2019 BMW X3: engine failure

Filed May 29, 2026 · Engine · PA

I am submitting this complaint regarding a serious mechanical and safety issue involving my 2019 BMW X3. On or around January 21, 2024, while driving from my home, a warning signal suddenly appeared on my dashboard related to the vehicle’s cooling system/engine. Due to safety concerns, I pulled into a nearby Wawa parking lot, which was the safest available place to stop at the time. I turned the vehicle off and waited approximately 15 minutes before carefully driving the vehicle back home. After inspection and diagnosis, I was informed that the vehicle required extensive repairs, including an engine replacement and cooling system repairs. At the time the coolant warning appeared, the replacement engine reportedly had approximately 59 miles on it. I believe a sudden engine or cooling system malfunction while operating a vehicle presents a serious safety concern for drivers, passengers, and others on the roadway. In addition, I experienced issues involving the shark fin antenna on the vehicle, which I understand may be connected to broader complaints involving BMW vehicles. I am requesting that the federal safety agency review this matter to determine whether these issues may indicate a broader defect or safety-related concern affecting other consumers. I am willing to provide supporting documentation including repair invoices, dealership records, photographs, and any additional information requested. Thank you for your attention to this matter and for your commitment to vehicle safety.

Filed May 21, 2026 · Engine, Transmission · NC

My 2019 BMW X3 equipped with a B46 engine developed a significant coolant leak at approximately 80,000 miles. The vehicle displayed a low coolant warning, and coolant was visibly leaking underneath the vehicle. Around the same time, I began noticing excessive white exhaust/steam during cold starts and, for the first time since owning the vehicle, had to add engine oil between scheduled oil changes. The vehicle is currently undergoing inspection by an independent repair facility. Preliminary findings indicate concerns involving premature failure of critical plastic cooling system and/or oil filter housing components. Based on my research, these failures appear consistent with widespread complaints involving BMW B46/B48 engine cooling system and oil filter housing defects. I am concerned this defect could lead to sudden coolant loss, overheating, engine failure, or unsafe driving conditions. Prior to the coolant warning appearing, there were no significant alerts indicating a major or imminent cooling system failure. The apparent failure of critical plastic engine cooling components under normal driving conditions raises serious concerns regarding the durability and safety of these parts. I have photographs documenting the coolant leak, as well as detailed notes and diagnostic information from the repair facility, available upon request. The vehicle is available for inspection.

Filed Dec 19, 2025 · Engine, Transmission · GA

Reporting a failure of the engine cooling system on my 2019 BMW X3 that developed over time despite repeated repair attempts and ultimately resulted in complete engine failure. Over the past year, the vehicle has experienced ongoing coolant loss and overheating warnings despite multiple coolant-related repairs. When the problem continued, I brought the vehicle to a BMW dealership, where the service department determined that the engine had suffered internal damage consistent with overheating and advised that a full engine replacement was required. These issues occurred during normal driving and created unsafe conditions, including the risk of sudden loss of power or breakdown in traffic. Based on my experience and the repeated nature of the failures despite proper maintenance, it appears that coolant and overheating issues may be persistent in this vehicle model rather than isolated to a single component, and I am concerned that other owners may be experiencing similar safety-related defects. A investigation into this is warranted.

Filed Dec 3, 2025 · Engine, Fuel system · GA

I am reporting repeated coolant system failures and overheating on my 2019 BMW X3 . I have had 4 coolant-related repairs in under 3 years, including the coolant reservoir boiling after service. Most recently, the problem recurred despite prior repairs. This is a Certified Pre-Owned vehicle with warranty history, and I believe this is a systemic engine/cooling defect that poses a risk of engine failure or fire. Other owners may be affected. A recall or investigation is warranted.

Filed Oct 25, 2025 · Engine · IL

Turbo coolant lines/ Oil filter housing failed I am reporting failure of the oil filter housing and turbo coolant lines on my 2019 BMW X3. These parts are leaking coolant due to defective plastic components and sealing surfaces, which causes sudden coolant loss and overheating risk while driving. This is a widespread issue affecting many BMW owners and has been documented in forums, service centers, and BMW technical bulletins. The failure poses a safety hazard, including potential engine failure at highway speeds, loss of power, and risk of breakdown or accident. BMW has not issued a recall or warranty extension, and consumers are being forced to pay out of pocket over $3,000 for what appears to be a systemic design flaw in the cooling system.

Filed Aug 13, 2025 · Engine · GA

2019 BMW X3 VIN # [XXX] Odometer - 70,000 miles Dealer - United BMW, 11458 Alpharetta HWY, Roswell GA 30075 I purchased my 2019 BMW x3 from United BMW in October 2022. The car had a little over 22K miles at the time or purchase. My vehicle suffered catastrophic engine failure on [XXX], just 48 hours after a BMW service technician topped off coolant in response to a warning light. The vehicle has been properly maintained, including repairs from United BWM Service and a BMW Certified independent mechanic. The engine failure occurred under normal driving conditions, rendering the engine inoperable. I have received a full diagnostic from BMW and they acknowledged that the independent mechanic was not at fault. Previous contact with BMW Consumer Relations and the United BMW service manager has not resolved the issue. The repair estimate from United is $40,000. Since I purchased my vehicle from United, they offered to reduce my repair cost to $33,000. I still owe $25,000 on this vehicle. Given the sudden failure shortly after BMW's service, this appears to be a serious reliability and potential safety defect. I have copies of my service records. Kindly advise. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 6, 2025 · Brakes · NV

Parking brake is malfunctioning and has seized in lock position, and will not release. Making the vehicle unmovable and not drivable, leaving me stranded.