Tl* the contact owns a 2006 chevrolet cobalt. The contact stated that the vehicle was taken to a local repair facility for a routine oil change when the contact was informed that there was an abnormally strong gasoline fuel odor emitting from the vehicle. The mechanic discovered a fuel leak and performed a diagnostic. The mechanic advised the contact that the fuel sending unit was fractured at the top of the fuel tank. The vehicle was repaired. The failure and current mileage was 60,000. Updated 01/04/11*lj the consumer stated the same problem he experienced a recall was issued. However, his VIN was not included. Updated 01/10/11
2006 Chevrolet Cobalt fuel system complaints
Page 15 of 17: complaints 401 to 430 of 466, newest first, as owners wrote them.
Tl*the contact owns a 2006 chevrolet cobalt. While the driving approximately 40 MPH, the contact was approaching a complete stop and smelled a strong odor of fuel emitting inside and outside of the vehicle. The vehicle was taken to an independent mechanic where they informed that the failure was contributed to the fuel pump module. The vehicle was not repaired. There was a recall under the federal safety agency campaign id number 09v419000 (fuel system, gasoline: delivery: fuel pump). The recall stated that the vehicle must be either originally sold or currently registered in the states indicated in the recall; however, the vehicle was not included due to those specifications mentioned. The failure mileage was 105,000. The VIN was unavailable.
Gasoline leak from fuel tank at fuel pump, 2006 chevy cobalt registered in new york state.
Tl*the contact owns a 2006 chevrolet cobalt. She was not clear on how the failure began because someone else was operating the vehicle. The driver began to smell gasoline coming from the vehicle while driving at any speed or while parked. The vehicle was taken to an independent mechanic where she was informed there was a fuel leak and it was in the process of being repaired. The failure and current mileages were unavailable. The VIN was unavailable.
Upon exiting vehicle, noticed extremely strong smell of gas on 9/1/10. Gas smell did not dissipate, and in fact got stronger over the period of one week. Noticeable inside and outside the cabin. Mileage at time of failure was approximately 72500. Spoke with dealer about problem, told that it did not fall under current recall conditions and there was nothing they could do. Had mechanic look at it, who confirmed that the fuel pump module needed replaced the lines attached to it had cracked and was leaking fuel on the top of the tank. Extreme fire hazard. Repairs were $760. Fuel pump module was replaced after diagnostics and having the tank dropped. Part available. Exact description of problem falls under the federal safety agency campaign 09v419000 recall. Car is not in recall state, but issue has been indicated to be related to high heat. Heat in current state (wv) has been 90+ degrees for more than 2 months. Dealer did not look at recall, only at the vis which did not include my car's VIN, apparently. This is an extreme safety issue, and should be expanded to include all 2006 chevy cobalts who have similar parts in their car. The state specific recall has been indicated in numerous complaints abundant on the internet to be a false, as people are affected nationwide. Gm claims that safety is their number one concern, but they do not (according to the rep I spoke with ) have an ongoing investigation into whether they should expand this recall into other states. This is appalling and needs looked into by someone who has the consumer's safety in their best interest.
Car smelled like gas all the time, wouldn't start easily when cold. Gas was leaking from the top of the fuel pump. Fuel pump was replaced.
Tl* the contact owns a 2006 chevrolet cobalt. The contact stated that there was an overpowering odor of gasoline in from the rear of the vehicle. The contact later discovered that the fuel line was leaking gasoline. The contact located a recall for the failure under the federal safety agency campaign id number 09v419000 (fuel system, gasoline: delivery: fuel pump) but was advised by the dealer that his VIN was not included. The vehicle was not repaired. The VIN was not available. The failure and current mileage was 53,000.
I had just returned home from shopping in my 2006 chevrolet cobalt. I noticed a strong smell of gasoline at the back of the car. I looked under the car and saw gasoline was leaking from the top of the fuel tank and collecting on the ground. After lowering the fuel tank it was easy to see the problem. The fuel return line had fractured at the top of the fuel pump module. The car was undriveable. Fortunately this happened in my driveway. I bought a new fuel pump module at my chevrolet dealer for $304.36 and replaced the part myself. I understand there is a recall for this problem but not in my state. I live in pennsylvania which is not part of the recall. I have retained the old part.
Tl* the contact owns a 2006 chevrolet cobalt. While driving approximately 55 MPH, the contact smelled a strong odor of fuel. The vehicle was taken to an independent mechanic where they detected an internal fuel leakage and informed that the fuel pump would need to be replaced. There was recall under the federal safety agency campaign id number 09v419000 (fuel system, gasoline delivery: fuel pump); however, the recall indicated that the vehicle must be registered or sold in one of the states mentioned in the recall defect. The contacts vehicle was not a part of the recall due to the state exclusion. The vehicle was being repaired at the owner's expense. The failure was approximately 43,000. Updated 11/19/10 *cn updated 11/23/10
2006 chevrolet cobalt fuel leak. Plastic port on top of fuel pump assembly cracked. I see there is a recall in certain states for this problem, but I live in virginia and that state is not listed in the recall.
I have a 2006 chevy cobalt that is registered in ohio but has been in florida for a year and a half, there is a recall on the fuel pump but gm does not want to honor it ,gm says that the heat in the southern states will cause the fuel pump to crack , should it matter where it was registered since it has been here this long. I did pay to have it fixed how do I get my money back?
Tl* the contact owns a 2006 chevrolet cobalt. The contact stated there was an unusually strong odor of gasoline. She then noticed that gasoline was leaking from the vehicle. The dealer and the manufacturer were both notified and the contact was advised the vehicle was not under recall. The vehicle was not repaired. The failure and current mileages were 82,150. Updated 11/16/10.
Just like a similar recall the plastic supply or return port on my cars reservoir assembly has cracked. Potentially leading to a fuel leak that could cause decreased efficiency and performance. Worse, if that leaking gasoline comes into contact with an ignition source of any kind, it will ignite.
Tl*the contact owns 2006 chevrolet cobalt. The contact stated that the fuel lines on the vehicle were cracked and caused fuel to leak from the fuel pump. The vehicle was inspected by a mechanic who stated that there was a recall for the fuel system related to the fuel pump, but the contact was told that his vehicle was not included in the federal safety agency recall campaign number 09v419000, fuel system, gasoline:delivery:fuel pump. The failure mileage was 119000. The current mileage was 122000.
1. Fuel odor in vehicle. 2. Fuel pump module leaking at seal on pressure line. Fuel leaking causing great hazard to drive vehicle 3. Vehicle was repaired at authorized dealer where vehicle was purchased. (dealership has old parts) the part that was replaced at a cost of $550.35 was the same part number in recall of 2006 chevy cobalts, however this VIN# was not included in the recall and was said to be not covered or reimbursed because the vehicle was no longer under warranty, and because it had 101k miles on it. A very dangerous driving situation knowing there was huge risk for fire on the vehicle while driving it.
Tl* the contact owns a 2006 chevrolet cobalt. The contact stated there was an overpowering gasoline odor in the interior cabin. When starting the vehicle, there was an abnormal squeak from the vehicle rear. The vehicle was taken to a local mechanic where the contact was informed that there was a crack in the fuel line. The vehicle was not repaired and there were no prior warnings of the failure. The failure mileage was 52,000 and the current mileage is 52,756. Updated 11/03/10. *lj the fuel pump module was replaced. Updated 11.04/10
I recently purchased a used 2006 chevy cobalt. With-in two weeks started noticing gas smell coming from the car. The fuel system plastic supply/ return port on the modular reservoir assembly cracked and fuel is dripping from the area.
Tl*the contact owns a 2006 chevrolet cobalt. The contact stated while driving at approximately 50 MPH, he noticed an abnormal and overpowering gasoline fuel odor. The dealer advised there were no recalls for the vehicle. The vehicle was taken to a local repair facility where the contact was informed that the fuel line had fractured and there was fuel sitting on the fuel tank. The dealer advised replacing the fuel pump and fuel line. The manufacturer was not contacted. The VIN was not available. The failure mileage was approximately 43,125 and the current mileage was approximately 43,200.
Tl* the contact owns a 2006 chevrolet cobalt. While exiting the vehicle the contact noticed a strong gasoline odor. When he returned to the vehicle, the odor had become overpowering. The contact was able to locate the federal safety agency campaign id number 09v419000 (fuel system, gasoline: delivery: fuel pump) yet when inquiring with the manufacturer, he was told his VIN was not included in the recall. The vehicle was not repaired and the failure persisted. The failure and current mileages were 150,000.
Tl*the contact owns a 2006 chevrolet cobalt. While the vehicle was parked in the garage, the contact smelled a strong odor of fuel. Immediately the vehicle was removed from the garage to a safe location. The vehicle was taken to an authorized dealer where the technician stated that the failure was contributed to a fuel pump module leakage. The federal safety agency recall campaign id number 09v419000 (fuel system, gasoline: delivery: fuel pump) was related to the failure; however, the VIN was excluded from the recall. The vehicle was repaired. The failure mileage was unknown.
Started leaking fuel approximately jan 2010. Loss of fuel mileage affected my asthma which caused me to go into hospital. Was inspected and was reported that the lines were leaking. You can smell gas fumes within 100 feet of car.
Having accident because power steering went off. The car was in shop (vara chevrolet san antonio,tx)on april 28, 2010. Asking dealer to fixed it. Saying no parts. After 2-3 weeks got an accident, dealer still did not have parts. Took car to the shop. (benson chevrolet san antonio tx) dealer called allstate without asking or informing us. They did not want to pay. Car is in the shop since may 13 2010 until today's date (june 27 2010) asking for rental car. Local dealer authorized it. After gmc chevrolet found out we put a complaint on bbb cancel rental meantime the car is still in the shop. Due to the complaint. They knew the consequence why sent letter without no parts and now do not want pay for the repairs.the car is 2006 and it has 4 recalls. 1. Fuel pump. 2. Power steering not fixed on time. 3.power train: automatic transmision.4.structure. Already had fuel pump and power steering defected.
I have owned my 2006 chevy cobalt since june 2006 and have had numerous problems out of this car. I have had to pay out of pocket for every repair because they seem to all happen before a recall is issued and the dealerships will not refund money on the repairs. 1) A/C leaks water in passenger side floor board. I have had it in the shop 3 times and it is still leaking. No one can figure out why the water is leaking into the car. 2) gas tank had to be replaced due to fuel lines cracking. 3) power steering went out while my husband was driving on the interstate and was about 130 miles from home. 4) the car would die if the RPM's got too low, this was caused by a carbon build up on the idler. 5) there is no way to check the transmission fluid and it is starting to slip and take forever to upshift. 6) the key gets stuck in the ignition and will not come out. 7) the drivers side door gets stuck and will not open. 8) the door latch sometimes messes up and the door does not close. 9) the stereo display and buttons no longer work. I can not use the cd player for fear of losing the cd for ever since the eject button doesn't work. I can not see the clock or what station the radio is on. The car lost its value so fast that even after 4 yrs of having it I still can not trade it in due to the amt. I still owe on it. So I am stuck driving this piece of crap until it is paid for. I have already invested several thousands of dollars into this car for these problems. I believe that the car is a lemon and I should be reimbursed for the car and all of the out of pocket repairs I have had to make.
I own a 2006 chevy cobalt. In the past week my wife and I have noticed a strong odor of fuel in the passenger cabin and around the vehicle after we have stopped. I called chevy and they tell me their is no recall on my vehicle for fuel problems. However, I see the that there is a recall on the same year, make and model for fuel issues that are eerily similar to mine. The gentleman from gm said that chevy would not cover this issue. I believe that this is a chevy issue and that the federal safety agency should get involved with this.
To whom it may concern, I am an owner of a 2006 chevrolet cobalt VIN [xxx] . The reason I am filing a complaint is in february I had a problem with an incredibly strong gas odor filling the cabin of my car and so I went to the dealer I purchased it from and they found that the fuel pump module needed replacing. They did the repair work and charged me a total of $558.89 for the replacement of the pump. I am aware that there is a recall for 2006 cobalts for faulty fuel pump modules (recall #09226). I tried to get reimbursement for the repair work since my VIN is well within the range of recalled vehicles but gm is claiming I have no right to do so. Any help you could provide me with would be greatly appreciated. Thank you. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Tl*the contact owns a 2006 chevrolet cobalt. While the vehicle was parked, the contact smelled a strong odor of fuel. The vehicle was taken to an authorized dealer. There was a recall related to the failure under the federal safety agency campaign id number 09v419000 (fuel system, gasoline: delivery: fuel pump). However, the VIN was excluded from the recall defect. The vehicle had not been diagnosed or repaired at the time of the complaint. The failure mileage was approximately 103,000.
I see there are issues on the fuel module on the 2006 chevy cobalts, and I took it to get replaced however when I take my car to get diagnosed it continues to say there is something with a misfire, and my fuel evaporating. I am having multiple problems with my 06 cobalts and has I have done extenuous research and every problem I've found online over 1000 complaints and blogs, and sites where customers are all complaining about the same issue. I am a working college student and drive to work and school everyday. My car stopped on the freeway the other day, and almost caused an accident however the vehicle slammed on their brakes. Not only the fuel line but also my car key does not come out the ignition. All these issues are ongoing and I have found over 10,0000 unsatisfied consumers all with the same issues with the cobalts. This is a big issue, and I am tired of dealing with chevrolet as this is there product and they are only trying to get the money and make you pay for all the services. These are major issues all going out at the same time.
On november 2, 2009 there was a strong fuel smell, I brought the vehicle to my repair shop and they dropped the tank and found that the fuel pump port was leaking, pump was replaced and the old pump is availble
Yesterday 03/20/10 on saturday night at 11:30pm to 11:40 pm my vehicle cobalt at close to 40 km/hr speed stop working. Like ignition off. All gauges goes to off condition like vehicle is moving without engine running.outside temp.-1degree c. I placed emergency lights on and put in parking mode then I restart my car again and it starts. This is happened second time. I took to dealer last month but there was no code. I complained to gm earlier also. They told me take to dealer when it happen and in running condition. But on saturday at 11:30 pm on night which dealer service station is open? I have 4 times earlier sudden acceleration problem in the same vehicle also. Pl do something before it met with accident.
I have a 2006 cobalt. The fuel pump started to leak gas. I was wondering why this was not part of the recall for this problem that has been in effect for other states. I live in missouri.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Chevrolet Cobalt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history