2019 BMW X7: engine overheating

Filed Apr 27, 2026 · Engine, Transmission · 102,000 miles · NY

The contact owns a 2019 BMW X7. The contact stated that while driving at an undisclosed speed, the engine overheated and the engine seized. The check engine warning light was illuminated. While attempting to restart the vehicle, the vehicle restarted with the power train warning light illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed, and the failure reoccurred. The failure was a persistent failure. The contact stated that there was thick white smoke coming from the exhaust. The contact noticed a fuel odor on the interior and exterior of the vehicle. In addition, the RPM was elevated. The vehicle was towed to the dealer. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall or warranty. The failure mileage was approximately 102,000.

Filed Dec 4, 2025 · Brakes, Electrical · NV

My 2019 BMW X7 is under Safety Recall 25V‑644 for an overheating/fire-risk defect, but the recall remedy is unavailable. The vehicle has now experienced multiple safety-related failures that appear to be progressing. BMW diagnosed the following failures: • Emergency Call System Malfunction • GPS and maps not working • Failure of the TCB telematics module • Failure of the antenna and TCB battery due to fluid ingress • Battery voltage in the red zone • All four tire pressure sensors beginning to fail • Collapsed engine mounts attributed to heat • $11,296 in repair estimates related to electrical and heat damage Immediately after picking up the vehicle from BMW service, a new battery/charging system warning light appeared that was NOT present before the visit. This suggests further deterioration of the electrical system. The combination of: • an open fire-risk recall with no fix available, • fluid ingress damaging telematics components, • multiple electrical and safety-system failures, and • new warning lights appearing after service makes this vehicle unsafe to operate, especially for long-distance highway travel. I am requesting that the federal safety agency document this as a safety-defect case and assist in ensuring BMW provides a safe resolution.

Filed May 12, 2025 · Electrical, Engine · 54,000 miles · CA

The contact owns a 2019 BMW X7. The contact stated that while attempting to start the vehicle, the message that the starter motor was overheating was displayed and the vehicle failed to start. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the starter motor. The vehicle was repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The manufacturer was not notified of the failure. The failure mileage was 54,000.

Filed Mar 11, 2025 · Electrical, Engine · 58,000 miles · FL

The contact owns a 2019 BMW X7. The contact stated that upon a warm start of the engine, a "System Overheating re-starting engine possible after cooling" message intermittently appeared on the instrument panel. The contact would be forced to open the hood to allow the engine to cool for several minutes before the vehicle would start up and resume normal operation. The dealer was notified of the failure and the contact was informed that the vehicle was not included in the federal safety agency Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.

Filed Feb 6, 2025 · Electrical, Engine · IA

When trying to start the vehicle it will say that the starter has overheated and to try restarting again in xx seconds. This occurs randomly and the car does not indicate that the engine is over heating, just the starter. When looking online it appears there is an active recall for this very issue but my VIN is not registered with the recall. BMW believes that my car should be covered under this warranty and advised filing a report with the federal safety agency to have it extended to my car. The vehicle is a 2019 and was produced in March of 2019.

Filed Oct 31, 2024 · Electrical · 85,000 miles · TX

The contact owns a 2019 BMW X7. The contact received notification of the federal safety agency Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING). The contact stated that while stopped at a traffic light with his son inside the vehicle, the vehicle STOP/START function activated and the engine shut off; however, when the light turned green the contact attempted to drive; however, the vehicle failed to restart or operate as intended. The contact stated that there was a message displayed that the engine and the starter had overheated. The contact stated that the vehicles behind had to go around the vehicle. The contact was concerned for the safety of his son and himself due to the failure. The local Police Department was contacted and arrived on the scene to control the flow of traffic. A tow truck arrived on the scene and towed the vehicle to a parking lot. The contact stated that the following day the vehicle was towed to a local dealer and the recall repair was performed; however, the vehicle was not diagnosed. The contact was informed that the replacement of the starter was an out-of-pocket expense. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage 85,000.