Clutch pedal slowly started getting harder to depress since new (I am the original owner). I put on mostly highway miles for the first few years. First the clutch pedal to rod bushing/retainer would wear out causing clutch to suddenly engage with no warning. After multiple bushings, the clutch master cylinders started failing from too much hydraulic pressure. After a total clutch system replacement at 140k miles, we found the root cause to be the fork and ball stud ate into each other due to insufficient lubrication. Clutch worked like new after replacement. At 160k miles clutch is back to very stiff and parts are now failing again, even with often greasing thru bell housing zerk fitting for ball stud.
The worst 1994 Chevrolet K2500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system4
- Brakes3
- Visibility3
- Acceleration2
- Engine2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system4
- Brakes3
- Visibility3
- Acceleration2
- Engine2
- Electrical1
- Lights1
- Seats1
- Suspension1
- Tires1
- Transmission1
Recalls
No recalls on record for this model year.
Defect investigations
Driver's seat frame failure
The office of defects investigation has received 375 reports alleging failure of the driver's seat frame which is prone to breakage at the left front attaching point.when this occurs, the seat may tilt away from the riser during accelerating or braking.(see closing report)
EA97023
Technical service bulletins for the 1994 Chevrolet K2500 2
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 1994 Chevrolet K2500 owners say
Most recent owner complaints, unedited.
After flooring the gas pedal, it stuck to floor caused vehicle to continue accelerating. Once had to shutoff engine another time it happened briefly and fixed itself. Upon inspection I noticed a piece of metal wire splintered and would get caught in other parts when fully depressing accelerator pedal. Bought replacement for throttle cable link. I think this will fix it.
Since it doesn't rain much in phoenix az, this has only happened twice. While driving in a light rain, with the wipers set on intermittent, they quit operating after a period of time. Quite disturbing when you cannot see where your going. After pulling off of the highway and pausing for 20 min, the wipers may again work. Some times it takes a couple of hours. I have tested all of the wiper circuits via the service manual recommendation, with out finding a failure.
The windshield wipers were inoperative.
Low power and "service engine" light would come on periodically. Dealer "shotgunned" parts but did not fix problem. Got manufacturer involved and admitted to a known problem with the engine control chip. Chip was replaced with one having a handwritten part number and no more problem. Am aware that many other owners experience this same problem and cannot get it fixed. Someone needs to "tell the world" since the manufacturer continues to hide the problem.
. I started to feel a slight vibration occurring in the truck. At this time I was driving about 45 MPH. I began to experience an increasing noise level from the tires. About 1 to 2 minutes later I heard a loud bang. Then I experienced tread separation from the front left tire. Fortunately I did not have an accident.*ak (dot number: vdw8r4a227 tiresize: lt26575r16)
Consumer became stuck in a snow drift in which the brake warning lights started flashing.
Spare tire hoist and storage under the bed of the truck failed sending spare tire loose onto roadway. Extremely dangerous to motorists behind. The cable holding the tire on the truck broke. Although I do not have statistical proof, this spare tire hoist is failing more than necessary as I have been looking under late model trucks and seeing the same frayed cable probably indicating failure as occurred to me. Called chevrolet, claim number c984196 and was stonewalled due to mileage of vehicle. This is a safety issue not a milieage issue/
After driving for approximately 1 to 1.5 hours the engine just died with no warning leaving me with no power in traffic. The first time the engine refired while in gear but the next 4 times I had to pull to the shoulder. I was extremely lucky that no one hit me each time because there was no warning. I have since spoken to another owner of the same vehicle and he described the exact same problem and the same part replacement that the dealer is telling me has to be replaced. This truck has relatively low mileage for its age. Three years ago we also experiancd a problem with the fuel pump and it was replaced under warranty on 9/22/97. Is this a problem that only 2 of us have had? Luckily I wasn't towing my travel trailer at the time.
While driving windshield wipers quit working during operation, causing poor visibility.
Compare the 1994 Chevrolet K2500
Other model years
Questions about the 1994 Chevrolet K2500
Is the 1994 Chevrolet K2500 reliable?
Owners have filed 19 complaints about the 1994 Chevrolet K2500, 3.8 times a typical K2500 model year.
What is the most common problem with the 1994 Chevrolet K2500?
Fuel and propulsion system, with 4 complaints. Next is brakes (3).
How many recalls does the 1994 Chevrolet K2500 have?
No recalls on record.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Chevrolet K2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history