2011 Chevrolet HHR: fuel leak

Filed Mar 26, 2026 · Fuel system · OH

Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.

Filed Dec 19, 2024 · Fuel system · KY

Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.

Filed Aug 24, 2024 · Fuel system · IL

Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?

Filed Oct 23, 2023 · Fuel system · IL

Fuel line/gas leaking from faulty tube carrying ignitable flammable fluid...no warning just smell and sighting at stop..went to savoy IL dealer immediately and had replaced @ 1k cost approx. 2+ yrs ago...cel

Filed Feb 8, 2023 · Fuel system · TN

Fuel line is rusted and leaking. This is apparently in numerous models and prior years as well. This metal piece on the fuel line is leaking. Fuel leaks out no matter how short of time you drive. I’m concerned with a fire and live on a fixed disability income and it’s food or the vehicle which I need to get to the doctor.

Filed Jan 16, 2023 · Fuel system · NC

While refueling the vehicle several weeks ago I noted a strong smell of gasoline. I did not see any visible fuel leak at the gas station. Drove the vehicle home approximately 10 miles, 20 minutes travel time. Gasoline smell persisted. On exit from the vehicle the smell became strong and I observed a liquid dripping/pooling under the vehicle on the driveway. Drips were occurring from the driver side rear of the vehicle slightly in front of the left rear wheel approximately 6 inches interior from the edge of the vehicle. After 15 minutes the drips subsided. Vehicle has not been used or moved since this incident.

Filed Aug 13, 2022 · Fuel system · WI

The fuel line on the drivers side just in front of the rear tire is leaking fuel.

Filed Mar 27, 2022 · Fuel system · MI

A small gas leak developed in the fuel line....

Filed Dec 17, 2021 · Fuel system · MI

The fuel line has corroded near the driver rear tire and is leaking fuel near the exhaust pipe. The leak is bad enough to create a 12 inch puddle in less than 30 seconds.

Filed Oct 26, 2021 · Fuel system · MI

My 2011 Chevy HHR has developed a fuel leak that has progressed to the point where I no longer drive the vehicle. The gasoline appears to be leaking from the fuel line, just in front of the left rear tire and leaks only while the engine is running. I understand that the federal safety agency is conducting an investigation into this matter, but has not included my year of vehicle. I would like for the federal safety agency become aware that this fuel leak issue does effect vehicles with manufacture dates outside the scope of its investigation.

Filed Sep 7, 2021 · Fuel system · MA

I would like to report of a fuel line leak in the fuel lines from the fuel tank to the engine. The lines are leaking due to corrosion caused by the manufacturer encasing the lines in , I think heat resistant tape to protect from the nearby exhaust , and a plastic type clamp that holds and separates the fuel and brake lines . The vehicle does not have to be running for fuel to leak as it will leak if just the key is on due to the electric fuel pump. I have read many complaints of this online and understand that there is an investigation into this safety problem ( fire hazard due to proximity of exhaust) . This is a manufacture design / engineering problem and should be recalled by them . This is a very expensive repair ( $ 1,200.00 if only fuel , more if brake lines need replacing ) , that not all people will be able to afford and will therefore ( like myself ) continue to drive their vehicles until they can have it repaired or worst try to attempt to repair it themselves ( not something I would suggest ). I think everybody is at risk if vehicles are driving around leaking fuel ( and maybe losing brakes next ) because people can not afford to fix them . I hope tragedy doesn't strike first ( as seems to be the case nowadays ) before people are motivated to take action . Attached are pictures showing the lines dry and wet . The tape and clamp are visible in picture , showing where corrosion and leaking occurred .

Filed Sep 2, 2021 · Fuel system · NY

Fuel line leaking very heavily. I have read that some of these vehicles were recalled but mine was NOT. The fuel is leaking at a very heavy drip drip drip rate from the rear driver side and causing fuel puddles. This is directly near the exhaust system. I’m very surprised as I also have an identical 2008 Chevy HHR with similar but lighter leak. I’m surprised that this is not a recall given a fuel leak. It should also be an EPA issue. Why would the car use coated brake lines but no stainless or coated lines for fuel when they run so closely to the exhaust system? This should easily be a safety/environmental recall related issue.