2001 Chevrolet Malibu suspension problems

Filed Apr 9, 2014 · Steering, Suspension · 110,000 miles · MI

This 2001 chevy malibu had the rack and pinion break free from the engine cradle due to frame corrosion. The car is now undrivable and needs new engine cradle (front frame). This is a safety issue and the frame should not rust on a car in a place that could kill somebody. Bad design. Poor quality. Never buy a gm ....ever.

Filed Sep 29, 2012 · Body, Engine · 109,740 miles · CT

I had my car tow to a auto services center cause it would not start, the tech told me it was the starter but said there was another problem the sub frame very rusted and the engine could fall out anytime. They replace the front sub frame,outer tie rod end, sway bar link kit, the cost was $927.39 . Is g m responsible and can I be reimburse for my cost.

Filed Jun 10, 2011 · Suspension · CO · crash

Tl*the contact owns a 2001 chevrolet malibu. The contact stated that while driving between 30 to 40 MPH the vehicle began to violently jerk. As a result, the vehicle traveld into another lane and crached into a curb. The contact also stated that the front passenger side axle was fractured. The vehicle was towed to an independent mechanic, but the failure was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage and VIN were unavailable.

Filed Aug 13, 2007 · Engine, Suspension · 103 miles · WV

I own a 2001 chevy malibu and out of the blue one day my engine just shut down right on the interstate. I have not yet had it checked due to finance problems. Not only that I also have to change my wheel bearings every week to two weeks. I have had this checked and the garage I take it to for all my repairs can't seem to figure it out either. Please help thank you, mrs.sparks

Filed Mar 25, 2007 · Suspension · 54,321 miles · MI

Noticed a howling noise coming from front suspension. Determined to be rf wheel hub/bearing. Replace the hub/bearing.

Filed Aug 27, 2005 · Suspension · 55,000 miles · IA

Can't keep car aligned. Technicians said that they have encountered this with other malibu's. They can't do any more to keep alignment in place. We did a test by aligning car and going back in 2 weeks and alignment has already deviated from set points.

Filed Jul 8, 2005 · Brakes, Electrical · ME

2001 chevrolet malibu has developed problems with the braking and the cooling systems.***no answer required***. *mr one month after the vehicle was purchased the rotor assembly was replaced. The vehicle would turn over but it wouldn't start. The dealer replaced the fuel pump. When accelerating the vehicle's coolant light illuminated on the dash. The dealer determined that there was a leak at the by pass pipe at the lower intake manifold. The alternator was replaced under warranty. The hazard and turn signal switch were replaced. The right outer tie rod were worn loose. The dealer replaced the right outer tie rod ends and set the front end. The right front wheel bearing was replaced. The ABS malfunctioned.

Filed Jun 6, 2005 · Brakes, Suspension · 52,000 miles · WI

Car has vibrations at higher speeds 60+ was told it was tires/wheels they were replaced for $280 for tires and $200 for just steel rims. Car still vibrated at high speeds and also felt like rotors needed to be replaced-the kind of vibrating when braking. Replaced rotors and brake pads $49 a piece for rotors and $40 a piece for brake pads. Car continued to vibrate except when stopping. After time now (3 mos) when the car is vibrating and you go to slow down it shakes the car even worse. Was then told to replace the wheel bearings. Just did that yesterday they cost me $230 not only does the car still vibrate it has a grinding noise when you trun to the right now. Since ive bought it it has vibrations at high speeds and a "rubbing" vv, vv, vv noise when turing right. After replacing wheel bearings the car still makes all the noises and grinds now. Dont know what else to do to fix it, beginning to think im just going to have to replace the entire front end. Really used to trust chevy now im not so sure. I have had way too many problems with this car and I just bought it in july2004- ridiculous if you ask me.

Filed May 3, 2005 · Suspension · 4 miles · MI

Consumer states: ABS system 11oo miles brakes started gridding, at 37000 had to replace master cyclinder, ABS system and the drum and brake lines in 2003 july and is getting worse. Had new brakes pads put on again in january 2005. Now ABS coming on again for 2 or 3 days at a time.

Filed Apr 27, 2005 · Brakes, Engine · MD

2001 chevrolet malibu experiencing problems with brakes, turn signals, cooling system and theft deterrent light. *mr the consumer experienced the following: a continuous brake problem with the rotors, the theft deterrent light illuminated, so the dealer replaced the ignition cylinder the signal lights worked intermittently and the dealer replaced the hazard switch. The right side hub assembly was replaced. There was water in the oil, therefore the intake gaskets were replaced due to leaking. *sc