October 7, 2026 this vehicle hydroplaned and I lost control of the vehicle. To the best of my knowledge, the steering wheel locked and when attempted to step on the brakes, no braking occurred. The vehicle slid into grass which then hit the guard railing on the interstate. After being inspected by collision shop techs, they have reason to believe the airbag sensor defected or was not installed to signal the airbags to deploy. The driver side door panel airbag did attempt to deploy but was unsuccessful.
Chevrolet Malibu steering lock-up problems
667 of the 19,367 owner complaints about the Chevrolet Malibu describe steering wheel locks up, most of them for the 2006 model year.
- owner complaints
- 667
- worst model year
- 2006
- typical repair cost reported
- $1,000
- typical mileage
- 98,000
Is there a fix? There are 3 recalls for this area of the car. See below
By model year
Often reported together
Engine failure 255Power steering loss 54Check engine light 29Jerking 23Loss of power 22Stalling 20Warning lights 15Steering noise 10
Trouble codes mentioned
U0121 1C0900 1C0661 1C0545 1
What owners say
The esc light came on, air conditioner fan speed went high then low and my screen flickered out momentarily. The esc light came on three more times, 10-15 seconds each time with no lights remaining on after and no other changes. The next time I drove, when turning the esc light came on and the steering locked up for about 5 seconds
i was driving and the steering wheel locked, the whole steering column has to be replaced it brought up a code saying torque input sensor i've only put 10,000 miles on this car and have only had it for 11 months
The steering locked up when the brakes were pressed and the steering wheel was turned to avoid crashing with another car. The result is the crash happened and damage to both cars. Thankfully traffic was only going around 10 mph. If this had happened at high speed my son may have been seriously injured or even killed. The mechanic is working on it now and has reported the power steering module and power steering motor has to be replaced.
My car has about 82000 miles and while driving it stated that I was shifted to neutral and needed to be restarted. After a few seconds the steering wheel locks up and I can’t press the gas anymore, even though the car is still in drive. This happened about 6 times on the half mile drive home. I haven’t been able to diagnose it yet since the dealership is backed up for a month. I think it’s the neutral safety switch
The contact owns a 2016 Chevrolet Malibu. The contact stated that while his daughter was driving at approximately 30 MPH, the vehicle came to a stop. After coming from the stop, the steering wheel seized. Several unknown warning lights were illuminated. The contact’s daughter crashed the vehicle into a utility pole and a utility box. The air bags deployed. The contact’s daughter was transported to the hospital by ambulance and treated for a concussion and seat belt-related bruising on her chest and waist. A police report was filed. The vehicle was towed to a tow yard, but the insurance company was not yet notified of the accident. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
Steering locks while driving
We own this vehicle with 147,xxx miles on it. There was extended warranty coverage of 10-years or 150,000 miles for the power steering position sensor and torque sensor, all part of the electronic stability control system the bulletin is 15356. A very costly repair that could result in a crash if a driver has the steering wheel lock up while driving. Zero help from GM because the period has "expired." I feel it should be covered since it is under the 150k mileage.
The contact owns a 2011 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the power steering failed to function as intended. The Electronic Stability Control warning light illuminated, and the steering wheel seized. In addition, the contact stated that the steering wheel was difficult to turn. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure. The contact was made aware of Special Coverage Program: 15356; however, the contact was informed that the repair was not covered under the program. Additionally, the contact was informed of NHSTA Campaign Number: 14V252000 (Electrical System, Exterior Lightening, Vehicle Speed Control, Electronic Stability Control (ESC); however, the VIN was not included in the recall. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 180,000.
I brought car told dealer of air bag light on to service and tire monitor light I had my steering lock and ESC light on dealership did nothing to comply to safety of this called don't return calls
Related recalls
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or Pontiac customer service at 1‑800‑762‑2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V‑153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Recall number 15V064000 · Recall details
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1‑800‑630‑2438, Saturn at 1‑800‑553‑6000, and Pontiac at 1‑800‑620‑7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Recall number 14V153000 · Recall details
Steering: rack and pinion
- What is wrong
- Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These retainers could fail and permit the ball bearings to escape.
- Risk
- If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. If the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. With the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. In any of these conditions, a crash could occur.
- Remedy
- Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began on february 5, 2004. Owners should contact buick at 1‑866‑608‑8080; chevrolet at 1‑800‑630‑2438; oldsmobile at 1‑800‑630‑6537; or pontiac at 1‑800‑620‑7668.
Recall number 03V527000 · Recall details
Questions about the Chevrolet Malibu steering lock-up
Which Chevrolet Malibu years have steering wheel locks up problems?
The model years with the most reports are 2006 (118 complaints), 2004 (98 complaints) and 2007 (90 complaints).
How much does it cost to fix steering wheel locks up on the Chevrolet Malibu?
Owners who mentioned a price put the repair at about $1,000 (median of 16 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Malibu?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history