I have a recall letter from gm canada concerning antilock brakes. When I took the van to be fixed, the dealer would not do it because the van was converted to an rv by roadtrek and it would require 16 hours labor to repair the brakes. Neither gm or roadtrek would cover the cost. How can I get this resolved.
The worst 1996 Chevrolet C30 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes4
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes4
Recalls 5
Seats
- What is wrong
- Vehicle description: extended cab and 2-door utility vehicles equipped with reclining seats and the easy-entry feature. These vehicles exhibit a condition in which a pinch point exists in the recliner mechanism that can trap and pinch a person's hand or finger(s) when the easy-entry feature is activated.
- Risk
- This pinching can cut the hand or possibly sever the finger(s) without prior warning.
- Remedy
- Dealers will install a protector cover over the recliner mechanism.
Recall number 97V037000 · Recall details
Tires: bead
- What is wrong
- These tires have bead damage which occured during tire mounting.
- Risk
- This damage to the tire reinforcing structure in the bead "toe" area causes a bulge in the sidewall after the tire is inflated. This condition will result in a slow air loss causing the tire to go flat. However, it is possible for the damage to result in a rapid air loss causing injuries to anyone if they were handling the tire when this occurred.
- Remedy
- Dealers will demount each tire and inspect for bead damage. If bead damage is found, the tire will be replaced.
Recall number 96V117000 · Recall details
Suspension: rear: springs: leaf spring assembly: u-bolt, leaf spring to axle
- What is wrong
- The four u-bolts nuts on either side of the rear axle were under-torqued.
- Risk
- Vehicle usage could cause the nuts to loosen and eventually fall off the u-bolt. This could result in sudden loss of vehicle control increasing the potential for a vehicle crash.
- Remedy
- Dealers will check the u-bolt nut torque and re-torque any loose u-bolts to specification.
Recall number 96V082000 · Recall details
Vehicle speed control
- What is wrong
- These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, "accelerator control systems."
- Risk
- Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.
- Remedy
- Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.
Recall number 96V057000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Certain trucks have fuel rail assemblies with an improperly crimped end retainer clip that results in a fuel leak.
- Risk
- If fuel leakage occurs and an ignition source is present, an engine compartment fire could occur.
- Remedy
- Dealers will inspect the fuel rail assembly and replace any fuel rail assembly with a julian date code of 95318 through 95338.
Recall number 95V243000 · Recall details
Technical service bulletins for the 1996 Chevrolet C30 2
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 1996 Chevrolet C30 owners say
Most recent owner complaints, unedited.
No summary listed for above vehicle. *ak( dot number: )
Vehicle used for police use. Consumer stated when traveling at 30 MPH the rear brakes grab and also lock up, causing the vehicle to freeze. Consumer also stated when the problem occurs the occupants inside the vehicle being forced into the windshield. Consumer has contacted the dealer.
Short in cigarette lighter caused interior lights and door locks to fail.
The ABS braking system malfunctioned when applying the brakes hard and quickly. Had an accident, applied the brakes quickly and they malfunctioned, causing the vehicle to roll 30 feet and run into another vehicle. Dealer said that was how the brakes worked.
Compare the 1996 Chevrolet C30
Other model years
Questions about the 1996 Chevrolet C30
Is the 1996 Chevrolet C30 reliable?
Owners have filed 5 complaints about the 1996 Chevrolet C30, 1.3 times a typical C30 model year.
What is the most common problem with the 1996 Chevrolet C30?
Brakes, with 4 complaints.
How many recalls does the 1996 Chevrolet C30 have?
5 recalls, covering seats, tires and suspension.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Chevrolet C30?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history