2021 BMW 530I technical service bulletins
174 technical service bulletins and manufacturer communications cover the 2021 BMW 530I, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been...
- The engine oil pump assembly coveragefor the issue described in the Service Information Bulletin that...
- A groaning noise is present from the door frame of any door, most commonly when driving over rough roadsor...
- A check control message is displayed, indicating that the parking assistance systems have...
- The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off...
- One or more of the LED daytime running lights are dim or discolored.
- Check Control message (CCM) indicates: (ID 213): Stop, exercising due care
- The basic conditions for initializing the power windows are not met.
- The electrical system of BMW vehicles has been subject to an ongoing development process over the last few...
- At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking,...
- The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3)....
- Situation
- Engine will crank but not start
- Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle
- Pressure control valve (PCV) extended ltd wty 15 years/150,000 miles
- ?A software error may
- ?Unusual noises occur only when operating the steering column in the axial direction.
- ?The front seat will not calibrate/initialize, and the stored faults cannot be deleted.
- ?The sunroof will not operate in either direction.
- With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service...
- BMW AG has issued a Delivery Stop effective June 6, 2023 on certain Model Year 2023
- A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system...
- BMW AG has issued an Emissions Recall (effective March 17, 2023) on a certain Model Year 2021
- A groaning type noise is heard during the height adjustment.
- Headlight check control (CC) message 128 "High beam headlight failure" is displayed
- The air conditioning cycles from cold to warm air while driving or while at a stand still
- Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
- Due to a software error, the vehicle sporadically does not achieve sleep mode
- After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes...
- Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can...
- BMW AG has issued a Delivery Stop: Due to a software failure, there is the possibility that the...
- There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving...
- Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn...
- The 3G network in the US has been shut down
- Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).
- Engine Variants Updated.
- There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving...
- Coolant leaking from the engine compartment
- A cracking, metallic noise from under the center of the vehicle.
- There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving...
- The saved steering column positions, vertical and horizontal, are not stored long term.
- Due to a software error, Remote Software Upgrade (RSU) and Remote Support are currently not possible
- The sunroof will not operate in either direction
- After opening the vehicle with the radio remote control and changing the profile, the exterior mirror...
- After programming, the
- According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle...
- The customer complains that the radio stations change by themselves.
- Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may...
- The sound output intermittently drops out entirely
- Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may...
- Electrical system
- Check Control Message (CCM) displays "Vehicle key missing" after engine start.
- When using the Key Reader to retrieve information from the customer's key, no current vehicle data is...
- The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain...
- The functionality of the right rear SRR sensor could be reduced which would display the "Driving...
- Note: Before performing a repair and submitting a claim, first confirm that the vehicle has the above...
- BMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service technicians
- The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the...
- Information updated about engine oil filter cap drain plug
- The customer complains that under moderate throttle application or on deceleration after throttle...
- 48 V battery may become totally discharged, and possible replacement needed.
- Check Control message (CCM) displays "Vehicle key missing" after engine start.
- Sport mode is not displayed correctly in the instrument cluster
- No heater output in passenger area.
- The steering intervention for Lane Departure Warning (LDW) is too strong (severe), which can create an...
- Equipment: other: owners/service/other manual
- BMW AG has issued a Delivery Stop (effective June 9, 2021) on certain Model Year 2021 BMW vehicles that...
- In some rare cases a customer vehicle might be excluded from one or more Remote Software Upgrade(RSU)...
- Temporary black screen in the instrument cluster.
- SiriusXM satellite radio is not working and does not display a channel list.
- The SIM card installed in the telematics control unit (ATM2) connects to different mobile providers' networks
- While using the wireless charger, one or both of the following may occur: 1) The BMW display key or mobile...
- Customer states the following about their vehicle: active radio or music source is interrupted, the...
- A faulty componnent inside the trunk spindle drive.
- The sunroof will not operate in either direction.
- The BMW Gesture Control function may fail permanently as a result of high temperature fluctuations.
- The "energy management" Check control message (ID code 415) is falsely displayed when entering the vehicle.
- BMW of North America (BMW NA) has made information available online to customers about software versions,...
- BMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service...
- ???When charging the vehicle with an Occasional Use Charger (OUC) after previously using a Wallbox...
- ???Due to an unfavorable operating point primarily in the low-end torque range, the fuel vapor scavenging...
- With the introduction of BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service...
- In some rare cases a customer vehicle might be excluded from one or more Remote Software Upgrade (RSU)...
- When charging the vehicle with an Occasional Use Charger (OUC) after previously using a Wallbox...
- The trunk lid/hatch does not open fully when unlatched with remote or hands-free operation.
- Groaning, scraping, or squeaking noise coming from the steering wheel area in the interior of the...
- Only warm air comes out of the vents despite the air conditioning being switched on. The status indicator...
- The air conditioning cycles from cold to warm air while driving or while at a stand still
- Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle...
- BMW AG has issued a Delivery Stop (effective June 9, 2021) on certain Model Year 2021 BMW vehicles that...
- The BMW key card cannot be activated
- The top view image of the vehicle is misaligned when observed in the Control Information Display (CID)....
- 48 V battery may become totally discharged, and possible replacement needed if: a) The vehicle has been...
- The customer may complain of a check control message stating "Safe share detected" (CCM-ID 953)
- Check control message (CCM-ID 49) "You can continue driving
- When the vehicle is operated in Sport Mode, the engine speed is no longer displayed in the BMW Head-Up...
- A software optimization affecting vehicle performance has been made available.
- On rare occasions during an engine oil service, the BMW Original (Genuine) engine oil filter insert is...
- Upon visual inspection, the passenger side upper active air flaps are either stuck open or closed, and...
- Front seat will not calibrate/initialize, and the stored faults cannot be deleted
- The driver's seat and/or passenger seat rattles ("cracking" noise) during load reversal
- Some of the vehicles listed above which were initially identified as requiring Recall Campaign 20V-601
- The total electrically driven miles are lost/reset after the vehicle is programmed
- BMW AG has issued a Delivery Stop (effective June 9, 2021) on certain Model Year 2021 BMW vehicles that...
- B58 engine: engine oil filter removal procedure and tools
- HU-H3 mgu resets due to bluetooth connection with samsung android 11
- Delivery stop: radio remote control m sport
- Remote control is not detected
- Bmw connecteddrive services are not available
- Remote 3D view not available
- Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal...
- Retrofit satellite radio (option code SA655)
- Bmw remote software upgrade is not offered for installation
- Instrument cluster display shakes-shifts to the left
- Rear light faulty check control message
- Automatic high beam does not dim automatically
- Remote-control parking fails after engine start
- Top view camera image is misaligned
- Combustion control valve lift at idle
- Seat fails to initialize due to missing end stop
- VOLT BATTERY MAINTENANCE: 48 V battery may become totally discharged, and possible replacement needed if:...
- Brake light remains lit after brake pedal release
- Rear light faulty check control message
- Sporadic failure or cracking noise in bass speakers
- Dynamic stability control (DSC) unit does not respond after programming
- Battery does not charge with external charger and closed hood
- Checking the jump start point cover and reworking if necessary
- Bmw remote software upgrade is not offered for installation
- Replace all the ignition coils
- Remote control key or bmw display key buttons not working
- ?BMW DIGITAL KEY CARD IS NOT DETECTED WHEN PLACED ON THE NFC TRAY: The
- Malfunction indicator lamp (MIL) is illuminated with fault memory CDC152
- ?INSTRUMENT CLUSTER DISPLAY SHAKES-SHIFTS TO THE LEFT: The Instrument cluster intermittently flickers,...
- ?DAYTIME RUNNING LIGHT IS DIM OR DISCOLORED: One or more of the LED daytime running lights are dim or...
- ?AIR CONDITIONING COOLING IS INSUFFICIENT: There is insufficient or no cooling from the air-conditioner...
- ?PROGRAM HEAD UNIT: Satellite radio content is not available over IP, this does not affect channels...
- ?GESTURE CONTROL UNINTENDED OPERATION: The Gesture camera inadvertently detects movement and performs...
- Remote control is not detected
- Fuel filler door will not open
- Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full: Low Washer Fluid Warning...
- High-voltage battery condition verification (20V-601)
- Head unit resets with fault code B7F8F9 reset watchdog
- Service action - install ground strap / suppressor belt
- Active cruise control - unexpected deceleration
- Surround view - parking view images displayed incorrectly
- Top view camera
- Front grille upper/lower active air flaps: ltd wty ext to 15 years/150,000 miles
- GROANING NOISE DURING HEIGHT ADJUSTMENT OF THE ELECTRIC STEERING COLUMN: A groaning type noise is heard...
- Service action - replace left rear short range radar sensor (SRR)
- Service action - replace right rear short range radar sensor (SRR)
- Failure of the electric steering column adjustment at higher cabin temperature
- Bmw turbocord portable EV 120 v/240 v charger
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 BMW 530I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history