The front passenger-side 6-piston Brembo caliper's (Part No. 20.A989.63) external steel crossover tube failed due to corrosion, specifically where the tubing was covered by a protective rubber sleeve, which trapped moisture and road salt. This led to a catastrophic loss of brake fluid and braking capability. This appears to be a systemic corrosion defect.
The worst 2016 Audi S6 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine14
- Transmission3
- Electrical2
- Acceleration1
- Brakes1
- Driver assistance1
- Fuel system1
- Steering1
- Suspension1
Specific symptoms reported on the 2016 Audi S6
Recalls 2
Engine and engine cooling: engine: gasoline: turbo/supercharger
- What is wrong
- Volkswagen Group of America, Inc. (Audi) is recalling certain 2013-2017 A8, S6 Sedan, S7, S8, and 2014-2017 RS7 vehicles. The turbocharger oil supply strainer can become blocked, causing wear to the bearings due to lack of lubrication.
- Risk
- Worn bearings can cause the turbine wheel to contact the turbocharger housing or cause the shaft to break, causing an engine stall and increasing the risk of a crash.
- Remedy
- Dealers will replace the oil strainer and perform an oil change, free of charge. Owner notification letters were mailed August 4, 2022. Owners may contact Audi customer service at 1‑800‑253‑2834. Audi's number for this recall is 21H7.
Recall number 22V178000 · Recall details
Air bags: sensor: occupant classification
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S6 and S7, 2012-2018 A7 and A6 Sedan, and 2014-2018 RS7 vehicles equipped with basic seats (with or without heating). Stress or wear of the body-sensing mat within the front passenger seat may cause the Passenger Occupant Detection System (PODS) control module to malfunction.
- Risk
- If the PODS module malfunctions, the front passenger air bag may not deploy properly in the event of a crash, increasing the risk of injury.
- Remedy
- Volkswagen will notify owners, and dealers will install a PODS system repair kit, free of charge. The recall began November 29, 2018. Owners may contact Audi customer service at 1‑800‑253‑2834. Volkswagen's number for this recall is 74D5.
Recall number 18V370000 · Recall details
See all 2 recalls for the 2016 Audi S6
Defect investigations
Engine Stall - Turbo Failure
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V‑178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
EA22001
Engine Stall - Turbo Failure
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the federal safety agency reports described above. To date, the federal safety agency has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.
PE21009
Technical service bulletins for the 2016 Audi S6 683
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This bulletin provides informaiton on the use of the PICO-NVH tool (VAS 611 015).
- This bulletin proides service information when there is a prompt to take over the steering wheel (hands...
- This bulletin provides information when the starter battery is discharged or malfunctioning.
- This bulletin provides information to aid in diagnosing the vehicle locking system.
- This bulletin provides information when the engine is not runing smoothly; all gas engines.
- This bulletin provides information on VIN plates, Safety Certification labels, and ordering procedures.
- This bulletin provides infomraiton when the exterior lights have moisture accumulation.
- This bulletin provides information for reporting safety related information to the manufacturer.
- This bulletin states that technicians are required to report to the manufacturer when a vehicle has...
- This bulletin provides service information regarding exterior glass cleaning.
2016 Audi S6 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 4.0L 8‑cyl | AWD | 18 | 27 | 21 |
What 2016 Audi S6 owners say
Most recent owner complaints, unedited.
Subject: Formal Complaint Regarding Defective Arnott Front Air Strut To Whom It May Concern, I am writing to formally report a significant safety concern regarding a defective Arnott FL front air strut purchased via RockAuto for my 2016 Audi S6 (VIN: [XXX] ). The air strut failed within five days of professional installation. This failure compromised the safety and functionality of my vehicle's suspension system, potentially risking further damage and endangering passengers. I was forced to drive the vehicle briefly in this compromised state to arrange for reinstallation, creating an additional safety hazard. Details of the issue: Product: Arnott FL Front Air Strut (purchased via RockAuto). Professional Installation Dates: October 25, 2024, and reinstallation due to failure on November 27, 2024. Failure Description: The air strut lost functionality within five days of installation, causing a significant drop in vehicle height and inability to maintain proper suspension. This defect demonstrates a failure of Arnott’s quality control and has left me concerned about the safety of their products, particularly when they play a critical role in vehicle performance and passenger safety. I am requesting that the federal safety agency investigate this matter to ensure no systemic issues with Arnott's products compromise the safety of other drivers. I have attached supporting documentation, including invoices for installation, reinstallation, and further details on the defective part. Thank you for your attention to this urgent safety matter. I look forward to your acknowledgment and any updates regarding this investigation. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
We, a group of Audi S6 owners with vehicles from the 2013-2017 model years, are experiencing premature mechatronic issues. These problems manifest as jerking when coming to a stop, which can lead to accidents, and intermittent power loss that can be life-threatening. These issues began around 40,000 miles and have progressively worsened, despite our vehicles having only approximately 70,000 miles on them. Given the early onset and severity of these problems, we strongly urge a recall. The current mechatronic design appears to be flawed and fails prematurely, posing significant safety risks.
Hi - The Crankcase Ventilation Valve Extended Warranty [XXX] covers only ten years or 120k miles. My car has close to 160k miles. According to the federal safety agency or Audi, “Audi has determined that, in some vehicles, it is possible for the crankcase ventilation valve to malfunction, causing a whistling noise in the engine compartment and the MIL to illuminate due to the presence of specific fault codes caused by this component. This condition may impact the vehicle tailpipe emissions, and the presence of a MIL-on condition may cause the vehicle to fail an IM (smog) test.” This is causing the engine to rev on its own, foul odor, consume more oil and gas, MIL-on, and potentially cause the IM (smog) test to fail regardless of years or miles and a safety issue. Please add this matter to recall rather than extended warranty and is likely related to the federal safety agency Campaign Number: 22V178000 which is causing oil separator and coolant pipe issues that need to be covered. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving with my wife and kids, on the highway, in the rain a warning message was displayed. The warning stated: steering malfunction, please stop the vehicle!. At which point the power steering locked-up & the engine powered down. As a result, I was unable to steer the vehicle. Thankfully, I was able to “muscle” the car off the highway and onto a secondary roadway. Vehicle was towed. With the power steering locking-up and not being able to effectively steer the vehicle this is a HUGE safety issue and needs to be addressed with Audi. This could have ended tragically if it were to happen to a driver who was unable to “muscle” the vehicle to safety.
The contact owns a 2016 Audi S6. The contact received notification of the federal safety agency Campaign Number: 22V178000 (Engine and Engine Cooling) however, the repair had been previously completed by an independent mechanic, a year prior to receiving the recall letter. The contact filed paperwork to be reimbursed after receiving the recall letter. The contact had taken the vehicle to a dealer, and the dealer stated that the vehicle was no longer under warranty. The dealer had not performed the recall repair, stating that the vehicle had been modified. The manufacturer was made aware of the issue. Parts distribution disconnect.
I was driving my car and it stalled out in the middle of an intersection which was totally unsafe and it would barely start. I was able to limp it to safety but it would not run or idle correctly. I had it towed to the local Audi dealership and they diagnosed the issue as being the turbos. The turbos failed and need to be replaced. The obvious known issue with the oil screen starving the turbos and causing collateral damage is well documented hence Audi issued an extended warranty on turbos and the recall on the oil screen however the dealer is refusing to do any repair and has had the vehicle for over a week.
I am having a transmission malfunction warning light on the dashboard that comes on. The car will not shift gears which is dangerous when driving in streets/highway. This is a known issue with the Audi S6 and related models and a class action lawsuit is in process. Audi is trying to charge few thousands dollars $8000-$12,000 to replace the mechatronic and clutch transmission system which is very prone to failure. Thank you
Loss of power on freeway, due to known turbo issue on these cars. Filter for turbo oil clogs, and burns the turbo's without warning causing loss of power. Not to mention it often sends metal into your engines oil and the repair for that is more than the car is worth.
The Passenger Side Turbo failed. Yes it’s available for inspection. I was driving and I felt a pop, like a backfire from under the hood. The car lost power instantly and was any under power anymore on the road. It could have been a lot worse if I was on a busy highway but luckily was on a street with do one behind me. It was confirmed it was the turbo failure and the turbo has been inspected. No warning lamps or any prior symptoms before hand. Once it happened it started throwing warning lights for pretty much everything. Limited slip diff, air bags, EPC, TPMS, check engine light and traction control warning lights all went off one after the other.
Compare the 2016 Audi S6
Other model years
1995199619971998200120022003200720082010201320142015201620172018202020222025
Questions about the 2016 Audi S6
Is the 2016 Audi S6 reliable?
Owners have filed 19 complaints about the 2016 Audi S6, 4.8 times a typical S6 model year.
What is the most common problem with the 2016 Audi S6?
Engine and cooling, with 14 complaints, typically around 56,000 miles. Next is transmission (3).
How many recalls does the 2016 Audi S6 have?
2 recalls, covering engine and engine cooling and air bags.
What gas mileage does the 2016 Audi S6 get?
Official estimates for the 2016 Audi S6 range from 21 mpg combined. The most efficient version (4.0L 8-cyl, AWD) gets 18 city and 27 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Audi S6?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history