2021 Chevrolet Colorado: sudden loss of power

Filed Jul 9, 2026 · Brakes · PA

While driving downhill nearing a stop sign my wife went to apply the brakes to stop and all she had was an extremely hard brake pedal. She panicked that she “no brakes.” She was only going about 20 MPH, and was able to stop the vehicle but it took an extraordinary amount of effort to do so. Had she had to make a sudden stop for a child, another person, or something else, she would not have been able to stop without negative consequences including possible death. There were no warning signs, vehicle pulled out of driveway and brakes were normal. Less than 10 seconds later no more power brakes. The vehicle had the vacuum pump seize which eliminated the power boost and the pump is operated by the exhaust camshaft which also got damaged and needs replaced. Chevy dealership estimated the repair at $2,600. Upon researching the vacuum pump, this is a common failure on multiple GM vehicles resulting in sudden brake loss. The vacuum pump should have been designed with a shear pin, so that if it fails the camshaft does not get damaged. Had the vacuum pump been properly designed and it was the only failing part, the repair cost would be $500 versus $2,600. Also, there should have been a temporary backup system so you would not lose power boost.

Filed May 29, 2026 · Brakes, Electrical · CA

I am reporting a serious safety defect involving my 2021 Chevrolet vehicle. While driving, multiple warnings appeared including “Service Power Steering,” “Steering Assist is Reduced,” “Service ESC,” and “Service Battery Charging System.” The vehicle then lost steering assist, braking performance became unreliable, and it created a serious risk of crash. The vehicle later shut down completely and has remained inoperable. The failure appears electrical and affected multiple critical systems at once, suggesting a cascading system malfunction. Since the incident, the vehicle has not restarted or operated normally. I have replaced the battery, alternator, starter, ignition switch, brake vacuum pump, ECM, spark plugs, fuses, and relays, but the issue persists. The vehicle still shows charging system faults and severe battery drain, indicating an unresolved underlying electrical defect. I have found numerous reports from other 2021 Chevrolet owners describing nearly identical failures, including sudden loss of power steering assist, ESC warnings, charging system failures, battery drain, and complete vehicle shutdowns. This suggests a possible widespread defect affecting this model year. Given the loss of steering assist, braking irregularities, and full vehicle shutdown while driving, I request the federal safety agency investigate this issue for a potential safety-related defect and determine whether a recall or manufacturer action is necessary.

Filed Jan 13, 2026 · Steering · 45,000 miles · MI

The contact owns a 2021 Chevrolet Colorado. The contact stated that while attempting to make a right turn from a traffic light, the vehicle lost power steering functionality, and the steering wheel became difficult to turn. The contact depressed the brake pedal the vehicle started operating as intended. The dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The failure had occurred twice. The contact related the failure to the federal safety agency Campaign Number: 21V213000 (STEERING); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 45,000.

Filed Nov 15, 2025 · Steering · OH

Starting my 2021 Chevy Colorado Zr2 in the morning and noticed the "service power steering, drive with care message. 40,000 miles. No power steering. This would clear after leaving vehicle sit and restarting. After reading many articles and found the recall notice for 2015 colorados. Based off of postings I didn't drive it due to the possibility of losing power steering while on the highway, which had happened to several people after restarting and clearing the error. I think GM never corrected the issue and is present in newer models. I took my vehicle in for the repair of the power steering gear and it was very costly. I feel GM should issue another recall, specifically with the possibility of losing power steering on a crowded highway is a major safety concern.

Filed Aug 16, 2025 · Transmission · CA

I own a 2021 Chevrolet Colorado Lt Extended Cab 2WD. The rear differential has failed prematurely at 70000 miles. the failure caused loud whining/grinding noises, vibration, and unsafe driving conditions. After researching online, i found many other 2021 Colorado owners reporting the same issue with rear differential failure, often at relatively low mileage. This indicates a widespread defect in the differential assembly. There are existing GM Technical Service Bulletins (20-NA-034, 20-NA-156) related to axle/differential noise and machining defects, but GM has not issued a recall or extended warranty coverage. Differential failure can lead to loss of power to the wheels or lockup while driving, which poses a serious safety risk. I request that the federal safety agency investigate this issue and require GM to issue a recall or Special coverage adjustment for the affected vehicles.