2003 Chevrolet Malibu suspension problems

Filed Feb 9, 2015 · Electrical, Fuel system · SC

2003 chevrolet malibu faulty ignition switch vehicle shut off in the middle of the road. *mw the consumer stated she had to replace the ignition switch on two different occasions. The first time was september 28, 2006 and the second time was june 3, 3014. After the second switch was installed, the consumer experienced other problems. She was informed the vehicle needed a body control module and lock switches. The dealer installed a chip in the keys, which did not correct the ignition problem. The front struts were replaced and the fuel pump needed to be replaced.

Filed Jan 4, 2015 · Engine, Suspension · 57,500 miles · NJ

We had to have the intake manifold replaced, at 55,000 miles, which didn't occur until 2012, because I don't put a large amount of miles on my car annually. I could not get any money from the recall, because the class action suit payout ended in 2008, and I was never made aware. Both the front and rear struts are leaking fluid. I was told all four need, replacement, and the mounts as well. . The mechanics said normally these shouldn't need replacement until 75,000-80,000 miles minimum, and should have lasted until 100,000 which is normal. I'm a gentle driver who doesn't lend my car out. I drive over speed bumps very slowly in our town, because I didn't want suspension issues. Our town's speed limit is 15 MPH over the speed bumps, and I do 7mph over then. Others with a 1999-2003 malibu, have told me their struts have worn out just as fast also.(at 50,000 miles or so).

Filed Dec 30, 2014 · Suspension · IN

Contanct dealer company will not return calls ask for assistance in resolving issues car needs brake all the way around rotors damageded needs tyrod end has white smoke coming from exaust dealer will not check car they have their own mechanic tell you to contact and you get no response vehicle sold to 76 year old lady and is unsafe I aske if they would trade up it is half paid for I was told no it has to be completely paid off.

Filed Dec 12, 2014 · Brakes, Electrical · 264,000 miles · IN

I tell dealer check engine light on "he says not to be concerned there is white smoke coming from tailpipe ignition can take up to 5 min to get on code says car needs egr valve car needed brakes and rotors all the way around and tyrod dealer will not respond to calls car was recalled for ignition switch never repaired I need to know if I can take it in to chevy dealer ony had 1 month vehicle is not safe and I am 76 there is a waranty on engine and transmission.

Filed Oct 23, 2014 · Brakes, Electrical · MI

2003 chevrolet malibu. Consumer states vehicle stalls. *tgw the consumer stated the fuel pump, battery and remote control were all replaced. However, the stalling continued. The ignition switch was eventually replaced. Also, t he brakes and struts needed to be replaced.

Filed Jul 12, 2013 · Suspension, Wheels · 70,000 miles · AL

While traveling on interstate, relatively new firestone affinity tire on the driver side rear developed a large bump and begin fraying. Recognized problem quickly and pulled over but could have caused a serious accident. Passenger side rear tire shows very little wear and no such issues, indicating that it was not worn out, just a bad quality tire.

Filed Mar 16, 2012 · Steering, Suspension · 44,370 miles · PA

I am currently experiencing loss of steering and suspension performance with my vehicle including significant loss of tire tread for my vehicle. The vehicle bounces and makes screeching sounds while steering a curve on the road. The vehicle was inspected in early march and no mechanical problem was observed or detected. A 4 wheel alignment was also done at a chevrolet dealer a few months back and no problems were found or detected then. I have reason to believe that something is wrong with the mechanical operation of either the steering or suspension component of the vehicle. Kindly investigate and look into this problem. Thank you

Filed Feb 28, 2010 · Suspension · 66,000 miles · ID

My 2003 chevy malibu has noise due to the front strut mounts being broke, noticed on web site 7 other people with the same problem. Some of them have replaced and happened again within 17,000 miles. All cars are between 50,000 to 69,000 miles. I think there should be a factory recall on this problem.

Filed Mar 28, 2008 · Lights, Suspension · 95,000 miles · TN

A few months ago my 2003 chevrolet malibu turn signals stopped working for no reason. Some days they work and some they don't. This is very dangerous if you have to make a turn and another vehicle is behind you. Also the front right side of the vehicle makes a creaking rubbing noise and a clunking noise. It's very irritating.

Filed Sep 13, 2007 · Acceleration, Suspension · 60,923 miles · NY

2003 chevy malibu accelerates on its own. Customer states that the car would drive on its own without putting her foot on the accelerator. **nar**kb the consumer received a recall notice in the mail which stated the accelerator pedal would be inspected only. After having continual problems with the vehicle accelerating on it s own, the consumer took the vehicle to the dealer where it was determined that the accelerator pedal had an internal malfunction. The consumer is seeking reimbursement. The consumer also complained of a rattle noise coming from the vehicle when going over bumps. The dealer inspected the vehicle and found the left front strut and mount were worn. The left side lower control arm was noisy.