Lost power steering after making a left hand 90 deg. turn
Chevrolet Malibu power steering loss problems
1,596 of the 19,367 owner complaints about the Chevrolet Malibu describe loss of power steering, most of them for the 2004 model year.
- owner complaints
- 1,596
- worst model year
- 2004
- typical repair cost reported
- $864
- typical mileage
- 97,000
Is there a fix? There are 3 recalls for this area of the car. See below
By model year
Often reported together
Loss of power 460Jerking 57Steering lock-up 54Check engine light 48Stalling 44Engine failure 25Steering noise 22Headlights 21
Trouble codes mentioned
C0545 7C0460 2B1325 2U2143 1U1510 1U0422 1U0420 1U0164 1U0121 1P2097 1
What owners say
The contact owns a 2008 Chevrolet Malibu. The contact stated that while driving 35 MPH, several warning lights flashed on the instrument panel, and the contact stated that there was heat coming from the vehicle. The contact stated that the electrical gauges flickered. While attempting to pull off the roadway, the power steering assist failed to operate as needed, and the brake pedal became firm. The contact stated that prior to the failure, a mechanic had discovered a minor oil leak coming from the engine. The contact called an independent mechanic who arrived at the scene and inspected the vehicle. The mechanic was unable to determine the cause of the failure. The vehicle was driven to the residence, and the vehicle shut off upon arriving at the destination. The contact attempted to restart the vehicle several times after the failure; however, the vehicle failed to restart. The dealer was notified of the failure, and the contact was informed that there were no recalls associated with the VIN. Upon investigation, the contact discovered the federal safety agency Campaign Number: 14V530000 (Electrical System). The failure mileage was approximately 100,000.
My power steering went out while pulling out of a parking spot. The message read “power steering/service ESC. I have read that these vehicles between the years 2007-2012 had a recall for this issue. My car has less than 46000 miles on it. I am confirming the recall so I can have this repair done. Thank you
Power steering assist motor is out and it was under recall in 2011 but it was out of the recall window but it has less than 150000 miles
My 2020 Chevrolet Malibu experienced a sudden and severe electrical failure after driving through normal roadway water. Immediately afterward, the vehicle displayed multiple safety‑critical warnings including loss of power steering assist, Electronic Stability Control (ESC) faults, brake control faults, and reduced propulsion. A GM dealership inspected the vehicle, scanned the modules, and found more than a dozen network and chassis‑related diagnostic trouble codes, including: B3979, U0164, B1325, B3122, U0121, C0196, C0460, B1011, B097B, B3205, C056E, C056D, U0420, U1510, C0545, U0422. These codes indicate failures in the steering system, brake control module, stability control system, body control module, and multiple CAN‑bus communication networks. The dealership confirmed: – No physical damage – No evidence of collision or impact – No evidence of flood damage – The suspected failed component is the electric power steering rack (GM part 85621696) – The part is not available, meaning the vehicle cannot be repaired – I would be responsible for diagnostic and repair costs This is a major safety concern. The vehicle can lose steering assist, stability control, and braking support without warning. The inability to obtain the required steering component makes the vehicle unrepairable and unsafe to operate. I am reporting this because this appears to be a systemic electrical/network failure affecting critical safety systems. I believe this defect poses a significant risk to drivers, passengers, and other motorists. The attached photo is a is a picture of the printout the Chevrolet dealership Service Manager provided to me.
The contact owns a 2010 Chevrolet Malibu. The contact stated that while driving 30 MPH, the steering wheel was shaking and locked up, and the steering wheel became difficult to turn. The vehicle lost power steering functionality. The power steering warning light was illuminated. A dealer or an independent mechanic was not contacted. The vehicle was not taken to an independent mechanic or dealer to be diagnosed. The manufacturer was notified of the failure, and the contact was informed that the warranty on the vehicle had expired. The approximate failure mileage was 146,000.
Everytime I turn on my car, I get a warning for ESC power steering and I have no power steering. Usually it will fix itself have shutting it off once and starting it again immediately. There has been a couple times where it has taken multiple starts to fix itself.
No power steering for 25min drive home. Next day it worked. Dealership said it had an expired recall for power steering fix. No work was done by dealership.
Power steering went out and I'm told it's a sensor that is in the steering column. Very expensive to have fixed due to location of the sensor. I seen a recall for this problem however it is only good for 150,000 miles or 10 years. I just purchased this car 2 years ago with 172,000 miles. This recall should still be valid if it hasn't been repaired. I almost wrecked the car not realizing this happened while driving.
The Powersteering is failing in my 2011 Chevrolet Malibu with 93K miles on it. The warning light on the dashboard appears randomly then it becomes difficult to steer. This has become a safety issue because when driving on the highway or trying to navigate turns requires a lot of strength and can be a hazard while driving in traffic or alone. I have taken the vehicle to an auto repair shop for a diagnostic and they were unable to fix it due to the Chevrolet dealership who no longer makes the part. I have researched and found that GM had a special coverage 15356 for this problem but no recall. The special coverage is now expired. I am not sure if it has been inspected by the manufacturer as I am the 2nd owner. The message that appears on the dashboard when there is a loss of power steering says ESC Power steering then it becomes difficult to steer. The problem started about 1 month ago.
Related recalls
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or Pontiac customer service at 1‑800‑762‑2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V‑153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Recall number 15V064000 · Recall details
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1‑800‑630‑2438, Saturn at 1‑800‑553‑6000, and Pontiac at 1‑800‑620‑7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Recall number 14V153000 · Recall details
Steering: rack and pinion
- What is wrong
- Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These retainers could fail and permit the ball bearings to escape.
- Risk
- If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. If the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. With the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. In any of these conditions, a crash could occur.
- Remedy
- Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began on february 5, 2004. Owners should contact buick at 1‑866‑608‑8080; chevrolet at 1‑800‑630‑2438; oldsmobile at 1‑800‑630‑6537; or pontiac at 1‑800‑620‑7668.
Recall number 03V527000 · Recall details
Questions about the Chevrolet Malibu power steering loss
Which Chevrolet Malibu years have loss of power steering problems?
The model years with the most reports are 2004 (280 complaints), 2009 (244 complaints) and 2006 (239 complaints).
How much does it cost to fix loss of power steering on the Chevrolet Malibu?
Owners who mentioned a price put the repair at about $864 (median of 115 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Malibu?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history