The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.
Chevrolet HHR fuel leak problems
165 of the 3,575 owner complaints about the Chevrolet HHR describe fuel leak, most of them for the 2009 model year.
- owner complaints
- 165
- worst model year
- 2009
- typical repair cost reported
- $1,000
- typical mileage
- 123,000
By model year
Often reported together
Fuel smell 46Check engine light 7Fuel pump 6Fire or smoke 3Won't start 1
What owners say
Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.
Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.
The fuel line on the left back side of the car (back drivers side) was leaking fuel when it was in parking or sitting and idling. Noted fuel smell when car started up and was idling, car was taken to independent mechanic, fuel line was broke in 2 places. It was broke close by the wheel are and the other spot was back by the exhaust
Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.
Car is leaking gas on left rear side. Corrosion and rust due to fuel line.
The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to the federal safety agency Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.
The contact owns a 2009 Chevrolet HHR. The contact stated that while the vehicle was parked, and while driving the vehicle, there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that the vehicle was experiencing excessive fuel consumption. The contact also noticed that fuel had leaked onto the ground. The contact stated that upon inspecting the vehicle, the contact noticed that fuel was leaking from the driver's side rear wheel well, where the fuel tank was located. The contact related the failure the federal safety agency Action Number:Â PE20011(Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?
Fuel leak coming from the Left (Drivers Side) of the vehicle in the area of the rear wheel. There was a strong odor of fuel, Fuel was observed dripping to the ground under the vehicle in front of the Left rear wheel. This condition was observed only when the vehicle was running and in park. The condition does not seem to happen when the vehicle is off and not running. No repair has been made yet , vehicle can be inspected in its current condition. This is a severe safety concern of ignition/explosion due to a fuel leak; risk of property damage or even death. This problem has not been addressed yet to a dealer or local mechanic as of yet . Failed component has not yet been inspected by GM, Police or insurance. No warning lamps or messages were illuminated on dashboard, prior to failure, vehicle did have some difficulty starting, possibly due to this problem, but it did start.
Related recalls
No recalls on record for this model year.
Questions about the Chevrolet HHR fuel leak
Which Chevrolet HHR years have fuel leak problems?
The model years with the most reports are 2009 (42 complaints), 2008 (37 complaints) and 2006 (23 complaints).
How much does it cost to fix fuel leak on the Chevrolet HHR?
Owners who mentioned a price put the repair at about $1,000 (median of 15 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet HHR?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history