2023 Chevrolet Bolt EV electrical problems

Filed Oct 28, 2026 · Electrical · SC

THE VEHICLE EXPERIENCES AN INTERMITTENT COMPLETE LOSS OF REARVIEW VISIBILITY WHILE REVERSING, DISPLAYING A BLANK SCREEN AND A RED WARNING TRIANGLE. THIS is a severe safety hazard that violates FMVSS111. The dealership held the vehicle for more than three weeks due to extensive dashboard while wiring harness failures on the communication loop. Yet GM has failed to issue a safety recall.

Filed Aug 1, 2026 · Brakes, Electrical · MD

The vehicle suffers from severe, unresolvable electrical failures causing recurring loss of propulsion, shifting lockouts ("No Driving Conditions" / stuck in Park), complete exterior lighting failures, and loss of communication with the Restraints Control Module (RCM) and airbag impact sensors. The primary failure involves short circuits, open circuits, poor terminal contact, and thermal damage with melted, charred wiring and exposed copper in the main harness[cite: 6]. On May 25, 2026, OnStar telematics issued a critical red alert for the Regenerative Braking System[cite: 7]. All damaged components and diagnostic reports are available for inspection upon request[cite: 6, 7]. Safety risks include sudden loss of propulsion at highway speeds, total headlight and tail light loss during night driving, and potential non-deployment or malfunction of airbag restraint systems during a collision. The issues have been repeatedly reproduced and confirmed by an authorized dealership through 7 repair attempts between Sept 2024 and Apr 2025. Diagnostic steps included opening GM TAC Case 9-13634782861, consulting GM engineers, and testing 33 ground points. On Oct 28, 2024, the dealer and an insurance adjuster officially confirmed the failures are covered under GM warranty and unrelated to any accident[cite: 8]. Symptoms first appeared on Sept 10, 2024 (at 5,144 miles) with a "Waiting initialization to shift" message, blown Fuse 58, and loss of power to the ECM. Warning signs prior to subsequent failures included "Service Trans" warnings, "Reduced Propulsion" alerts, dim headlights, Check Engine Lights, SRS/Airbag warning lights, and total shifting lockouts after hitting road bumps. Despite replacing Fuse 58 (multiple times), Fuse 64, IP Fuse 7, the underhood fuse block, ECM connector terminals, headlamp assemblies, the RCM module, and multiple airbag impact sensors, the underlying electrical instability remains unresolved.

Filed Jun 22, 2026 · Driver assistance, Electrical · OH

Vehicle infotainment system on 2023 Chevrolet Bolt completely stopped functioning in May of May of 2026. Screen/radio/bluetooth and associated components had no functionality, including backup camera, safety warning features, etc. Dealership confirmed that the system needed replacement entirely and was non-functional. Vehicle was not inspected by any other parties but it was confirmed by the dealership that this is a "common issue" for Chevrolet vehicles, even newer models. There were no warnings prior to the issue - the system simply did not work one day and never functioned again.

Filed May 28, 2026 · Driver assistance, Electrical · CA

Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this component failure, the vehicle is in direct non-compliance with Federal Motor Vehicle Safety Standards (FMVSS): 1.FMVSS 111 (Rear Visibility): The vehicle completely fails to display a rear-view image when shifted into reverse, creating an immediate blind-spot hazard for pedestrians. 2. FMVSS 101 (Controls and Displays): All critical audible safety alerts, pedestrian alerts, and driver warning chimes have been entirely silenced. The manufacturer (General Motors) and the authorized franchise dealership (F.H. Dailey Chevrolet) have acknowledged the failure and have the part on backorder, but refuse to fully cover the safety restoration under warranty or provide a temporary loaner vehicle. This forces the primary driver, a [XXX] senior citizen, to choose between total isolation or operating a hazardous, federally non-compliant vehicle. This appears to be a systemic manufacturing or design defect inherently tied to the internal HMI module architecture on the late-model Chevrolet Bolt EV platform, rather than individual wear and tear. A formal investigation is requested to mandate a safety recall and enforce full manufacturer accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 8, 2026 · Electrical, Transmission · CA

Recurring electronic transmission shift control failure on a 2023 Chevrolet Bolt EV. The Electronic Transmission Shift Control Pushbutton Circuit Board (GM part designation K212) has failed twice within approximately 9,300 miles. First failure occurred at approximately 45,695 miles in July 2025. The dashboard displayed a malfunction indicator and a "Service Transmission" warning. Diagnostic trouble code U18D2 was set: Lost Communication with Transmission Range Selector Control Module on the Powertrain Sensor CAN Bus. The selling Chevrolet dealer replaced the K212 pushbutton circuit board and reprogrammed the HPCM2 module. Second failure occurred at approximately 54,969 miles in March 2026, only about 9,300 miles after the first repair. Same diagnostic code family, including the identical U18D2 code, plus U0076, U18C6, and U240E. The same dealer replaced the same K212 pushbutton circuit board a second time. The repair was processed under manufacturer warranty. Safety risk: when the failure occurs, communication with the transmission range selector is lost intermittently and without warning, leaving the vehicle unable to be reliably shifted into Drive, Reverse, or Park. This creates a clear hazard in traffic, parking lots, and on inclines. The failure mode is sudden and the warning lamps appear only after the malfunction has begun. The component is located beneath the center cup holder area. There is no visible waterproofing or moisture isolation around the circuit board, despite its location directly under a known liquid exposure zone. The failed component from the second repair was reportedly shipped back to GM by the dealer. The vehicle is available for inspection. The failure has been confirmed twice by an authorized Chevrolet dealer.

Filed Apr 3, 2026 · Brakes, Electrical · GA

While driving at approximately 45 mph, the regenerative braking feature of the vehicle suddenly failed, and also generated a master caution light on the dashboard display. This is the second time this has happened while driving and resulted in a sudden, alarming change in vehicle dynamics. Regenerative braking is the normal operation regime of the vehicle, with the traditional mechanical-hydraulic brake pedal available for added braking, as demonstrated by the Chevrolet dealership during a test drive and confirmed with the vehicle manual. Furthermore, the vehicle will no longer shut itself off and could pose a fire risk when stored in a garage, parking deck, other vehicles, etc. These issues happened in November 2024. The car was returned to the dealer for warranty repair. Even after extensive repairs to the electrical system, the car has repeated the alarming failure mid-drive. This indicates that there is a serious problem with the electronic and poses a serious safety risk.

Filed Dec 17, 2025 · Electrical · CA

This vehicle just stopped in the middle of traffic, not giving me time to pull over. The screen just said, "service mode", and would not go into neutral to enable the car to be pushed to a safe spot. Highway petrol had to stop traffic and have it towed off. This was endangering everyone involved. If this is a common problem with other chevy bolts, it definitely needs addressing.

Filed Aug 6, 2025 · Airbags, Electrical · MD

I own a 2023 Chevy Bolt EV. Around 9/27/24 at 5,144 miles, the vehicle began experiencing serious electrical and propulsion issues. It has been to the dealership six times, each requiring a tow due to total loss of function. Issues include blown fuses, charging failures, shifting problems, propulsion loss, and repeated warning messages. Repairs have involved fuse box replacements, a new wiring harness, and other electrical components. The car has spent over 100 hours inactive at the dealership. Problems have been confirmed by technicians, but persist despite repairs. Additional safety concerns include a defective impact sensor, airbag warning lights, and a burned-out headlamp. These compromise crash readiness and visibility. Due to ongoing issues, the vehicle has been parked and unused for months, as it is unsafe and unreliable to drive. The manufacturer has not inspected the vehicle. Based on repeated failures and unresolved safety risks, I believe this vehicle qualifies as a lemon and request further investigation.

Filed Mar 24, 2025 · Electrical, Suspension · CA

I just purchased this vehicle from Hertz authorized dealer in December 2024, January 2025 the Electrical system, infotainment became non functioning. This caused my vehicle to stall, on star safety charge, etc to fail and not function. No communication within the vehicle that is an electric vehicle that requires this system for all components to function and provide a safe car to drive. Power to vehicle, back up camera, on star for emergencies, charging, this affects all the ADAS components in this vehicle to function properly causing a safety hazard. Took this vehicle into the dealer they diagnosed this system is down and no communication with radio. Also Set false DTC was completed. It is scary that a radio component can cause an emergency service to fail and other components in the vehicle to fail all electrical components in this vehicle. I am writing a complaint to Hertz since they stated all was okay when the radio, on star never worked, an update for the main system was no corrected and they failed to make sure the EV batteries were properly connected.

Filed Jan 20, 2025 · Electrical, Fuel system · CA

The vehicle was driving and lost all power and came to a stop. After about 5 seconds vehicle regained power. The "check engine light" illuminated on the dash. took to dealer and stated could not replicate problem. Only have the report from vehicle computer and the EV technician did not understand the information and had to call GM for help. Got car back and problem happen again. Dealer had GM specialist out to help. GM reset computer and problem just happens again.