2021 Chevrolet Colorado engine problems

Filed Oct 24, 2026 · Brakes, Engine · OK

The brake booster vacuum pump broke and caused my brakes to stop working properly while driving on the highway. There were zero warnings from the vehicle I went to press on my brake and it was stuck i luckily was able to push it down enough to safely stop

Filed Sep 30, 2026 · Brakes, Engine · 65,500 miles · CA

The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving 40 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was depressed to the floorboard and the engine seized. The contact stood on the brake pedal. The vehicle was towed to the dealer, where it was diagnosed with a fractured camshaft. The contact was informed that the brake vacuum pump fractured the camshaft, and the camshaft was fractured in half. The contact was informed that the camshaft needed to be replaced. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 65,500.

Filed Aug 5, 2026 · Brakes, Engine · 106,000 miles · TN

The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving approximately 75 MPH, the engine revved without the accelerator pedal being depressed. The contact stated that while turning onto an exit ramp, the brake pedal was depressed to slow the vehicle; however, there was resistance to the brake pedal, and an excessive amount of pressure was needed to depress brake pedal to stop the vehicle. There were no warning lights illuminated. The vehicle was not taken to be diagnosed or repaired. The dealer was informed of the failure. The dealer informed the contact that failure might cause the complete engine failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

Filed Jul 29, 2026 · Brakes, Electrical · TX

Brake vacum pump experienced a catastrophic failure. I was unable to step on the break because the break pedal was hard. I ran thru a red light. I was told the brake vacume pump shattered & pieces of metal went into my engine

Filed Jul 5, 2026 · Brakes, Engine · AL

While driving on the parkway, the engine revved, and then the brakes became hard as a brick. The truck was unable to be stopped. There were no warning lamps or indications there was a problem, it happened suddenly and immediately. Other drivers' and my own safety was at risk because I could not stop the truck. Here is the diagnosis from the GM service center where it was towed to: "After the removal of the valve cover, the tech found the pump in pieces, and the end of the exhaust camshaft was damaged, as presented in the photos. The quote attached depicts all that is being replaced with this repair." The is a know and acknowledged GM defect that has affected well over 3 million vehicles to date. There was a recall issued for some models, but not the Chevrolet Colorado. There are many reports online of other Colorado owners having the exact brake vacuum pump failure, resulting in damage to the camshaft.There is also a class action lawsuit filed in Michigan in early 2026, involving the same brake vacuum pump failure, for some of the models that were not included in the recall. This is an extremely dangerous mechanical failure that GM is aware of.

Filed Jun 25, 2026 · Engine · 43,500 miles · UT

The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at 30 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the camshaft actuator valve needed to be replaced. The vehicle was not repaired. The contact associated the failure with Special Coverage Program: N232430470 (Camshaft Position Actuator Valve Solenoid - Bank 2 (Left Side) Exhaust ); however, the VIN was not included in the program. The manufacturer was notified of the failure and informed the contact to call the federal safety agency Hotline for assistance. The failure mileage was 43,500.

Filed Feb 14, 2026 · Engine · GA

There is a coolant leak from the hoses stemming to the thermostat housing. This has been commonly Reported amongst the same vehicles across the country. No damage to the hoses and no accidents to trigger leak. No light triggered. Just leaks visibly under the car

Filed Dec 31, 2025 · Electrical, Engine · VA

The engine coolant temperature gauge is stuck at approximately 160•F. Cooling fans are running at high speed constantly. The thermostat is stuck in the open position. The vehicle is less than 100,000 miles. There is a “Special Coverage Bulletin N242484760” that has indicated the issue is occurring regularly with my type of vehicle but my specific VIN is excluded due to misplaced parameters. The part is readily available at the dealership in which we are getting the part fixed because so many vehicles of my make and model are having this issue. The cost of the repair will be $1,200 and will be out of pocket because my VIN is excluded but clearly affected by the same faulty system for the coolant. This is a mistake as my vehicle is have the exact same issue as all of the others “covered” in the special coverage. We are seeking an appeal and want to file a complaint that my vehicle is excluded and will have to pay $1,200 where other customers will not be required to do so.

Filed Dec 18, 2025 · Brakes, Engine · AZ

In December 2024, at under 50,000 miles, my 2021 Chevrolet Colorado suffered complete brake failure caused by vacuum pump failure. The vacuum pump failure led to irreparable internal engine damage, requiring complete engine replacement under warranty. Sudden, complete brake failure in traffic could have led to a serious accident causing injuries or death to myself and/or others. The component was inspected by the manufacturer and the service advisor at the dealership stated this was "kind of a known issue on Colorados". There were no warning lamps, messages, or symptoms of the problem prior to the failure. This vacuum pump failure is documented in GM Technical Service Bulletin #21-NA-268, which addresses vacuum pump failures on other GM vehicles. The identical failure mode in my 2021 Colorado demonstrates this is a systemic manufacturing defect, not an isolated incident.

Filed Nov 25, 2025 · Brakes, Engine · 70,029 miles · CA

The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and failed to decelerate as intended while the brake pedal was depressed. An unknown message was displayed. In addition, the contact stated the vehicle failed to respond properly while the accelerator pedal was depressed. Upon inspection, the contact noticed an abnormal engine oil leak. The vehicle was towed to the residence. The vehicle was later towed to a local dealer, where it was diagnosed with an exploded brake booster and metal shavings inside the engine. The vehicle remained at the local dealer unrepaired due to the cost. The local dealer could not guarantee that the repairs would correct the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.