2018 BMW X3: engine failure

Filed Aug 14, 2026 · Engine · NJ

There were several radiatior hose leaks that happened in the winter due to the outdated plastic housing and lines that seized and cracked with colder temperatures. It has become extremely common historically and not considered affordable part or labor to replace.

Filed Oct 10, 2025 · Engine, Transmission · FL

Vehicle: 2018 BMW X3 VIN: [XXX] My 2018 BMW X3 has had continuous oil and coolant leaks for several years. Major parts have already been replaced including the turbocharger, oil cooler, water pump, turbo lines, radiator hose, thermostat, and valve cover gaskets. The dealer recently confirmed my crankshaft seals are leaking. These issues are consistent with a defective Positive Crankcase Ventilation (PCV) system, which causes excess crankcase pressure and oil leaks. BMW issued an Extended Limited Warranty for PCV/valve cover defects on other models but said my VIN isn’t included—even though I’m experiencing the same failure pattern. This creates potential fire and safety hazards from oil leaking onto hot engine components, as well as the risk of sudden engine failure and environmental hazards from oil dripping onto roads. I respectfully request that the federal safety agency investigate whether 2018 BMW X3 vehicles should be included in BMW’s PCV/valve cover recall or extended warranty coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 29, 2025 · Engine · FL

BMW uses plastic coolant pipes which become brittle and crack causing huge issue with entire coolant system. It’s a known issue for bmw repair facilities including engine failure

Filed Mar 17, 2025 · Electrical, Engine · CA

My 2018 BMW X3 xdrive30i G01 series has been experiencing persistent overheating issues, even in cold temperatures as low as 40 degrees. The coolant reservoir boils vigorously while driving, but the temperature gauge does not indicate overheating, and no warning lights appear. The only alert displayed is a low coolant warning instructing to refill coolant or to top off. Recently, I noticed coolant and other fluids leaking from underneath the vehicle, along with a strong burning smell coming from the engine. Adding BMW brand antifreeze/coolant did not resolve the issue. Despite these ongoing issues, the authorized BMW dealership has refused to inspect the cooling system further because no fault codes appear. Independent repair shops have also been unable to diagnose the root cause. This presents a serious safety risk. The vehicle is overheating without warning, which could result in sudden engine failure while driving. The boiling coolant, burning smell, and fluid leaks also raise concerns about a potential fire hazard. This vehicle is now undrivable and unsafe. I urge the federal safety agency to immediately investigate potential cooling system and sensor defects in this model.

Filed Mar 6, 2024 · Electrical, Engine · 152,942 miles · NY

The contact owns a 2018 BMW X3. The contact stated while his wife was driving 65 MPH, a message advising to stop driving was displayed, and the vehicle simultaneously shifted into neutral(N) independently. The vehicle stalled in the middle of the highway and failed to respond while depressing the accelerator pedal. The message advising to drive with caution was displayed after several minutes, and the contact was able to continue driving upon depressing the accelerator pedal. The vehicle was taken to an unknown dealer to be diagnosed. The vehicle was not diagnosed or repaired. The vehicle was then towed to the local dealer, where it was diagnosed that coolant was leaking from a hose. Additionally, the dealer informed the contact that excessive engine temperature could have damaged the cylinder head and the rod bearings. The dealer recommended replacing the engine. The vehicle was not repaired. The contact stated that his son-in-law then towed the vehicle to another facility, where the vehicle was diagnosed by a mechanic; however, no engine failure or coolant leak were found. The contact related the failure to an unknown recall. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 152,942.