2007 Chevrolet HHR: ball joint or control arm failure

Filed Aug 25, 2017 · Steering · 18,000 miles · CA

Steering column rattle and severe shake at 18,000 miles. Machined rotors and replaced front brake pads. Replaced intermediate steering shaft, lower control arms, sway bar bushings, stabilizer links and outer tie rod ends per research and recommendations from dealerships and independent gm-trained mechanics. Rattle still not cleared, latest dealer visit says only possible fix is to replace steering column, another $1000 repair. Car still rattles at low speed over uneven surfaces - problem is documented online extensively. The lower control arm bushings the dealer said were worn out and defective that came off the car were kept for inspection and found to not be defective. Gm has redesigned all these parts knowing they are often defective and sued the steering column supplier in 2009, but still no recall other than the steering column motor. Called chevrolet to open a case and their only response was to take it back to a dealer. Ludicrous.

Filed Dec 3, 2015 · Brakes · 100,000 miles · LA

Tl* the contact owns a 2007 chevrolet hhr. The contact stated that while driving at approximately 35 MPH, the brake pedal was depressed as the front of the vehicle shook violently. The failure recurred numerous times. The vehicle was taken to an independent mechanic where it was diagnosed that the brakes failed and needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was taken back to the independent mechanic where it was diagnosed that the rotors and outer tie rods failed and the rear brake pads needed to be dusted. The vehicle was repaired but the failure recurred. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Dec 3, 2013 · Brakes, Locks · 86,987 miles · LA

I had to replace left and right control arms on this vehicle,brakes constantly can't unlock doors from inside,have to roll down window to unlock,now having engine problems and one of the control arms going bad again.plus something is causing rain to get in my car somewhere,because when it rains at smells mildewy.

Filed Sep 12, 2013 · Driver assistance, Steering · 91,675 miles · OH

I have a 2007 chevy hhr and few months ago my traction control light come on and engine light. Then shortly after my power steering went out. The power steering has been going out periodically...last time was on a exit ramp on the curve. I almost put it in the ditch. I understand that the cobalt had recalls on these items but not the hhr. Which makes no sense because of the same chassis and all. I took it to ed schidmt chevy in perrysburg ohio and they said I need a steering column (because power steering module is in column), power steering motor, camshaft valve actuators, left lower control arm, and front struts. I have read a lot of internet forums and there has been many complaints on same issues. Chevy should take care of this. Dealership wants $2300+ for the repairs.

Filed Dec 23, 2010 · Brakes, Engine · 11,604 miles · MA

It would be easier to list the things that are ok with this car. I've resurfaced or replaced the rotors several times (four times in one year) after consistently complaining to the dealer that it sounded like things were falling off the car. The car's braking and steering capacity is extremely diminished. I've replaced a broken stabilizer control arm and now I'm told the front end needs to be rebuilt. This damage is a direct result of the continuing problem with the rotor warping. The check engine light is on more than off and its been in at least 10 times for this issue. Gm customer service is aware of these issues and refuses to return customer calls. *ln updated 11/29/11. *jb updated 12/06/11.

Filed Jun 25, 2009 · Suspension · 26,533 miles · MI

Tl*the contact owns a 2007 chevrolet hhr. The contact stated that the vehicle makes a loud noise when driven between 25-30 MPH. He took the vehicle to the dealer several times and they replaced the front passenger side stabilizer control arm; however, the failure was not corrected. He took the vehicle to three other service centers for diagnostic testing and they confirmed the stabilizer failure. The contact took the vehicle back to the dealer and they stated again that the front stabilizer failed. The estimated cost for repair was $300. The failure mileage was 26,533 and current mileage was 61,353. Updated 8/7/09 *cn updated 08/11/09.