My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.
BMW 535I fuel pump problems
96 of the 486 owner complaints about the BMW 535I describe fuel pump failure, most of them for the 2009 model year.
- owner complaints
- 96
- worst model year
- 2009
- typical repair cost reported
- $3,500
- typical mileage
- 76,000
By model year
Often reported together
Stalling 34Loss of power 25Check engine light 13Engine failure 8Won't start 6Overheating 3
Trouble codes mentioned
P0087 1
What owners say
Consistent fuel pump error code 2AAF
The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to the federal safety agency Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.
BMW REFUSES TO TAKE RESPONSIBILITY OF CONSEQUENTIAL ISSUES CAUSED MY FAULTY FUEL PUMP RECALL AND IS TRYING TO CHARGE ME 21000 to fix. Engine reads maximum drivetrain output drive moderately
The contact owns a 2009 BMW 535I. The contact stated that while driving at an undisclosed speed, the vehicle vibrated violently with a message displayed to, "Check Engine – Engine Power Reduced”. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the spark plugs and ignition coil. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the valve cover gasket and upper radiator hose. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the evaporative leak detection assembly, water pump, and high-pressure fuel pump. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but did not assist. The failure mileage was 70,000.
I was told by BMW that the high pressure fuel pump for these vehicles are under warranty for 100,000 miles or 10 years. I just purchased the vehicle to not only drive from new jersey to New York and shut down. Since then it caused an accident and the used dealer is just ignoring everything. I was also told there’s an electric water pump class action suit and also something with the trunk leaking. Now I do know that a vehicle is not supposed to be sold without recalls being stated and fixed. I’m already paid 10k for the car and then 1k for a starter . The vehicle is in the body shop having body repair due to the engine shutting down. If the engine shuts down it displays fuel pump malfunction and within 20-30 mins will start again. The BMW 535i has 96,000 miles on it and I don’t think it’s fair that I should be penalized for someone not following thru with repairs let alone having an accident on my insurance now. I’m asking please just help get the vehicle running again and all future service will absolutely be done through BMW. That’s how I handled my Mercedes’ and plan so with this vehicle. I’m a single father that just took a severe beating financially and had to sell the Mercedes’ and thought buying a BMW was a good choice being I had a similar issue with Mercedes’ and they honored the repair due to the amount of time owned and still being in the mileage range of the defective part. Please help . Email-[XXX] Cell- [XXX] [XXX] Thank you in advance INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
The contact owns a 2012 BMW 535I. The contact stated that while driving at 20 MPH, the vehicle stalled as the drivetrain malfunction warning message flashed on the instrument panel. The contact stated that the vehicle failed to start up after multiple attempts. The contact had a friend replace the battery; however, the failure persisted. The contact then had the vehicle towed to a dealer where they diagnosed the vehicle with a defective fuel pump. Upon investigation, the contact discovered the federal safety agency Campaign Number: 16V746000 (Fuel System, Gasoline) which she linked to the failure. The manufacturer was notified and informed her that there were no recalls on the vehicle. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 90,000.
While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500
Car failed to start due fuel pump wires malfunction.
The car stop running completly when I was wainting at the stop light An anounsmemt came out in my dash saying that I have to repleaced the fuel pump I know that there was a recall abuot this problem but I never got any notice or letter from bmw
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
- Risk
- The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 16V746000 · Recall details
Questions about the BMW 535I fuel pump
Which BMW 535I years have fuel pump failure problems?
The model years with the most reports are 2009 (33 complaints), 2010 (25 complaints) and 2011 (18 complaints).
How much does it cost to fix fuel pump failure on the BMW 535I?
Owners who mentioned a price put the repair at about $3,500 (median of 6 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used BMW 535I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history