2005 Chevrolet Malibu steering problems

Filed Mar 10, 2026 · Steering · 37,000 miles · FL

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There was no warning light illuminated. The contact stated that the failure was related to the U-joint in the steering column, which made the vehicle difficult to control. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

Filed Dec 12, 2025 · Steering · MO

Power steering failing. As I was driving down the road I got a power steering message and chime. No dash light came on and I lost all ability to turn my vehicles steering wheel. I went to add power steering fluid just to learn that my 2005 Chevy Malibu maxx LS comes equipped with EPS(electric power steering). Then I check on the federal safety agency for safety recalls and there is a safety recall for the Chevy Malibu maxx including the 2005 Chevy Malibu maxx. I was pulling safely out of store parking lot into traffic and I had to hit the ditch luckily I didn't get T-boned. Thanks to my reaction time being fast I made it safely outta the road. I am available to have car inspected if needed. It just started on 11/23/2025 I bought the car used a year prior in Nov. 2024.

Filed Nov 20, 2025 · Steering · MD · crash

The steering locked up when the brakes were pressed and the steering wheel was turned to avoid crashing with another car. The result is the crash happened and damage to both cars. Thankfully traffic was only going around 10 mph. If this had happened at high speed my son may have been seriously injured or even killed. The mechanic is working on it now and has reported the power steering module and power steering motor has to be replaced.

Filed Aug 6, 2025 · Steering · TX

The car has a recall for power steering the recall covers the torque sensor in the steering assembly I had the recall done about 6-8 weeks ago & now I’m dealing with another power steering issue I took the car to Chevy & the whole power steering motor has failed they say it is not covered under the recall although it should be other Malibu models are this is very frustrating & unacceptable as I just got a recall for steering done & now I can’t even drive my car

Filed Aug 4, 2025 · Electrical, Steering · KS

The EPS began sporadically and severely jerking the steering very powerfully while driving and stationary and draining the battery at an accelerated rate necessitating multiple replacements of and charging 2 batteries to get to and from my job and anywhere else making everyday life very difficult beginning in early 2024. A couple months before this issue became a daily and constant occurrence in in February 2024 between the 6th and 13th I had a stabilizer link and control arm on the right side replaced and an alignment done at Firestone, on the document for the alignment it states no manufacturers recommended services necessary on suspension. The mechanic who replaced the parts told me that the EPS issue is a likely cause for the steering system damage as a vehicle is not meant to remain stationary while the wheels are forcibly turned as is the case when the EPS takes over and jerks the wheel often to the extremes of its function. I have video of this on multiple occasions and it can be inspected still occuring. I took it to Hendrick Chevrolet Shawnee Mission in April 2024 and explained the services done recently and the mechanics opinion on the EPS. They held my vehicle for 3 days not saying it would take so long, during which I had to use a truck I had just bought and was not ready to be driven to get to work, it's transmission blew and has sat since. They called me to come pick it up and only once there told me they had refused to replace the recalled EPS unit "due to loose steering" as quoted from the document Given to me. I asked them to reconsider since this was the only vehicle I had running and charging batteries and being nearly forced off of the road or into other cars daily was very concerning, they simply told me to take it to another dealership for "a second opinion" I stated I didn't have time for another dealer to hold my car for days because my truck had just gone OOC, they held their position and I drove it until forced to buy a new car in 03/2025

Filed Jul 24, 2025 · Steering · MN

Power steering went out and water pump

Filed Jul 11, 2025 · Driver assistance, Steering · 220,000 miles · MO

The contact owns a 2005 Chevrolet Malibu. The contact stated that while driving at 60-70 MPH, the steering wheel turned to left and to the right independently. The traction control warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 220,000.

Filed May 15, 2025 · Steering · OH · crash

The electric power steering has failed on me numerous times. From being completely locked and having to restart the car 5 times just to free it up, to it locking up while i'm going 70 down the freeway multiple times. one of those times was while i was merging lanes and my wheel got locked slightly left and it sent me into the median wall, luckily no more damage than some missing paint and scratches but this is a problem that needs fixed. I searched my vin and there is no recall but it is the exact same make and model and has the exact same EPS issues the other 05 malibus do. what are my options before i get into a really bad accident because of this?

Filed Jan 2, 2025 · Steering · 103,000 miles · NJ

The contact owns a 2005 Chevrolet Malibu. The contact stated that while his daughter was driving at an undisclosed speed and attempting to complete a turn, he became aware that the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The message "Service Electronic Power Steering" was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. The electronic power steering warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 14V153000 (Steering); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 103,000.

Filed Apr 20, 2024 · Electrical, Steering · NE

Steering wheel shakes violently when the car is started. After awhile it goes out completely making it extrememly dangerous to steer or turn while driving. Took it to a dealer in norfolk, ne, norfolk gm service center, and they said recall was fixed back in 2014 at a shop in hartington, ne. Same issue immediaitly happened again. Issue is not fixed and car remains unsafe for travel.