2023 Chevrolet Colorado engine problems

Filed Nov 8, 2026 · Acceleration, Engine · CA

While driving on freeway started losing speed and felt a sudden jolt/ break. This has happened three times in the last year. No accidents but can easily cause an accident.

Filed Sep 11, 2026 · Electrical, Engine · GA

My truck is in the shop for Engine Wiring Harness Chafe. they are making me pay 1200 dollars for an issue that is known by chevy. I feel like I should not have to pay

Filed Jun 14, 2026 · Electrical, Engine · MI

On May 15, 2026, my 2023 Chevrolet Colorado (2.7L L3B turbocharged engine, approximately 49,000 miles) lost its entire engine oil charge while in normal operation, and at NO point did the low-oil-pressure warning light illuminate to alert me. While driving, a loud buzzing/vibrating noise developed near the upper engine and the center dash area. The vehicle continued to run with no oil-pressure warning of any kind — no low-oil-pressure light and no audible oil-pressure chime. Concerned by the noise, I immediately pulled into a parking lot and checked under the hood. The engine oil dipstick was completely dry, showing no oil whatsoever. I added 3 quarts of oil and the dipstick still showed no reading, indicating the engine had been operating with a critically low or empty oil level. Throughout this entire event, no oil-pressure warning activated. There was no external oil leak, no puddle where the vehicle is normally parked, and no oil in the coolant reservoir, which suggests the oil was being consumed or lost internally rather than dripping out — a condition the driver cannot see or anticipate without a functioning warning system. Drivers depend entirely on the oil-pressure warning system to alert them before oil starvation causes catastrophic engine damage or sudden engine seizure. An engine that seizes without warning while the vehicle is in motion creates an immediate and severe crash risk — sudden loss of motive power in traffic, on a highway, or in an intersection. The complete failure of this warning system to illuminate during a total loss of oil is, by itself, a safety defect independent of whatever is causing the oil loss, because it removes the driver's only opportunity to stop the vehicle safely before failure. These symptoms also align with existing GM service documentation: TSB 25-NA-309 addresses high idle, oil consumption, oil leaks, and MIL illumination caused by internal failure of the PCV oil separator, and service campaign N232415060 addresses a

Filed Jun 14, 2026 · Acceleration, Engine · MI

My 2023 Chevrolet Colorado (2.7L, approx. 49,000 miles) experiences sudden, intermittent loss of motive power involving the 8-speed automatic transmission. The transmission sets codes and the vehicle drops into limp mode, capped at roughly 45 mph, without warning. The most dangerous symptom is a total loss of acceleration from a stop, especially on inclines — pressing the accelerator produces no response. On one occasion, stopped on a slight incline, the vehicle rolled backward toward the car behind me when it failed to move forward on accelerator input. I narrowly avoided a collision. On a separate occasion, after pressing the accelerator with no response, the vehicle then suddenly lurched forward into cross traffic; repeated presses produced inconsistent, delayed engagement, nearly causing a collision. To climb inclines I now have to hold the brake while applying throttle and slowly release the brake to prevent rollback. These are unpredictable loss-of-control events that create a serious crash risk in traffic. I believe this relates to a known issue affecting the GM 8-speed automatic transmission. The vehicle is currently at a GM dealer and I have an open GM Customer Care case. No crash, fire, or injury has occurred yet, but two near-collisions have.

Filed May 18, 2026 · Engine · IN

Engine light came on. Fan ran high. Had it towed to the dealership. Has 39,000 miles on it. Needs a new upper radiator hose due to a defective hose. Apparently, after reading online, GM is aware of this issue. Now we have to pay the diagnostic fee and $850 for a new hose and a flush, as well as the tow bill! Now can’t get the part for a week or 8 days and then have to wait on the repair. This is unsatisfactory that there is a known problem and isn’t covered or hasn’t been a recall.

Filed May 6, 2026 · Engine · CA

Faulty Radiator Inlet Hose, upper radiator hose failure, outlined in PIT6494A. This is the third time that the light on the dashboard has come on for failure, the first time they "Fixed it" the second time they said it was the Battery, it was NOT!! This time they are saying what it really is, The Radiator Hose FAILURE, since the vehicle is only 3 years old but over the 36k mile WARRANTY, they will NOT fix! failure on their part.

Filed Apr 9, 2026 · Engine · CA

Coolant leak, upper radiator hose, TSB issued PIT6494A over $500 repair. Not covered under any warranty.

Filed Mar 6, 2026 · Engine · NY

The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 20K miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.

Filed Feb 25, 2026 · Engine · CO

Radiator hose near failure, lose of coolant could be catastrophic. Upper Radiator hose quick disconnect O-ring inside failed.

Filed Feb 19, 2026 · Engine · KS

Since Friday, February 23rd 2026 when my 2023 Chevy Colorado first start blowing oil out of the oil pan. almost 5 qts total was lost when it arrived at the dealership. Truck was out of service from Friday until the following Wednesday, January 28th. The truck was picked up and taken on a drive out to (January 29th, 2026) Waverly, KS from my hometown of Prairie Village, KS about 70 miles. On the way back home the truck went into safe mode at highway speeds. Lost all acceleration and barely made it off the side of the road before getting hit. Truck went back to dealership after being towed 70 miles. Where it was kept until Friday, February 6th. During this time at the dealership, they thought the problem was fixed, where again blew out all the oil while driving. Finally received the truck back. Check engine lights were still on but truck was holding oil and driving decent. Truck was doing fine until Monday February 16th. I was at a job and was driving home to finish the day. Again on the highway at highway speeds, truck goes into safe mode and limp it to gas station to again be empty on oil. It is still sitting there. Just last January the truck needed a new Transmission at 48,000 miles and at the same time a wirinig harness for the back-up camera needed replaced. Alot of things have been going wrong with this truck to be so new. It has cost me alot of out of pocket expenses.