leak was found. Also that only audi performs this update. Regarding the p190f00 code informed me that there are several recalls regarding this issue as it has been causing some severe symptoms such as engine shaking, loss of power, squealing, whining noise near or at timing belt area at start up, delayed reaction at acceleration ( takes a while to reach desired speeds), temp gauge lowering despite warm up, warming of vehicle taking longer, unable to drive over 30-40mph and RPM won't go above 2000-2500 rpms. Acceleration is not as responsive as it should be.

Filed Mar 4, 2020 · Engine · 89,900 miles · CA

I took my car in for a recall regarding the after-run coolant pump on december 10th to 27,2019. They performed the recall service. They charged my extended warranty for the service repair. At the end of january 2020 the epc light came on and on 2/10/2020 the audi dealer indicated that the after-run coolant pump was defected because it was plastic and it can crack easily which is what happened and they indicated that they replaced it.they suggested that I have a flush of the fluids and I told them I would look outside of the dealer for these services. On 2/23/2020 the epc light came on again. This time the dealer is indicating that there was a build up of debris and is causing the coolant pump to malfunction. However, they are stating that this is due to my negligence of not flushing the fluids. I asked why the fluid would not have been changed the two times they replaced the coolant pump? They said they do not flush the system they only put back what was lost due to the change of part. I took my car for a second opinion and the new mechanic called the audi dealer to get a clear understanding of what needs to be repaired. He examined the car and removed all parts in question. He indicated that the after-run coolant pump has a filter bag that has broken open and expelled pellets throughout the entire cooling system. He will now have to repair the entire cooling system to ensure that these pellets are cleared out. He indicates this is bad design on the manufacture and there is no way anyone the dealer nor him can with 100% certainty get all the pellets out. These pellets can stay stuck in any component of the cooling system and dislodge at any time and cause the damage to occur again. Can you please let me know if I can request reimbursement for the coolant pump recall even though they have already replaced it once?

Filed Apr 1, 2019 · Engine, Fuel system · 100,000 miles · NY

Upon starting my vehicle I noticed extended cranking. Upon driving the vehicle I noticed a fuel odor, initially I thought it was the older vehicle driving in front of me. After driving approximately 4 miles I realized it was my vehicle. I then drove my vehicle back to my house, and had it towed to audi of albany due to recalls that were open. Upon inspection they performed recalls, but informed me the recall for the engine fuel rails was performed june 2015. They then told me they needed to charge labor to inspect the issue, to which point I told them I am an ase master mechanic, and I will figure the issue out myself. I then had the vehicle towed to my garage, where I took it apart following the recall provided on your website. Upon inspection I verified that the injector supports (p/n 06d133036k) listed in the recall (code 24ap) were never replaced. The injector supports I removed from my vehicle are (p/n 06d133036h). Audi has had my vehicle now from 21nov2018 until the present. They will not verify that those parts were supposed to be replaced during the recall, and also if any other parts were never replaced. They have contacted me and told me my fuel injector failed causing the fuel leak, and everything will be covered. I believe my injector failed (if that is the truth) due to the non replaced injector supports. The incorrect geometry over time would cause stress on the injector, and for it to crack. I also question if any seals were truthfully replaced, or if the recall was done at all. I also fear that this issue may have occurred to others who had the recall performed there (langan audi), and are not mechanically inclined enough to disassemble there engine and fuel systems. This problem could have caused a fiery death for me and my family in the car if I wasn't inclined enough to realize the problem is my car and not others around me.

Filed Nov 7, 2018 · Airbags, Engine · FL

Tl* the contact owns a 2012 audi a6. The contact stated that the federal safety agency campaign number: 18v229000 (engine) and the federal safety agency campaign number: 18v370000 (air bags) exceeded a reasonable amount of time for repair. The contact received the recall notifications in june and july of 2018. The contact spoke with audi clearwater (18940 us-19 clearwater, fl 33764, (888) 727-0742) several times and requested part information; however, the dealer stated that parts were not available for the repair. The dealer also stated that they did not have a time frame for when parts would be available. The manufacturer advised the contact to continue to check with the dealer regarding part availability. Parts distribution disconnect for the federal safety agency campaign number: 18v229000 and VIN tool confirms parts not available for the federal safety agency campaign number: 18v370000.

Filed Aug 10, 2018 · Airbags, Engine · 80,000 miles · GA

Tl* the contact owns a 2012 audi a6. While driving approximately 60 MPH, the vehicle suddenly reduced speed to approximately 15 MPH and an unknown message was displayed. The vehicle was taken to audi north atlanta (11505 alpharetta hwy, roswell, ga) where it was diagnosed that the engine cylinders failed. The vehicle was repaired. The vehicle later experienced frequent failures to start and was taken back to the dealer where it was again diagnosed with engine failure. The vehicle was repaired. In addition, the passenger side air bag sensor would illuminate while operating the vehicle, which was a safety concern. The failure was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.

Filed Jul 23, 2018 · Airbags, Engine · FL

Tl* the contact owns a 2012 audi a6. The contact received notification of the federal safety agency campaign numbers: 18v229000 (engine and engine cooling) and 18v370000 (air bags); however, the parts to do the repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The dealer (braman bmw west palm beach, 2901 okeechobee boulevard, west palm beach, fl 33409, (561)-465-8293) was contacted and confirmed that the parts were not available for the recall remedy. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. *tt

Filed Jul 6, 2018 · Engine · 100,000 miles · ND

2 problems I have and I see more and more people having it, the chain rattle on the back of the engine on the passenger side and the flex pipe braking and making the car sound like it has a tin can both on the passenger side, the problem with the timing chain rattle whenever you start the car makes it sound like a loose heat shield, I went and checked the car at multiple mechanics/dealerships and all know those are common problems with the 3.0t a6 2012

Filed Jun 21, 2018 · Airbags, Engine · FL

Tl* the contact owns a 2012 audi a6. The contact received notification of the federal safety agency campaign number: 18v229000 (engine and engine cooling) and an unknown recall notice pertaining to the air bags. The contact called audi jacksonville at 904‑565‑4000 (located at 7230 blanding blvd, jacksonville, fl 32244) and was informed that the parts were not available. The manufacturer was made aware of the issue and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Vin tool confirms parts not available.

Filed Feb 13, 2018 · Engine · 114,000 miles · NY

Tl* the contact owns a 2012 audi a6. The contact stated that the vehicle stalled on the highway and would not restart. There were no warning indicators illuminated prior to the failure. The vehicle was towed to the dealer (audi of huntington, 363 e jericho turnpike, huntington station, ny 11746). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The contact referenced the federal safety agency campaign number: 16v619000 (engine and engine cooling), but the recall was for a different model vehicle. The failure mileage was 114,000.