2011 BMW X5 engine problems

Filed May 9, 2026 · Engine · TX

There's currently an open recall for a number of BMW engines involving aluminum bolts in the vanos assembly that shear, strip, and break off completely. The open recall is somehow excluding some vehicles with the same exact problem like my 2011 BMW X5 xdrive35i N55 E70 with the inline 6. Currently my vanos bolts are already sheared off and sitting in my oil pan. My vehicle started misfiring and acting strange while I was traveling at 75mph, luckily I made it into a gas station and had to have it towed from there because it wouldn't start again and hasn't since. BMW knows about these hazardous bolts and chose to not repair some of them directly endangering drivers and their families. My local BMW dealership won't even confirm that the bolts in my oil pan are the vanos bolts even after I showed them photographic evidence which I still have. I've spoken with BMW North America and they said I need to get it confirmed by my local dealership, so where dies that leave me? Here...over $8,000 in damage/loss from an obvious manufacturer error that THEY ARE AWARE OF!

Filed May 27, 2025 · Electrical, Engine · 132,000 miles · AL

The contact owns a 2011 BMW X5. The contact stated that the vehicle failed to start. The vehicle was towed to an unknown dealer but was not diagnosed or repaired. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 132,000.

Filed Feb 12, 2025 · Engine · NY

EGR failure where the diesel emissions come into the cabin via the hvac system Dealer said the EGR cooler needs to be replaced. This is a know problem and recall on the 2012 and 2013. This makes the fumes to the driver when first driving the car in the morning dangerous as carbon monoxide and diesel exhaust enter the car. My friend has an exact similar problem and this issue is known on all the BMW boards

Filed Jan 24, 2024 · Engine, Fuel system · WV

I own a 2011 BMW x5. the federal safety agency shows 15 recalls for my vehicle type; however, the federal safety agency must be relying upon BMW for the VIN numbers as: 1.) my vehicle doesn't show up for recalls; 2.) I have never been contacted by BMW for many of those recalls - in fact, I have not received a letter from BMW in many many years, and among the 15 recalls above, I have never received any notification of for at least October 20, 2023 the federal safety agency CAMPAIGN NUMBER: 23V707000 Camshaft Timing Bolts May Loosen Causing Stall Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash. April 18, 2018 the federal safety agency CAMPAIGN NUMBER: 18V248000 Electric Auxiliary Water Pump Failure October 30, 2017 the federal safety agency CAMPAIGN NUMBER: 17V683000 PCV Heater may Short Circuit March 2, 2017 the federal safety agency CAMPAIGN NUMBER: 17V138000 Front Driveshaft Universal Joint may Fail May 17, 2016 the federal safety agency CAMPAIGN NUMBER: 16V311000 Front Driveshaft Universal Joint may Fail. When I call BMW, they say there are no recalls outstanding on my vehicle and this the federal safety agency states there are recalls, but does not associate my VIN with the recalls, so say there are no recalls outstanding. The most prominent recent issue was that when my BMW dealership diagnosed a check engine light in my vehicle, they wanted to replace a SCR DEF active tank for $3,000, but it turned out that BMW had an almost 100% failure rate for the same part and issued an extended warranty for this part under their technical bulletin SI B01 23 16. They denied replacing the parts under the warranty stating that it was limited to 10 years/120,000 miles. I had only 101,600 miles on my car, but they stated the 10 year limited out the warranty from the in-service date. However, my car had many emission system related issues including just a few years previous.

Filed Jan 15, 2024 · Engine · WV

After BMW replaced my battery on 1/11/24, a check engine light immediately appeared. It said that the Scr Active Tank needed to be replaced and it would cost upwards of $3,000. I immediately found a the federal safety agency bulletin that informed that this particular part had been on recall, but had a 10 year/120k mile limitation. My car only had 101k miles, but BMW denied my recall work on goodwill because they say it was well past 10 years of my in-service date. The warranty, however, should still be effective, as many customers have different rates of utilization and I am still 19k short of the mileage limitation, which should not be time limited. BMW worked with the federal safety agency for a reason - they acknowledged that they had a flawed part, and this needs to be changed at their expense, not passed on as $3,000 unfairly to the customer. Please see the recall bulletin attached.

Filed Oct 18, 2023 · Engine · 107,000 miles · GA

The contact owns a 2011 BMW X5. The contact stated that while stopped at a stop sign, the vehicle unexpectedly turned off and independently shifted into neutral. The “Engine Failure - Reduced Power” message was displayed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to a faulty variable valve timing system. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 107,000.

Filed Sep 22, 2023 · Engine · MD

Passport BMW told us that there was a recall on the engine of our X5 and asked if we had to add oil periodically; our answer was yes. We were told that the engine failed the oil consumption test performed by Passport BMW and the engine needed to be replaced. Passport then said that we had to pay for the replacement of the engine, $2,500. The engine has been replaced, however the engine still leaks oil and now also leaks antifreeze additionally, engine malfunction is displayed permanently on the dashboard.

Filed Sep 9, 2022 · Electrical, Engine · OK

I was driving to work one morning On the highway, when I suddenly heard a loud sharp noise from the engine bay that followed with the engine and battery lights turning blinking on my display with sudden loss of steering. I panicked but quickly put my vehicle into neutral with my hazard lights on and slowly hit my brakes till I came to a complete stop on the highway. I got my vehicle towed back and upon further inspection saw that the idler pulley bolt snapped completely off. I researched and saw that this bolt has been recalled twice already with the same issue. If this was during a heavy traffic situation it could have been far worse.

Filed Jun 24, 2022 · Engine, Fuel system · IL · fire

Our car get on fire from begin low on oil, we stopped on the side and went on another car to get oil at the gas station and Suddenly star on fire and our entire car truck burned. Luckily we were able to get out off the car on time.

Filed Jun 20, 2022 · Acceleration, Engine · NY

As I was slowing down to make a turn, the vehicle went into neutral and shut off. I immediately turned it back on and put it in drive and the same thing occurred moments later. I start it again and drove away enough to safely park. I let the car rest in the off position for 30 minutes and it drove fine. There were no warning lights and the vehicle is well maintained with scheduled services. I contacted the nearest reputable mechanic and explained the situation. I drove it there. They found no faulty codes when they plugged in the computer and the battery has no issues. The vehicle drives fine now, but this is very concerning especially since this took place in local traffic.