The contact owns a 2015 BMW 535I. The contact stated that while driving at 30 MPH, the engine overheated. The engine temperature gauge was between 250 and 300 degrees. The contact linked the failure to the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The vehicle was taken to the local dealer and was diagnosed with a water pump connector failure. The vehicle was repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 70,000.
BMW 535I overheating problems
22 of the 486 owner complaints about the BMW 535I describe engine overheating, most of them for the 2008 model year.
- owner complaints
- 22
- worst model year
- 2008
- typical mileage
- 60,000
Is there a fix? There are 2 recalls for this area of the car. See below
By model year
- 20161
- 20152
- 20141
- 20131
- 20121
- 20114
- 20101
- 200811
Often reported together
Loss of power 3Fuel pump 3Stalling 2Engine failure 2Water leak 1Won't shift 1Misfire 1Fuel smell 1
What owners say
I purchased the BMW 535 and it continues to have drivetrain malfunction issues. This feels like a safety concern for several reasons. The first is that were not able to identify the issue, but I believe it has to do with the systems diagnostics being triggered or misfiring this is an unfortunateissue because wherever we are, we can get stuck randomly. Lastly, the car has an issue with Oberheu. Issue because wherever we are, we can get stuck randomly. Lastly, the car has a issue with overheating believe it has to do with the radial hose
The contact owns a 2013 BMW 535I. The contact stated while driving at various speeds, the engine was overheating. Additionally, the contact noticed an abnormal burning odor while driving, with smoke coming from underneath the hood while at a complete stop. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000.
The contact owns a 2015 BMW 535I. The contact stated while driving 35 MPH, the message that the engine was overheating was displayed, with a message to “Drive Moderately” displayed as well. The driver started to slow down and the message to turn off the engine was displayed. The contact turned off and restarted the vehicle four times and waited 15 to 20 minutes. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 25,000.
The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to the federal safety agency Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.
The contact owns a 2016 BMW 535I. The contact stated while driving at various speeds, the message that the engine was overheating was displayed. The contact stated that the vehicle was left overnight in a hotel parking lot. The vehicle was able to be restarted; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed and determined that the water pump, plug connector, and head gasket had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.
The vehicle is having cooling/ heat problems. Does not overheat while driving but rather driving on high temp. Cools to norm temp here and there. My best thought is electrical. Also same vehicle rattles in rear center when going 65mph.. not sure the cause is.
Recall coolant leak within erg. My engine has developed a strange ticking sound.
I was driving on the highway and vehicle sent an overheating message and instantly the power to the motor was cut off causing the vehicle to rapidly slow down with no brake signal so the rear car almost rear ended the vehicle due to the signal cutting power to the engine during the overheat message, once I was able to pull over and stop it was fine? I checked the coolant after I got home and it was at the level required, after I was able to the read the codes it showed waterpump ? I recently saw recalls for 2011 bmw 5 series on water pump issues, I would like to ad this problem and or safey issue to be noticed, if all those vehicles are being reported to have waterpump issues ,l believe my car should be on that list of recalls as well , they all have the same water pump ,so that would effect all models 6 clyinder ,8 cylinder etc,, tthe after a month of no codes no issues, I pulled into my driveway to get something from the house, I left the car running, when I cam out it had sent an over heat signal again, when the car wasnt overheating? It was just weird, it might be wise to include all vehicles with the 2010-2011 style water pump to be replaced and look into the power cut off due to the failure of the pumps/and or their electrical systems which are being recalled , please let know if my car can be added to the recall so it could be replaced because it has the same issues as the other models that recalled, havent driven on the highway since, scared I might get rear ended, if the power cuts off to slow the vehicle brake lights should go on or some indicator to let vehicles following behind know the vehicle is slowing down, live and learn I geuss,
The vehicle (2011 bmw 535i gt) indicated that it was overheated after driving for about 25 minutes in the city and highway. The vehicle automatically slowed down and would not accelerate. Fan was continually running after vehicle was stopped on the side of the highway and when the vehicle was turned back on hours later. Took the vehicle to a local mechanic who said it was the auxiliary water pump that needed to be replaced. Bmw has a recall but the 535i gt is not in the recall, the 550i gt is. The recall should be looked at for expansion.
Related recalls
Engine and engine cooling: engine
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
- Risk
- If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1‑800‑525‑7417.
Recall number 14V176000 · Recall details
Engine and engine cooling: cooling system
- What is wrong
- Vehicle description: passenger vehicles. A malfunction or failure of a coolant system component, such as a thermostat, water pump, or fan belt, can result in significantly increased coolant temperature and system pressure. If the indications of a critical overheating condition is not noticed by the driver, it is possible that damage to, or failure of, a coolant system component could occur.
- Risk
- If a crack were to form or a seam were to separate in the heater core end piece, hot coolant could suddenly be expelled, increasing the risk of personal injury to a vehicle occupant.
- Remedy
- Dealers will install a new design radiator cap to control pressure and provide greater coolant overflow in the event of overheating.
Recall number 98V178000 · Recall details
Questions about the BMW 535I overheating
Which BMW 535I years have engine overheating problems?
The model years with the most reports are 2008 (11 complaints), 2011 (4 complaints) and 2015 (2 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used BMW 535I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history