We were driving on the highway about 65mph when it began to rain. I turned the wipers on and off several times but they would not respond. After a few minutes the rain intensified I tried the wipers again and they worked. I recently needed the wipers again and they failed.
The worst 1996 Chevrolet C10 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Visibility10
- Brakes3
- Seats2
- Acceleration1
- Airbags1
Specific symptoms reported on the 1996 Chevrolet C10
Recalls 6
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Vehicle description: crew cab pickup trucks. The front, inner corner of the fuel tank can contact the body sill either intermittently or constantly. This movement can cause a discernible noise and, over time, can wear a hole in or crack the fuel tank at point of contact.
- Risk
- This condition can result in fuel leakage and a distinct fuel odor if the tank were filled above the level of the hole or crack. In the presence of an ignition source, a fire could result.
- Remedy
- Dealers will inspect the fuel tank for wear and, either install a spacer between the fuel tank and the front crossmember, or if necessary, replace the fuel tank.
Recall number 98V187000 · Recall details
Visibility: windshield wiper/washer
- What is wrong
- Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
- Risk
- This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
- Remedy
- Dealers will replace the wiper motor circuit board and cover.
Recall number 98V150001 · Recall details
Seats
- What is wrong
- Vehicle description: extended cab and 2-door utility vehicles equipped with reclining seats and the easy-entry feature. These vehicles exhibit a condition in which a pinch point exists in the recliner mechanism that can trap and pinch a person's hand or finger(s) when the easy-entry feature is activated.
- Risk
- This pinching can cut the hand or possibly sever the finger(s) without prior warning.
- Remedy
- Dealers will install a protector cover over the recliner mechanism.
Recall number 97V037000 · Recall details
Suspension: rear: springs: leaf spring assembly: u-bolt, leaf spring to axle
- What is wrong
- The four u-bolts nuts on either side of the rear axle were under-torqued.
- Risk
- Vehicle usage could cause the nuts to loosen and eventually fall off the u-bolt. This could result in sudden loss of vehicle control increasing the potential for a vehicle crash.
- Remedy
- Dealers will check the u-bolt nut torque and re-torque any loose u-bolts to specification.
Recall number 96V082000 · Recall details
Vehicle speed control
- What is wrong
- These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, "accelerator control systems."
- Risk
- Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.
- Remedy
- Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.
Recall number 96V057000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Certain trucks have fuel rail assemblies with an improperly crimped end retainer clip that results in a fuel leak.
- Risk
- If fuel leakage occurs and an ignition source is present, an engine compartment fire could occur.
- Remedy
- Dealers will inspect the fuel rail assembly and replace any fuel rail assembly with a julian date code of 95318 through 95338.
Recall number 95V243000 · Recall details
Technical service bulletins for the 1996 Chevrolet C10 2
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 1996 Chevrolet C10 owners say
Most recent owner complaints, unedited.
Windshield wipers stop working intermittently. Vehicle has not been examined by a dealer. There is a recall, 98v150001, but this vehicle is not affected due to VIN. *ak
Consumer contacted manufacturer regarding recall 98v 150 001/98 v 150 000 concerning windshield wiper wiring. Manufacturer stated that vehicle was included in recall. However, dealership insisted that vehicle was not included in recall. *ak
While driving and without warning windshield wipers will work intermittently, causing driver not to have a clear view. Dealer has been notified, and stated that despite a recall issued for wiper motor failure it did not apply to the consumers vehicle. *ak
97v037000/ seat recliners recall repair failure on two occasions at heartland chevrolet; liberty, mo; phone # 816/781-3500. Appointment made by dealer for third time. Feel free to provide any further information on this matter.
Engine revs up when engine is cold and idles down the road at 35 MPH I first reported this to the dealer soon after I bought this truck and was told that it was the way a 5.0 l. Engine operated and nothing could be done about it after several near crashes because of the rpms of the engine as I have approached icy intersections because the wheels would be pushing me and the brakes would lock up I would have to shift into netural to keep from runnng into the intersection, after 5 years I have this is a safety hazard and the dealer may have been in error as tho the problem or otherwise. This has happened several times (the icy roads) am I the only one having this problem?
While traveling 55 MPH during a rain storm windshield wipers worked initially, and suddenly stopped and worked intermittently. Consumer has had this problem several times.
While using the windshield wipers they quit working without a warning just like mentioned in recalls 98v150001 and 98v150000.
Windshield wipers failed while driving in rain, without a serious problem. I had brosz repair look at them and the printed circuit module was bad, so a new replacement was bought and installed. While visiting your website, I see there was a recall on this year and model pickups. I contacted my dealer who says my pickup was not recalled. I think that, as the faulty part s now known to be faulty, chevrolet should re-imburse me for the part($53.43), and the small labor bill($10).
While using windshield wipers they would work on and off. Consumer had to hit the box for windshield wipers to start they were working again. But, then they stopped working. There was a recall for this problem. But, this vehicle was not included due to VIN.
Compare the 1996 Chevrolet C10
Other model years
Questions about the 1996 Chevrolet C10
Is the 1996 Chevrolet C10 reliable?
Owners have filed 16 complaints about the 1996 Chevrolet C10, 2.3 times a typical C10 model year.
What is the most common problem with the 1996 Chevrolet C10?
Windows, wipers and visibility, with 10 complaints. Next is brakes (3).
How many recalls does the 1996 Chevrolet C10 have?
6 recalls, covering fuel system, gasoline, visibility and seats.
Was there a recall on the 1996 Chevrolet C10 visibility?
Yes, 1 recall: 98V150001. Check your VIN to see if your car still needs the free repair.
What year does the Chevrolet C10 have the most visibility problems?
The Chevrolet C10 model years with the most visibility complaints are 1995 (22 complaints), 1994 (10 complaints) and 1996 (10 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Chevrolet C10?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history