2002 Audi S6 problems

Filed Jun 24, 2021 · Fuel system · OH

Fuel is leaking from the top of the driver side of fuel tank. Appears to be near to rollover nipple that was previously recalled in 2010. Result: accumulation of fuel near exhaust - fire hazard.

Filed Mar 6, 2015 · Acceleration, Transmission · 12,000 miles · MN

Tl* the contact owns a 2002 audi s6. The contact stated that when the brake pedal was released and the accelerator pedal was depressed in cold temperatures, the vehicle failed to accelerate. The vehicle was taken to a dealer, where unknown repairs were performed. However, the failure recurred. The vehicle was taken back to the dealer. The technician informed that the vehicle was operating as designed. The manufacturer was notified of the failure. The failure mileage was 12,000.

Filed Aug 23, 2010 · Fuel system · 110,342 miles · NJ

On 10 aug 2010 my 2002 audi s6 avant fuel tank rollover valve hose nipple began leaking fuel vapors and liquid. The leak which is caused by the same material failure noted in the federal safety agency campaign # 08v157000 and is a serious safety risk because of fuel and fuel vapor exposure to hot exhaust and other possible ignition sources. In this case the plastic hose nipple cracked without any type of impact, damage or the presence of harsh conditions. The valve is located on the driver's side of the tank a few inches from the fuel sender access hole under the rear seat. The p/n for the entire fuel tank for the a6 and allroads affected by 08v157000 is [xxx] bl. The p/n for the entire fuel tank in the s6 and a6s w/ 4.2 v8s *not yet recalled* is [xxx]. The design of the tanks is nearly identical, but the 075 bl is three gallons smaller. While the fuel tank p/ns are different the plastic rollover valve which is bonded to the fuel tank assembly is common to both p/ns and is unavailable as a replaceable component. Although the fuel line attached to the valve is of a different material, similar forces act upon the hose nipple leading to the cracking on the 4.2s larger yet otherwise similar tank. The defective fuel tank on my vehicle is still installed and the car is not drivable due to the serious safety hazard. An inspection through the fuel sender access panel under the rear seat revealed that the plastic rollover valve was the source of the fuel leak streaming down the tank beside the exhaust and pooling below car. Note: I personally know of at least one other instance where a 2002 a6 w/ 4.2 v8 began leaking fuel from the same rollover valve hose nipple and these vehicles equipped with the 4.2 have not yet been identified by a the federal safety agency campaign or manufacturer recall. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Oct 26, 2009 · Fuel system · 59,000 miles · CA

Fuel leaking from the gas storage unit.

Filed Jan 2, 2004 · Acceleration · 1,000 miles · NY

Dangerous random loss of throttle responsiveness; erratic transmission shift function .

Filed Mar 10, 2003 · Transmission · 125 miles · NJ

Vehicle exhibits loss of throttle response and power if accelerator pedal is depressed under certain circumstances.

Filed Aug 30, 2002 · Tires · CA

Tire exploded (at freeway speed) and disintegrated causing me to be immediately driving on the wheel (damaging the wheel) until I could get over to the right shoulder and stop.