2012 Chevrolet Malibu: loss of power steering

Filed Mar 11, 2026 · Steering · OH

On March 4, 2026, my wife was driving the vehicle when she suddenly lost power steering. The steering wheel became extremely difficult to turn, creating a dangerous situation that could have resulted in serious injury. She was able to safely pull over and contact me. I carefully drove the vehicle home. The vehicle was taken to Jeff Wyler Chevrolet of Columbus for diagnosis and repair. The dealership confirmed that the problem involved the power steering system. The repair cost was $1,513.03. After researching the issue, I discovered that this 2012 Malibu is subject to a special coverage related to the steering torque sensor. General Motors had reportedly sent notification letters to owners, but we never received one. Had we been aware, we would have addressed the issue immediately. This defect represents a significant safety risk, as sudden loss of power steering could cause an accident or serious injury.

Filed Jan 13, 2026 · Driver assistance, Steering · 111,000 miles · IL

The contact owns a 2012 Chevrolet Malibu. The contact stated that the power steering warning light was illuminated, and the message "ESC OFF" was displayed. The contact stated that the vehicle experienced an intermittent loss of power steering while driving. The contact stated that upon restarting the vehicle, the vehicle operated as intended; however, the failure initially became a persistent failure upon restarting the vehicle and then became a permanent failure. The contact stated that upon taking the vehicle to an independent mechanic for a tire replacement, the contact was also informed that the steering failure was related to Chevrolet Special Coverage Number: 15356. The contact was referred to the dealer, who informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,000.

Filed Apr 24, 2025 · Transmission · DE

The problem started with the steering wheel jerking by itself then the power steering went out. The only way to get power steering back is to turn the car off then turn it back on while turning the steering wheel manually then it’s hard to say how long you have power steering for. To get it fixed is around 1,500 for a 3 hour job.

Filed Mar 26, 2025 · Electrical, Steering · OH

The power steering assist has cause the steering wheel to move to its let by its self when not holding the steering wheel. I must hold the steering wheel firmly to keep it strait when driving. If i would let go the car will abruptly turn left and possibly drive off the road or hit a car, pedestrian, or whatever is in the way. It started with uncontrolled vibrating at a stand still motion. The car is 165,000 miles that's 15,000 miles from the recall. The car has been repaired a couple times I think only to have the same power steering assist internal parts break down and fail multiple times. I believe the amount of power (amps) the power steering assist draws is needed is to much and the system fails within a short time. The alternative hydraulic version on the V 6 doesn't put so much stress on the electrical system. This could be also why the headlights bulb sockets melt and why I see a 15 volt constant charge is being created from the charging system. Ruining the alternator and battery. Putting high levels of amps on the wiring. Leading to malfunctioning components that is filed for complaints. A major safety hazard for others. Fires and uncontrolled crash since the power steering assist moves the car into dangerous life threating crashes.

Filed Mar 4, 2025 · Electrical, Steering · NH

Loss of power steering assist while driving. Safety issue puts driver and others at risk. Problem confirmed to be known by dealer service bulletin 15356. Special coverage has expired however many vehicles with issue still on the road. ESC light accompanies failure, restarting the vehicle resets system and allows function for short period until loss of steering while moving occurs again. Request GM extend the special coverage to all vehicles still in service or recall.

Filed Feb 21, 2025 · Steering · 130,000 miles · IL

The contact owns a 2012 Chevrolet Malibu. The contact stated that while his son was driving at an undisclosed speed, he became aware that the electronic power steering assist was not functioning properly, requiring an increased effort to maneuver the vehicle. The service power steering warning light was illuminated. The vehicle was taken to the dealer, who diagnosed failures with the power steering control module and power steering torque sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 15356; however, the vehicle had previously been repaired in 2019 and again in 2020, under the special coverage program. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 130,000.

Filed Jul 4, 2024 · Steering · NY

As I was driving my vehicle last Sunday the "Power Steering and the Service ESC" warnings came on my dashboard as well as the "Traction Control light" I audible sound came on and I lost power steering. When I went to drive my car to my service station everything worked fine for a few blocks the problem came back. I drove it to my local service mechanic and his scan tool gave an error code of CO545. I did some research on this issue and found that GM put out a Special Coverage #15356 for the power steering sensor. This coverage expired in 2021 however my vehicle did not have this problem until last week. My car only has 60,000 miles on it. Yesterday I took my vehicle to the GM dealer that I purchased my vehicle from and the said I have to pay $200.00 for them to diagnose the problem (which I understand) but the service writer told me that GM will probably not replace the parts needed because their "Special Coverage" expired in 2021. I am asking if the government can force GM to recall. I thank God that my wife nor my daughter was not driving the vehicle when this happened or they may have been hurt or worse fighting the steering wheel to keep the car going straight until I could stop it saftly.

Filed Jan 31, 2024 · Steering · IA

I Was driving and my power steering went out. I got it home turned it on and the power steering came back but the wheel keeps twitching. Tried to start it again and the power steering was out again.

Filed Sep 22, 2023 · Steering · IL

Attempting to pull out of my parking lot, I was suddenly unable to steer my car. Immediately warning lights went on in the dashboard the car would not move. Luckily, I was not in the middle of the street or driving down the highway as I would have lost control of the vehicle. I had the car towed to Meineke and they reported that the power steering assist motor had failed. Prior to the incident, no warning signs had come on in my car.

Filed Jul 28, 2023 · Electrical, Steering · CA

While I was making a right turn, I experienced a sudden loss of steering, the steering wheel became completely stiff and almost imposible to maneuver. The panel message was Service EPS and ESC off. According to information in this website, there was a special warranty extension, which expired on 2022, which covered this specific issue (the problem is related to the electric power steering assist (EPS), the steering column torque sensor or the EPS motor/controller). The special warranty code was 15356. I have taken my car to the dealership in the past for maintenance and other safety recalls, but I was not alerted about this very dangerous issue. I called GM today, and they said I was not alerted because this was not a recall but an extended warranty. This sounds like a lack of due diligence on GM´s end to address an issue that is extremely dangerous. I am now afraid to drive this car.

Filed Jul 28, 2022 · Steering · 71,000 miles · MO

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle lost power steering functionality. The vehicle was restarted and worked as designed. The service ESC power steering message was displayed. The traction control warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that the steering column and steering control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified via email but there was no response. The contact stated that the failure was similar to the federal safety agency Campaign Number: 14E044000 (Steering). The approximate failure mileage was 71,000.

Filed Jul 11, 2022 · Steering · 118,472 miles · MO

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 118,472.